IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v228y2021ics0360544221008343.html
   My bibliography  Save this article

Experimental measurements for Polish lignite combustion in a 1 MWth circulating fluidized bed during load changes

Author

Listed:
  • Alobaid, Falah
  • Peters, Jens
  • Epple, Bernd

Abstract

The conventional design of circulating fluidized beds mainly focuses on high process efficiency, while electricity markets increasingly target operating flexibility due to the increased penetration of renewable energy sources. In this work, the operational flexibility of the CFB furnace when applied to compensate for the feed-in fluctuations from renewable energies has been investigated experimentally. Employing a 1 MWth CFB test facility, Polish lignite was combusted over a wide range of transient operating conditions. The profiles of temperatures and pressures along the riser, the flue gas concentration and the temperature developments in the bed zone, and the outlet of the cyclone that identify the basis for operational flexibility and scale-up studies were shown. It was found that the circulating fluidized bed furnace can be operated with higher positive and negative load change rates up to ±25%/min, maintaining high combustion efficiency and low emissions. Furthermore, the temperature distribution along the riser was almost homogeneous at higher loads. By reducing the load, the temperature difference in the bed zone and after the cyclone was decreased and heterogeneous temperature distribution along the riser can be observed, resulting in a slight decrease in the combustion efficiency.

Suggested Citation

  • Alobaid, Falah & Peters, Jens & Epple, Bernd, 2021. "Experimental measurements for Polish lignite combustion in a 1 MWth circulating fluidized bed during load changes," Energy, Elsevier, vol. 228(C).
    • Handle: RePEc:eee:energy:v:228:y:2021:i:c:s0360544221008343
    DOI: 10.1016/j.energy.2021.120585
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544221008343
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2021.120585?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Kayahan, Ufuk & Özdoğan, Sibel, 2016. "Oxygen enriched combustion and co-combustion of lignites and biomass in a 30 kWth circulating fluidized bed," Energy, Elsevier, vol. 116(P1), pages 317-328.
    2. Sanchez, M.E. & Otero, M. & Gómez, X. & Morán, A., 2009. "Thermogravimetric kinetic analysis of the combustion of biowastes," Renewable Energy, Elsevier, vol. 34(6), pages 1622-1627.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Mahapatro, Abinash & Mahanta, Pinakeswar & Jana, Kuntal, 2019. "Hydrodynamic study of low-grade Indian coal and sawdust as bed inventory in a pressurized circulating fluidized bed," Energy, Elsevier, vol. 189(C).
    2. Jayaraman, Kandasamy & Kok, Mustafa Versan & Gokalp, Iskender, 2017. "Thermogravimetric and mass spectrometric (TG-MS) analysis and kinetics of coal-biomass blends," Renewable Energy, Elsevier, vol. 101(C), pages 293-300.
    3. Bujak, Janusz Wojciech, 2015. "New insights into waste management – Meat industry," Renewable Energy, Elsevier, vol. 83(C), pages 1174-1186.
    4. Zhenghui Xu & Xiang Xiao & Ping Fang & Lyumeng Ye & Jianhang Huang & Haiwen Wu & Zijun Tang & Dongyao Chen, 2020. "Comparison of Combustion and Pyrolysis Behavior of the Peanut Shells in Air and N 2 : Kinetics, Thermodynamics and Gas Emissions," Sustainability, MDPI, vol. 12(2), pages 1-14, January.
    5. Fidalgo, B. & Chilmeran, M. & Somorin, T. & Sowale, A. & Kolios, A. & Parker, A. & Williams, L. & Collins, M. & McAdam, E.J. & Tyrrel, S., 2019. "Non-isothermal thermogravimetric kinetic analysis of the thermochemical conversion of human faeces," Renewable Energy, Elsevier, vol. 132(C), pages 1177-1184.
    6. Engin, Berrin & Kayahan, Ufuk & Atakül, Hüsnü, 2020. "A comparative study on the air, the oxygen-enriched air and the oxy-fuel combustion of lignites in CFB," Energy, Elsevier, vol. 196(C).
    7. João Silva & Senhorinha Teixeira & José Teixeira, 2023. "A Review of Biomass Thermal Analysis, Kinetics and Product Distribution for Combustion Modeling: From the Micro to Macro Perspective," Energies, MDPI, vol. 16(18), pages 1-23, September.
    8. Liu, Jingxin & Huang, Simian & Wang, Teng & Mei, Meng & Chen, Si & Zhang, Wenjuan & Li, Jinping, 2021. "Evaluation on thermal treatment for sludge from the liquid digestion of restaurant food waste," Renewable Energy, Elsevier, vol. 179(C), pages 179-188.
    9. Havukainen, J. & Uusitalo, V. & Niskanen, A. & Kapustina, V. & Horttanainen, M., 2014. "Evaluation of methods for estimating energy performance of biogas production," Renewable Energy, Elsevier, vol. 66(C), pages 232-240.
    10. Lelis Gonzaga Fraga & João Silva & Senhorinha Teixeira & Delfim Soares & Manuel Ferreira & José Teixeira, 2020. "Influence of Operating Conditions on the Thermal Behavior and Kinetics of Pine Wood Particles Using Thermogravimetric Analysis," Energies, MDPI, vol. 13(11), pages 1-22, June.
    11. Zacharczuk, Wojciech & Andruszkiewicz, Artur & Tatarek, Andrzej & Alahmer, Ali & Alsaqoor, Sameh, 2021. "Effect of Ca-based additives on the capture of SO2 during combustion of pulverized lignite," Energy, Elsevier, vol. 231(C).
    12. Ma, Jinxing & Wang, Zhiwei & Zhu, Chaowei & Xu, Yinlun & Wu, Zhichao, 2014. "Electrogenesis reduces the combustion efficiency of sewage sludge," Applied Energy, Elsevier, vol. 114(C), pages 283-289.
    13. Na Xu & Mifen Cui & Zhuxiu Zhang & Jihai Tang & Xu Qiao, 2022. "Quest for the Co-Pyrolysis Behavior of Rice Husk and Cresol Distillation Residue: Interaction, Gas Evolution and Kinetics," Energies, MDPI, vol. 15(6), pages 1-13, March.
    14. Chen, Chunxiang & Ma, Xiaoqian & Liu, Kai, 2011. "Thermogravimetric analysis of microalgae combustion under different oxygen supply concentrations," Applied Energy, Elsevier, vol. 88(9), pages 3189-3196.
    15. Sergio Suárez & Jose Guillermo Rosas & Marta Elena Sánchez & Roberto López & Natalia Gómez & Jorge Cara-Jiménez, 2019. "Parametrization of a Modified Friedman Kinetic Method to Assess Vine Wood Pyrolysis Using Thermogravimetric Analysis," Energies, MDPI, vol. 12(13), pages 1-14, July.
    16. Niu, Shengli & Yu, Hewei & Zhao, Shuang & Zhang, Xiangyu & Li, Ximing & Han, Kuihua & Lu, Chunmei & Wang, Yongzheng, 2019. "Apparent kinetic and thermodynamic calculation for thermal degradation of stearic acid and its esterification derivants through thermogravimetric analysis," Renewable Energy, Elsevier, vol. 133(C), pages 373-381.
    17. Lai, ZhiYi & Ma, XiaoQian & Tang, YuTing & Lin, Hai, 2011. "A study on municipal solid waste (MSW) combustion in N2/O2 and CO2/O2 atmosphere from the perspective of TGA," Energy, Elsevier, vol. 36(2), pages 819-824.
    18. Coimbra, Ricardo N. & Paniagua, Sergio & Escapa, Carla & Calvo, Luis F. & Otero, Marta, 2015. "Combustion of primary and secondary pulp mill sludge and their respective blends with coal: A thermogravimetric assessment," Renewable Energy, Elsevier, vol. 83(C), pages 1050-1058.
    19. Li, Y. & Zhou, L.W. & Wang, R.Z., 2017. "Urban biomass and methods of estimating municipal biomass resources," Renewable and Sustainable Energy Reviews, Elsevier, vol. 80(C), pages 1017-1030.
    20. Aleksandra Petrovič & Sabina Vohl & Tjaša Cenčič Predikaka & Robert Bedoić & Marjana Simonič & Irena Ban & Lidija Čuček, 2021. "Pyrolysis of Solid Digestate from Sewage Sludge and Lignocellulosic Biomass: Kinetic and Thermodynamic Analysis, Characterization of Biochar," Sustainability, MDPI, vol. 13(17), pages 1-34, August.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:228:y:2021:i:c:s0360544221008343. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.