IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v234y2021ics0360544221015061.html
   My bibliography  Save this article

Investigating the potential of the slurry technology for sustainable pig farm heating

Author

Listed:
  • Blázquez, Cristina Sáez
  • Borge-Diez, David
  • Nieto, Ignacio Martín
  • Maté-González, Miguel Ángel
  • Martín, Arturo Farfán
  • González-Aguilera, Diego

Abstract

Sustainable energy development in the farming sector is an essential strategy to respond the combined challenge of achieving a reliable and affordable solution but including mitigation and adaptation to climate change. Intensive breeding farms require maintaining an adequate indoor thermal environment that results in high energy demands, usually covered by fossil fuels and electricity. This paper addresses the application of the combined slurry technology for a particular pig farm that currently uses a diesel boiler to supply the piglet heating energy needs. The study also considers different options based on closed ground source heat pump systems. After the design of the slurry alternative and the geothermal ones, notable advantages are detected compared to the existing diesel system. Results show that the implementation of the slurry technology implies an important reduction of the operational costs, which, in turn, involves short amortization periods for this system in relation to the diesel one. Greenhouse gases emissions are also highly reduced in the slurry alternative based on the low electricity use of the heat pump. The environmental side is reinforced by the reduction of polluting substances such as methane of ammonia derived from the descent of temperature of the slurry.

Suggested Citation

  • Blázquez, Cristina Sáez & Borge-Diez, David & Nieto, Ignacio Martín & Maté-González, Miguel Ángel & Martín, Arturo Farfán & González-Aguilera, Diego, 2021. "Investigating the potential of the slurry technology for sustainable pig farm heating," Energy, Elsevier, vol. 234(C).
    • Handle: RePEc:eee:energy:v:234:y:2021:i:c:s0360544221015061
    DOI: 10.1016/j.energy.2021.121258
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544221015061
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2021.121258?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Borge-Diez, David & Colmenar-Santos, Antonio & Pérez-Molina, Clara & López-Rey, África, 2015. "Geothermal source heat pumps under energy services companies finance scheme to increase energy efficiency and production in stockbreeding facilities," Energy, Elsevier, vol. 88(C), pages 821-836.
    2. Alberti, Luca & Antelmi, Matteo & Angelotti, Adriana & Formentin, Giovanni, 2018. "Geothermal heat pumps for sustainable farm climatization and field irrigation," Agricultural Water Management, Elsevier, vol. 195(C), pages 187-200.
    3. Kythreotou, Nicoletta & Florides, Georgios & Tassou, Savvas A., 2012. "A proposed methodology for the calculation of direct consumption of fossil fuels and electricity for livestock breeding, and its application to Cyprus," Energy, Elsevier, vol. 40(1), pages 226-235.
    4. Pulat, Erhan & Coskun, Salih & Unlu, Kursat & Yamankaradeniz, Nurettin, 2009. "Experimental study of horizontal ground source heat pump performance for mild climate in Turkey," Energy, Elsevier, vol. 34(9), pages 1284-1295.
    5. Yang, Weibo & Shi, Mingheng & Liu, Guangyuan & Chen, Zhenqian, 2009. "A two-region simulation model of vertical U-tube ground heat exchanger and its experimental verification," Applied Energy, Elsevier, vol. 86(10), pages 2005-2012, October.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Cristina Sáez Blázquez & David Borge-Diez & Ignacio Martín Nieto & Miguel Ángel Maté-González & Arturo Farfán Martín & Diego González-Aguilera, 2022. "Geothermal Heat Pumps for Slurry Cooling and Farm Heating: Impact and Carbon Footprint Reduction in Pig Farms," Sustainability, MDPI, vol. 14(10), pages 1-17, May.
    2. Alberti, Luca & Antelmi, Matteo & Angelotti, Adriana & Formentin, Giovanni, 2018. "Geothermal heat pumps for sustainable farm climatization and field irrigation," Agricultural Water Management, Elsevier, vol. 195(C), pages 187-200.
    3. Ozyurt, Omer & Ekinci, Dundar Arif, 2011. "Experimental study of vertical ground-source heat pump performance evaluation for cold climate in Turkey," Applied Energy, Elsevier, vol. 88(4), pages 1257-1265, April.
    4. Sebarchievici, Calin & Sarbu, Ioan, 2015. "Performance of an experimental ground-coupled heat pump system for heating, cooling and domestic hot-water operation," Renewable Energy, Elsevier, vol. 76(C), pages 148-159.
    5. Ioan Sarbu & Calin Sebarchievici, 2016. "Performance Evaluation of Radiator and Radiant Floor Heating Systems for an Office Room Connected to a Ground-Coupled Heat Pump," Energies, MDPI, vol. 9(4), pages 1-19, March.
    6. Man, Yi & Yang, Hongxing & Wang, Jinggang & Fang, Zhaohong, 2012. "In situ operation performance test of ground coupled heat pump system for cooling and heating provision in temperate zone," Applied Energy, Elsevier, vol. 97(C), pages 913-920.
    7. Go, Gyu-Hyun & Lee, Seung-Rae & N.V., Nikhil & Yoon, Seok, 2015. "A new performance evaluation algorithm for horizontal GCHPs (ground coupled heat pump systems) that considers rainfall infiltration," Energy, Elsevier, vol. 83(C), pages 766-777.
    8. Ioan Sarbu & Calin Sebarchievici, 2020. "Exploratory Research to Improve Energy-Efficiency of a Ground-Coupled Heat Pump Utilizing an Automatic Control Device of Circulation Pump Speed," Energies, MDPI, vol. 13(19), pages 1-19, September.
    9. Aira, Roberto & Fernández-Seara, José & Diz, Rubén & Pardiñas, Ángel Á., 2017. "Experimental analysis of a ground source heat pump in a residential installation after two years in operation," Renewable Energy, Elsevier, vol. 114(PB), pages 1214-1223.
    10. Bakirci, Kadir & Colak, Derya, 2012. "Effect of a superheating and sub-cooling heat exchanger to the performance of a ground source heat pump system," Energy, Elsevier, vol. 44(1), pages 996-1004.
    11. Zhang, Linfeng & Zhang, Quan & Huang, Gongsheng, 2016. "A transient quasi-3D entire time scale line source model for the fluid and ground temperature prediction of vertical ground heat exchangers (GHEs)," Applied Energy, Elsevier, vol. 170(C), pages 65-75.
    12. Barkat Rabbi & Zhong-Hua Chen & Subbu Sethuvenkatraman, 2019. "Protected Cropping in Warm Climates: A Review of Humidity Control and Cooling Methods," Energies, MDPI, vol. 12(14), pages 1-24, July.
    13. Antonio Colmenar-Santos & Elisabet Palomo-Torrejón & Enrique Rosales-Asensio & David Borge-Diez, 2018. "Measures to Remove Geothermal Energy Barriers in the European Union," Energies, MDPI, vol. 11(11), pages 1-29, November.
    14. Hannah Licharz & Peter Rösmann & Manuel S. Krommweh & Ehab Mostafa & Wolfgang Büscher, 2020. "Energy Efficiency of a Heat Pump System: Case Study in Two Pig Houses," Energies, MDPI, vol. 13(3), pages 1-20, February.
    15. Van linden, Veerle & Herman, Lieve, 2014. "A fuel consumption model for off-road use of mobile machinery in agriculture," Energy, Elsevier, vol. 77(C), pages 880-889.
    16. Blum, Philipp & Campillo, Gisela & Kölbel, Thomas, 2011. "Techno-economic and spatial analysis of vertical ground source heat pump systems in Germany," Energy, Elsevier, vol. 36(5), pages 3002-3011.
    17. Atwany, Hanin & Hamdan, Mohammad O. & Abu-Nabah, Bassam A. & Alami, Abdul Hai & Attom, Mousa, 2020. "Experimental evaluation of ground heat exchanger in UAE," Renewable Energy, Elsevier, vol. 159(C), pages 538-546.
    18. Kung, Chih-Chun & Lan, Xiaolong & Yang, Yunxia & Kung, Shan-Shan & Chang, Meng-Shiuh, 2022. "Effects of green bonds on Taiwan's bioenergy development," Energy, Elsevier, vol. 238(PA).
    19. Badescu, Viorel & Isvoranu, Dragos, 2011. "Pneumatic and thermal design procedure and analysis of earth-to-air heat exchangers of registry type," Applied Energy, Elsevier, vol. 88(4), pages 1266-1280, April.
    20. Weidong Lyu & Hefu Pu & Jiannan (Nick) Chen, 2020. "Thermal Performance of an Energy Pile Group with a Deeply Penetrating U-Shaped Heat Exchanger," Energies, MDPI, vol. 13(21), pages 1-17, November.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:234:y:2021:i:c:s0360544221015061. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.