IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v284y2023ics0360544223027196.html
   My bibliography  Save this article

Optimum design of bivariate operation strategy for a supercritical/ transcritical CO2 hybrid waste heat recovery system driven by gas turbine exhaust

Author

Listed:
  • Cao, Yue
  • Zhan, Jun
  • Jia, Boqing
  • Chen, Ranjing
  • Si, Fengqi

Abstract

Gas turbines are always operated under part-load conditions to participate in the frequency regulation of power grids; therefore, the exhaust gas has fluctuating temperature and mass flow rate parameters. For better utilization of the waste heat in gas turbine exhaust under part-load conditions, a supercritical/transcritical carbon dioxide (CO2) hybrid waste heat recovery system with different operation strategies was studied. The turbine inlet pressure and mass flow rate were considered as the dominant factors affecting the system part-load performance, which formed a bivariate operation strategy. A solution procedure was proposed to optimize the bivariate operation strategy for a hybrid waste heat recovery system. The results indicate that the mass flow rate of the transcritical CO2 cycle has a greater effect on its net power than the turbine inlet pressure whereas these two regulation variables should be controlled cooperatively. The net power of the hybrid waste heat recovery system increased with an increase in the inlet valve opening of the supercritical CO2 turbine under a specific gas turbine load. Generally, the optimal bivariate operation strategy has the advantage of enhancing the part-load performance of a hybrid waste heat recovery system driven by gas turbine exhaust.

Suggested Citation

  • Cao, Yue & Zhan, Jun & Jia, Boqing & Chen, Ranjing & Si, Fengqi, 2023. "Optimum design of bivariate operation strategy for a supercritical/ transcritical CO2 hybrid waste heat recovery system driven by gas turbine exhaust," Energy, Elsevier, vol. 284(C).
    • Handle: RePEc:eee:energy:v:284:y:2023:i:c:s0360544223027196
    DOI: 10.1016/j.energy.2023.129325
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544223027196
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2023.129325?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Cao, Yue & Rattner, Alexander S. & Dai, Yiping, 2018. "Thermoeconomic analysis of a gas turbine and cascaded CO2 combined cycle using thermal oil as an intermediate heat-transfer fluid," Energy, Elsevier, vol. 162(C), pages 1253-1268.
    2. Li, Bo & Wang, Shun-sen, 2022. "Thermodynamic analysis and optimization of a hybrid cascade supercritical carbon dioxide cycle for waste heat recovery," Energy, Elsevier, vol. 259(C).
    3. Xingyan, Bian & Wang, Xuan & Wang, Rui & Cai, Jinwen & Tian, Hua & Shu, Gequn, 2022. "Optimal selection of supercritical CO2 Brayton cycle layouts based on part-load performance," Energy, Elsevier, vol. 256(C).
    4. Li, Ligeng & Tian, Hua & Shi, Lingfeng & Wang, Jingyu & Li, Min & Shu, Gequn, 2021. "Adaptive flow assignment for CO2 transcritical power cycle (CTPC): An engine operational profile-based off-design study," Energy, Elsevier, vol. 225(C).
    5. Wang, Mingtao & Zhang, Juan & Liu, Huanwei, 2022. "Thermodynamic analysis and optimization of two low-grade energy driven transcritical CO2 combined cooling, heating and power systems," Energy, Elsevier, vol. 249(C).
    6. Li, Ligeng & Tian, Hua & Shi, Lingfeng & Zhang, Yonghao & Huang, Guangdai & Zhang, Hongfei & Wang, Xuan & Shu, Gequn, 2022. "Experimental investigation of a splitting CO2 transcritical power cycle in engine waste heat recovery," Energy, Elsevier, vol. 244(PB).
    7. Zhou, Aozheng & Li, Xue-song & Ren, Xiao-dong & Gu, Chun-wei, 2020. "Improvement design and analysis of a supercritical CO2/transcritical CO2 combined cycle for offshore gas turbine waste heat recovery," Energy, Elsevier, vol. 210(C).
    8. Wang, Zhe & Jiang, Yuemao & Ma, Yue & Han, Fenghui & Ji, Yulong & Cai, Wenjian, 2022. "A partial heating supercritical CO2 nested transcritical CO2 cascade power cycle for marine engine waste heat recovery: Thermodynamic, economic, and footprint analysis," Energy, Elsevier, vol. 261(PA).
    9. Wang, Wenyi & Zhao, Zhongfan & Zhou, Qun & Qiao, Yiyuan & Cao, Feng, 2021. "Model predictive control for the operation of a transcritical CO2 air source heat pump water heater," Applied Energy, Elsevier, vol. 300(C).
    10. Liese, Eric & Albright, Jacob & Zitney, Stephen A., 2020. "Startup, shutdown, and load-following simulations of a 10 MWe supercritical CO2 recompression closed Brayton cycle," Applied Energy, Elsevier, vol. 277(C).
    11. Fan, Gang & Du, Yang & Li, Hang & Dai, Yiping, 2021. "Off-design behavior investigation of the combined supercritical CO2 and organic Rankine cycle," Energy, Elsevier, vol. 237(C).
    12. Du, Yadong & Yang, Ce & Zhao, Ben & Gao, Jianbing & Hu, Chenxing & Zhang, Hanzhi & Zhao, Wei, 2022. "Dynamic characteristics of a recompression supercritical CO2 cycle against variable operating conditions and temperature fluctuations of reactor outlet coolant," Energy, Elsevier, vol. 258(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Jiang, Yuemao & Ma, Yue & Han, Fenghui & Ji, Yulong & Cai, Wenjian & Wang, Zhe, 2023. "Assessment and optimization of a novel waste heat stepped utilization system integrating partial heating sCO2 cycle and ejector refrigeration cycle using zeotropic mixtures for gas turbine," Energy, Elsevier, vol. 265(C).
    2. Sreekanth Manavalla & Feroskhan M. & Joseph Daniel & Sivakumar Ramasamy & T. M. Yunus Khan & Rahmath Ulla Baig & Naif Almakayeel & Bhanu Kiran Voddin Tirumalapur, 2023. "System Design, Optimization and 2nd Law Analysis of a 100 MWe Double Reheat s-CO 2 Power Plant at Full Load and Part Loads," Sustainability, MDPI, vol. 15(20), pages 1-19, October.
    3. Li, Bo & Wang, Shun-sen, 2022. "Thermodynamic analysis and optimization of a hybrid cascade supercritical carbon dioxide cycle for waste heat recovery," Energy, Elsevier, vol. 259(C).
    4. Lu, Bowen & Zhang, Zhifu & Cai, Jinwen & Wang, Wei & Ju, Xueming & Xu, Yao & Lu, Xun & Tian, Hua & Shi, Lingfeng & Shu, Gequn, 2023. "Integrating engine thermal management into waste heat recovery under steady-state design and dynamic off-design conditions," Energy, Elsevier, vol. 272(C).
    5. Du, Yadong & Yang, Ce & Zhao, Ben & Gao, Jianbing & Hu, Chenxing & Zhang, Hanzhi & Zhao, Wei, 2022. "Dynamic characteristics of a recompression supercritical CO2 cycle against variable operating conditions and temperature fluctuations of reactor outlet coolant," Energy, Elsevier, vol. 258(C).
    6. Ehsan, M. Monjurul & Awais, Muhammad & Lee, Sangkyoung & Salehin, Sayedus & Guan, Zhiqiang & Gurgenci, Hal, 2023. "Potential prospects of supercritical CO2 power cycles for commercialisation: Applicability, research status, and advancement," Renewable and Sustainable Energy Reviews, Elsevier, vol. 172(C).
    7. Ma, Ning & Meng, Fugui & Hong, Wenpeng & Li, Haoran & Niu, Xiaojuan, 2023. "Thermodynamic assessment of the dry-cooling supercritical Brayton cycle in a direct-heated solar power tower plant enabled by CO2-propane mixture," Renewable Energy, Elsevier, vol. 203(C), pages 649-663.
    8. Yang, Wei & Bao, Jingjing & Liu, Hongtao & Zhang, Jun & Guo, Lin, 2023. "Low-grade heat to hydrogen: Current technologies, challenges and prospective," Renewable and Sustainable Energy Reviews, Elsevier, vol. 188(C).
    9. Maria Alessandra Ancona & Michele Bianchi & Lisa Branchini & Andrea De Pascale & Francesco Melino & Antonio Peretto & Noemi Torricelli, 2021. "Systematic Comparison of ORC and s-CO 2 Combined Heat and Power Plants for Energy Harvesting in Industrial Gas Turbines," Energies, MDPI, vol. 14(12), pages 1-22, June.
    10. He, Jintao & Shi, Lingfeng & Tian, Hua & Wang, Xuan & Zhang, Yonghao & Zhang, Meiyan & Yao, Yu & Cai, Jinwen & Shu, Gequn, 2022. "Control strategy for a CO2-based combined cooling and power generation system based on heat source and cold sink fluctuations," Energy, Elsevier, vol. 257(C).
    11. Yuhui Xiao & Yuan Zhou & Yuan Yuan & Yanping Huang & Gengyuan Tian, 2023. "Research Advances in the Application of the Supercritical CO 2 Brayton Cycle to Reactor Systems: A Review," Energies, MDPI, vol. 16(21), pages 1-23, October.
    12. Zhou, Aozheng & Li, Xue-song & Ren, Xiao-dong & Gu, Chun-wei, 2020. "Improvement design and analysis of a supercritical CO2/transcritical CO2 combined cycle for offshore gas turbine waste heat recovery," Energy, Elsevier, vol. 210(C).
    13. Fei Teng & Qing Zhang & Tao Zou & Jun Zhu & Yonggang Tu & Qian Feng, 2022. "Energy Management Strategy for Seaport Integrated Energy System under Polymorphic Network," Sustainability, MDPI, vol. 15(1), pages 1-22, December.
    14. Li, Zhi & Wang, Lei & Jiang, Ruicheng & Wang, Bingzheng & Yu, Xiaonan & Huang, Rui & Yu, Xiaoli, 2022. "Experimental investigations on dynamic performance of organic Rankine cycle integrated with latent thermal energy storage under transient engine conditions," Energy, Elsevier, vol. 246(C).
    15. He, Yu-Jia & Tai, Ying-Di & Fakrouche, Nassim & Zhang, Chun-Lu, 2023. "Applicability evaluation of internal heat exchanger in CO2 transcritical cycle considering compressor operation boundaries," Applied Energy, Elsevier, vol. 349(C).
    16. Wu, Pengzhi & Liu, Changchun & Wen, Hu & Luo, Zhenmin & Fan, Shixing & Mi, Wansheng, 2023. "Experimental investigation of jet impingement during accidental release of liquid CO2," Energy, Elsevier, vol. 279(C).
    17. Dingchen Wu & Mingshan Wei & Ran Tian & Siyu Zheng & Jundi He, 2022. "A Review of Flow and Heat Transfer Characteristics of Supercritical Carbon Dioxide under Cooling Conditions in Energy and Power Systems," Energies, MDPI, vol. 15(23), pages 1-28, November.
    18. Kazemiani-Najafabadi, Parisa & Amiri Rad, Ehsan, 2021. "Multi-objective optimization of a novel offshore CHP plant based on a 3E analysis," Energy, Elsevier, vol. 224(C).
    19. Zhang, Lianjie & Deng, Tianrui & Klemeš, Jiří Jaromír & Zeng, Min & Ma, Ting & Wang, Qiuwang, 2021. "Supercritical CO2 Brayton cycle at different heat source temperatures and its analysis under leakage and disturbance conditions," Energy, Elsevier, vol. 237(C).
    20. Zhang, Xuanang & Wang, Xuan & Cai, Jinwen & Wang, Rui & Bian, Xingyan & He, Zhaoxian & Tian, Hua & Shu, Gequn, 2023. "Operation strategy of a multi-mode Organic Rankine cycle system for waste heat recovery from engine cooling water," Energy, Elsevier, vol. 263(PE).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:284:y:2023:i:c:s0360544223027196. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.