IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v147y2020ip1p1511-1524.html
   My bibliography  Save this article

Scenario analysis of implementing a power-to-gas and biomass gasification system in an integrated steel plant: A techno-economic and environmental study

Author

Listed:
  • Rosenfeld, Daniel C.
  • Böhm, Hans
  • Lindorfer, Johannes
  • Lehner, Markus

Abstract

Since the European Union's target a domestic greenhouse gas emission reduction of 80% till 2050, as compared to the value of 1990 (European Commission, 2011), there has been an increasing interest in greening large industrial processes. Thus, gas greening and alternative emission reduction processes are gaining importance. In this study, a gas greening system for an integrated steel plant, producing synthetic natural gas serving as a substitute for the fossil fuel-based gas, was investigated. The analysed system consisted of a Power-to-Gas unit combined with a biomass gasification plant, where carbon rich steel gases were used as a CO2 source for methanation. To analyse the system, three extreme value scenarios and three constrained scenarios were defined and evaluated. The biomass gasification plant, set to a maximum nominal power of 105 MWth, was the main limiting factor for the constrained scenarios. The assessment included a basic mass and energy balance, techno-economic analysis, sensitivity analysis, and CO2 potential impact analysis. It was found that the main cost influencing factor throughout all six scenarios was the energy supply cost (electricity and biomass).

Suggested Citation

  • Rosenfeld, Daniel C. & Böhm, Hans & Lindorfer, Johannes & Lehner, Markus, 2020. "Scenario analysis of implementing a power-to-gas and biomass gasification system in an integrated steel plant: A techno-economic and environmental study," Renewable Energy, Elsevier, vol. 147(P1), pages 1511-1524.
    • Handle: RePEc:eee:renene:v:147:y:2020:i:p1:p:1511-1524
    DOI: 10.1016/j.renene.2019.09.053
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148119313837
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2019.09.053?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Uribe-Soto, Wilmar & Portha, Jean-François & Commenge, Jean-Marc & Falk, Laurent, 2017. "A review of thermochemical processes and technologies to use steelworks off-gases," Renewable and Sustainable Energy Reviews, Elsevier, vol. 74(C), pages 809-823.
    2. Fuchs, Josef & Schmid, Johannes Christian & Benedikt, Florian & Müller, Stefan & Hofbauer, Hermann & Stocker, Hugo & Kieberger, Nina & Bürgler, Thomas, 2018. "The impact of bed material cycle rate on in-situ CO2 removal for sorption enhanced reforming of different fuel types," Energy, Elsevier, vol. 162(C), pages 35-44.
    3. Marshall, A. & Børresen, B. & Hagen, G. & Tsypkin, M. & Tunold, R., 2007. "Hydrogen production by advanced proton exchange membrane (PEM) water electrolysers—Reduced energy consumption by improved electrocatalysis," Energy, Elsevier, vol. 32(4), pages 431-436.
    4. Bailera, Manuel & Lisbona, Pilar, 2018. "Energy storage in Spain: Forecasting electricity excess and assessment of power-to-gas potential up to 2050," Energy, Elsevier, vol. 143(C), pages 900-910.
    5. Antonio Molino & Vincenzo Larocca & Simeone Chianese & Dino Musmarra, 2018. "Biofuels Production by Biomass Gasification: A Review," Energies, MDPI, vol. 11(4), pages 1-31, March.
    6. Kotowicz, Janusz & Węcel, Daniel & Jurczyk, Michał, 2018. "Analysis of component operation in power-to-gas-to-power installations," Applied Energy, Elsevier, vol. 216(C), pages 45-59.
    7. Parra, David & Zhang, Xiaojin & Bauer, Christian & Patel, Martin K., 2017. "An integrated techno-economic and life cycle environmental assessment of power-to-gas systems," Applied Energy, Elsevier, vol. 193(C), pages 440-454.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Ahlström, Johan M. & Walter, Viktor & Göransson, Lisa & Papadokonstantakis, Stavros, 2022. "The role of biomass gasification in the future flexible power system – BECCS or CCU?," Renewable Energy, Elsevier, vol. 190(C), pages 596-605.
    2. Jorge Perpiñán & Manuel Bailera & Luis M. Romeo & Begoña Peña & Valerie Eveloy, 2021. "CO 2 Recycling in the Iron and Steel Industry via Power-to-Gas and Oxy-Fuel Combustion," Energies, MDPI, vol. 14(21), pages 1-15, October.
    3. Song, Weiming & Zhou, Jianan & Li, Yujie & Li, Shu & Yang, Jian, 2021. "Utilization of waste tire powder for gaseous fuel generation via CO2 gasification using waste heat in converter vaporization cooling flue," Renewable Energy, Elsevier, vol. 173(C), pages 283-296.
    4. Kim, Dongin & Han, Jeehoon, 2020. "Techno-economic and climate impact analysis of carbon utilization process for methanol production from blast furnace gas over Cu/ZnO/Al2O3 catalyst," Energy, Elsevier, vol. 198(C).
    5. Böhm, Hans & Zauner, Andreas & Rosenfeld, Daniel C. & Tichler, Robert, 2020. "Projecting cost development for future large-scale power-to-gas implementations by scaling effects," Applied Energy, Elsevier, vol. 264(C).
    6. Sébastien Pissot & Henrik Thunman & Peter Samuelsson & Martin Seemann, 2021. "Production of Negative-Emissions Steel Using a Reducing Gas Derived from DFB Gasification," Energies, MDPI, vol. 14(16), pages 1-32, August.
    7. Michael Bampaou & Kyriakos Panopoulos & Panos Seferlis & Amaia Sasiain & Stephane Haag & Philipp Wolf-Zoellner & Markus Lehner & Leokadia Rog & Przemyslaw Rompalski & Sebastian Kolb & Nina Kieberger &, 2022. "Economic Evaluation of Renewable Hydrogen Integration into Steelworks for the Production of Methanol and Methane," Energies, MDPI, vol. 15(13), pages 1-26, June.
    8. Perpiñán, Jorge & Bailera, Manuel & Peña, Begoña & Romeo, Luis M. & Eveloy, Valerie, 2023. "Technical and economic assessment of iron and steelmaking decarbonization via power to gas and amine scrubbing," Energy, Elsevier, vol. 276(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Lewandowska-Bernat, Anna & Desideri, Umberto, 2018. "Opportunities of power-to-gas technology in different energy systems architectures," Applied Energy, Elsevier, vol. 228(C), pages 57-67.
    2. Bailera, Manuel & Peña, Begoña & Lisbona, Pilar & Romeo, Luis M., 2018. "Decision-making methodology for managing photovoltaic surplus electricity through Power to Gas: Combined heat and power in urban buildings," Applied Energy, Elsevier, vol. 228(C), pages 1032-1045.
    3. Valerie Eveloy & Tesfaldet Gebreegziabher, 2018. "A Review of Projected Power-to-Gas Deployment Scenarios," Energies, MDPI, vol. 11(7), pages 1-52, July.
    4. Kim, Dongin & Han, Jeehoon, 2020. "Techno-economic and climate impact analysis of carbon utilization process for methanol production from blast furnace gas over Cu/ZnO/Al2O3 catalyst," Energy, Elsevier, vol. 198(C).
    5. Vo, Truc T.Q. & Rajendran, Karthik & Murphy, Jerry D., 2018. "Can power to methane systems be sustainable and can they improve the carbon intensity of renewable methane when used to upgrade biogas produced from grass and slurry?," Applied Energy, Elsevier, vol. 228(C), pages 1046-1056.
    6. Uchman, Wojciech & Skorek-Osikowska, Anna & Jurczyk, Michał & Węcel, Daniel, 2020. "The analysis of dynamic operation of power-to-SNG system with hydrogen generator powered with renewable energy, hydrogen storage and methanation unit," Energy, Elsevier, vol. 213(C).
    7. Yoshida, Akira & Nakazawa, Hiroto & Kenmotsu, Naoki & Amano, Yoshiharu, 2022. "Economic analysis of a proton exchange membrane electrolyser cell for hydrogen supply scenarios in Japan," Energy, Elsevier, vol. 251(C).
    8. Li, Yanxue & Gao, Weijun & Ruan, Yingjun, 2019. "Potential and sensitivity analysis of long-term hydrogen production in resolving surplus RES generation—a case study in Japan," Energy, Elsevier, vol. 171(C), pages 1164-1172.
    9. Böhm, Hans & Zauner, Andreas & Rosenfeld, Daniel C. & Tichler, Robert, 2020. "Projecting cost development for future large-scale power-to-gas implementations by scaling effects," Applied Energy, Elsevier, vol. 264(C).
    10. Xiang Huang & Yapan Qu & Zhentao Zhu & Qiuchi Wu, 2023. "Techno-Economic Analysis of Photovoltaic Hydrogen Production Considering Technological Progress Uncertainty," Sustainability, MDPI, vol. 15(4), pages 1-29, February.
    11. Andrea Di Giuliano & Stefania Lucantonio & Katia Gallucci, 2021. "Devolatilization of Residual Biomasses for Chemical Looping Gasification in Fluidized Beds Made Up of Oxygen-Carriers," Energies, MDPI, vol. 14(2), pages 1-16, January.
    12. Andrade, Carlos & Selosse, Sandrine & Maïzi, Nadia, 2022. "The role of power-to-gas in the integration of variable renewables," Applied Energy, Elsevier, vol. 313(C).
    13. Christoph Sejkora & Johannes Lindorfer & Lisa Kühberger & Thomas Kienberger, 2021. "Interlinking the Renewable Electricity and Gas Sectors: A Techno-Economic Case Study for Austria," Energies, MDPI, vol. 14(19), pages 1-38, October.
    14. Richard P. van Leeuwen & Annelies E. Boerman & Edmund W. Schaefer & Gerwin Hoogsteen & Yashar S. Hajimolana, 2022. "Model Supported Business Case Scenario Analysis for Decentral Hydrogen Conversion, Storage and Consumption within Energy Hubs," Energies, MDPI, vol. 15(6), pages 1-22, March.
    15. Michael Bampaou & Kyriakos Panopoulos & Panos Seferlis & Spyridon Voutetakis & Ismael Matino & Alice Petrucciani & Antonella Zaccara & Valentina Colla & Stefano Dettori & Teresa Annunziata Branca & Vi, 2021. "Integration of Renewable Hydrogen Production in Steelworks Off-Gases for the Synthesis of Methanol and Methane," Energies, MDPI, vol. 14(10), pages 1-24, May.
    16. Auguadra, Marco & Ribó-Pérez, David & Gómez-Navarro, Tomás, 2023. "Planning the deployment of energy storage systems to integrate high shares of renewables: The Spain case study," Energy, Elsevier, vol. 264(C).
    17. Munawar, Muhammad Assad & Khoja, Asif Hussain & Naqvi, Salman Raza & Mehran, Muhammad Taqi & Hassan, Muhammad & Liaquat, Rabia & Dawood, Usama Fida, 2021. "Challenges and opportunities in biomass ash management and its utilization in novel applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 150(C).
    18. Cox, Brian & Bauer, Christian & Mendoza Beltran, Angelica & van Vuuren, Detlef P. & Mutel, Christopher L., 2020. "Life cycle environmental and cost comparison of current and future passenger cars under different energy scenarios," Applied Energy, Elsevier, vol. 269(C).
    19. Fischer, David & Kaufmann, Florian & Hollinger, Raphael & Voglstätter, Christopher, 2018. "Real live demonstration of MPC for a power-to-gas plant," Applied Energy, Elsevier, vol. 228(C), pages 833-842.
    20. Mo, Jingke & Kang, Zhenye & Yang, Gaoqiang & Retterer, Scott T. & Cullen, David A. & Toops, Todd J. & Green, Johney B. & Zhang, Feng-Yuan, 2016. "Thin liquid/gas diffusion layers for high-efficiency hydrogen production from water splitting," Applied Energy, Elsevier, vol. 177(C), pages 817-822.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:147:y:2020:i:p1:p:1511-1524. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.