IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v241y2025ics0960148125000035.html
   My bibliography  Save this article

Boosting wet yeast-based biodiesel production by in-situ transesterification using a novel acid-base bifunctional carbon-based catalyst derived from spent coffee ground and cement residue

Author

Listed:
  • Fiala, Khanittha
  • Rublaim, Angsumalee
  • Leesing, Ratanaporn

Abstract

Production of yeast-based biodiesel using waste-derived catalyst correlates with the sustainable development concept. For this goal, a novel waste-derived acid-base bifunctional carbon-based catalyst, SCG@CR-SC, was generated from spent coffee ground and cement residue by wet impregnation and direct hydrothermal sulfonation, and their catalytic ability was evaluated for enhancing biodiesel production from SCO-rich wet cell of Rhodotorula sp. KKU-WP2 (SCO-RWP2) through wet in-situ transesterification (W-ISTE). The SCG@CR-SC characteristic underwent comprehensive analysis through FE-SEM-EDX, FTIR, XRD, Raman, and TGA techniques, confirming the successful introduction of CaO and sulfonic (–SO3H) groups on the SCG@CR-SC surface. SCG@CR-SC exhibited good catalytic efficiency for producing SCO-RWP2-biodiesel under optimized W-ISTE conditions (3.0 wt% catalyst amount, 15:1 MeOH/SCO-RWP2 ratio, 65 °C for 1.0 h), reaching 96.9 % (1st cycle), 89.9 % (4th cycle) and >93 % (regenerated catalyst) of FAME conversion yield, surpassing results reported for similar studies. Notably, the estimated fuel properties of SCO-RWP2-biodiesel were correlated well with the requirements for ASTM D6751 and EN 14,214 international standards, representing great application prospects. The findings underscore the potential of using SCO-RWP2 as a promising feedstock and SCG@CR-SC as an eco-friendly catalyst for boosting biodiesel production, that might mitigate environmental concerns and promote the sustainable development of clean and renewable energy.

Suggested Citation

  • Fiala, Khanittha & Rublaim, Angsumalee & Leesing, Ratanaporn, 2025. "Boosting wet yeast-based biodiesel production by in-situ transesterification using a novel acid-base bifunctional carbon-based catalyst derived from spent coffee ground and cement residue," Renewable Energy, Elsevier, vol. 241(C).
    • Handle: RePEc:eee:renene:v:241:y:2025:i:c:s0960148125000035
    DOI: 10.1016/j.renene.2025.122341
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148125000035
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2025.122341?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Niakan, Mahsa & Masteri-Farahani, Majid & Seidi, Farzad, 2022. "Efficient glucose-to-HMF conversion in deep eutectic solvents over sulfonated dendrimer modified activated carbon," Renewable Energy, Elsevier, vol. 200(C), pages 1134-1140.
    2. Sun, Xianke & Xu, Liuyang & Yuan, Honglei & Wang, Gaoliang & Maleki, Basir, 2024. "Boosted conversion of restaurant waste oil into biodiesel using Fe3O4@UiO-66-NH2 magnetic heterogeneous nanocatalyst and its application on the diesel engine: Optimization via RSM," Renewable Energy, Elsevier, vol. 223(C).
    3. Tan, Yie Hua & Abdullah, Mohammad Omar & Kansedo, Jibrail & Mubarak, Nabisab Mujawar & Chan, Yen San & Nolasco-Hipolito, Cirilo, 2019. "Biodiesel production from used cooking oil using green solid catalyst derived from calcined fusion waste chicken and fish bones," Renewable Energy, Elsevier, vol. 139(C), pages 696-706.
    4. Leesing, Ratanaporn & Siwina, Siraprapha & Ngernyen, Yuvarat & Fiala, Khanittha, 2022. "Innovative approach for co-production of single cell oil (SCO), novel carbon-based solid acid catalyst and SCO-based biodiesel from fallen Dipterocarpus alatus leaves," Renewable Energy, Elsevier, vol. 185(C), pages 47-60.
    5. Akinfalabi, Shehu-Ibrahim & Rashid, Umer & Yunus, Robiah & Taufiq-Yap, Yun Hin, 2017. "Synthesis of biodiesel from palm fatty acid distillate using sulfonated palm seed cake catalyst," Renewable Energy, Elsevier, vol. 111(C), pages 611-619.
    6. Saikia, Kankana & Das, Arpita & Sema, Atoholi H. & Basumatary, Sanjay & Shaemningwar Moyon, N. & Mathimani, Thangavel & Rokhum, Samuel Lalthazuala, 2024. "Response surface optimization, kinetics, thermodynamics, and life cycle cost analysis of biodiesel production from Jatropha curcas oil using biomass-based functional activated carbon catalyst," Renewable Energy, Elsevier, vol. 229(C).
    7. Battista, Federico & Zanzoni, Serena & Strazzera, Giuseppe & Andreolli, Marco & Bolzonella, David, 2020. "The cascade biorefinery approach for the valorization of the spent coffee grounds," Renewable Energy, Elsevier, vol. 157(C), pages 1203-1211.
    8. Ao, Supongsenla & Changmai, Bishwajit & Vanlalveni, Chhangte & Chhandama, Michael Van Lal & Wheatley, Andrew E.H. & Rokhum, Samuel Lalthazuala, 2024. "Biomass waste-derived catalysts for biodiesel production: Recent advances and key challenges," Renewable Energy, Elsevier, vol. 223(C).
    9. Leesing, Ratanaporn & Somdee, Theerasak & Siwina, Siraprapha & Ngernyen, Yuvarat & Fiala, Khanittha, 2022. "Production of 2G and 3G biodiesel, yeast oil, and sulfonated carbon catalyst from waste coconut meal: An integrated cascade biorefinery approach," Renewable Energy, Elsevier, vol. 199(C), pages 1093-1104.
    10. Perumal, Govindhan, 2024. "Production of biodiesel from waste cooking oil using a novel surface-functionalized CaMoO4/ TiO2 solid catalyst," Renewable Energy, Elsevier, vol. 228(C).
    11. Efe, Şükran & Ceviz, Mehmet Akif & Temur, Hakan, 2018. "Comparative engine characteristics of biodiesels from hazelnut, corn, soybean, canola and sunflower oils on DI diesel engine," Renewable Energy, Elsevier, vol. 119(C), pages 142-151.
    12. Mendaros, Czarina M. & Go, Alchris W. & Nietes, Winston Jose T. & Gollem, Babe Eden Joy O. & Cabatingan, Luis K., 2020. "Direct sulfonation of cacao shell to synthesize a solid acid catalyst for the esterification of oleic acid with methanol," Renewable Energy, Elsevier, vol. 152(C), pages 320-330.
    13. Siwina, Siraprapha & Leesing, Ratanaporn, 2021. "Bioconversion of durian (Durio zibethinus Murr.) peel hydrolysate into biodiesel by newly isolated oleaginous yeast Rhodotorula mucilaginosa KKUSY14," Renewable Energy, Elsevier, vol. 163(C), pages 237-245.
    14. Marinković, Dalibor M. & Stanković, Miroslav V. & Veličković, Ana V. & Avramović, Jelena M. & Miladinović, Marija R. & Stamenković, Olivera O. & Veljković, Vlada B. & Jovanović, Dušan M., 2016. "Calcium oxide as a promising heterogeneous catalyst for biodiesel production: Current state and perspectives," Renewable and Sustainable Energy Reviews, Elsevier, vol. 56(C), pages 1387-1408.
    15. Robles-Iglesias, Raúl & Naveira-Pazos, Cecilia & Fernández-Blanco, Carla & Veiga, María C. & Kennes, Christian, 2023. "Factors affecting the optimisation and scale-up of lipid accumulation in oleaginous yeasts for sustainable biofuels production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 171(C).
    16. Leesing, Ratanaporn & Siwina, Siraprapha & Fiala, Khanittha, 2021. "Yeast-based biodiesel production using sulfonated carbon-based solid acid catalyst by an integrated biorefinery of durian peel waste," Renewable Energy, Elsevier, vol. 171(C), pages 647-657.
    17. Lani, Nurul Saadiah & Ngadi, Norzita & Haron, Saharudin & Mohammed Inuwa, Ibrahim & Anako Opotu, Lawal, 2024. "The catalytic effect of calcium oxide and magnetite loading on magnetically supported calcium oxide-zeolite catalyst for biodiesel production from used cooking oil," Renewable Energy, Elsevier, vol. 222(C).
    18. Patel, Alok & Arora, Neha & Mehtani, Juhi & Pruthi, Vikas & Pruthi, Parul A., 2017. "Assessment of fuel properties on the basis of fatty acid profiles of oleaginous yeast for potential biodiesel production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 77(C), pages 604-616.
    19. Aisien, Felix Aibuedefe & Aisien, Eki Tina, 2023. "Modeling and optimization of transesterification of rubber seed oil using sulfonated CaO derived from giant African land snail (Achatina fulica) catalyst by response surface methodology," Renewable Energy, Elsevier, vol. 207(C), pages 137-146.
    20. Yuan, Zong & Zhu, Jishen & Lu, Jie & Li, Yueyun & Ding, Jincheng, 2024. "Preparation of biodiesel by transesterification of castor oil catalyzed by flaky halloysite supported ZnO/SnO2 heterojunction photocatalyst," Renewable Energy, Elsevier, vol. 227(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Leesing, Ratanaporn & Siwina, Siraprapha & Ngernyen, Yuvarat & Fiala, Khanittha, 2022. "Innovative approach for co-production of single cell oil (SCO), novel carbon-based solid acid catalyst and SCO-based biodiesel from fallen Dipterocarpus alatus leaves," Renewable Energy, Elsevier, vol. 185(C), pages 47-60.
    2. Leesing, Ratanaporn & Somdee, Theerasak & Siwina, Siraprapha & Ngernyen, Yuvarat & Fiala, Khanittha, 2022. "Production of 2G and 3G biodiesel, yeast oil, and sulfonated carbon catalyst from waste coconut meal: An integrated cascade biorefinery approach," Renewable Energy, Elsevier, vol. 199(C), pages 1093-1104.
    3. Leesing, Ratanaporn & Siwina, Siraprapha & Fiala, Khanittha, 2021. "Yeast-based biodiesel production using sulfonated carbon-based solid acid catalyst by an integrated biorefinery of durian peel waste," Renewable Energy, Elsevier, vol. 171(C), pages 647-657.
    4. Ingryd Mayer Krinski & Vinícius Reisdorfer Leite & Luis Mauro Moura & Viviana Cocco Mariani, 2025. "Critical Extraction Parameters for Maximizing Oil Yield from Spent Coffee Grounds," Energies, MDPI, vol. 18(6), pages 1-17, March.
    5. Zhang, Gaoqiang & Xie, Wenlei & Guo, Lihong, 2024. "Application of metal organic frameworks ZIF-8-based solid catalyst with hierarchical porous structure and Brønsted-Lewis dual acid sites ionic liquids for sustainable biodiesel production from acidic ," Renewable Energy, Elsevier, vol. 237(PC).
    6. Zhao, Man & Wang, Yanan & Zhou, Wenting & Zhou, Wei & Gong, Zhiwei, 2023. "Co-valorization of crude glycerol and low-cost substrates via oleaginous yeasts to micro-biodiesel: Status and outlook," Renewable and Sustainable Energy Reviews, Elsevier, vol. 180(C).
    7. Chuengcharoenphanich, Nuttha & Watsuntorn, Wannapawn & Qi, Wei & Wang, Zhongming & Hu, Yunzi & Chulalaksananukul, Warawut, 2023. "The potential of biodiesel production from grasses in Thailand through consolidated bioprocessing using a cellulolytic oleaginous yeast, Cyberlindnera rhodanensis CU-CV7," Energy, Elsevier, vol. 263(PB).
    8. Gadore, Vishal & Mishra, Soumya Ranjan & Roy, Saptarshi & Ahmaruzzaman, Md., 2024. "Highly potent novel SnS2/Zeolite (SFAZ) photocatalyst: An eco-friendly and sustainable strategy for producing biodiesel," Renewable Energy, Elsevier, vol. 234(C).
    9. Mansir, Nasar & Teo, Siow Hwa & Rashid, Umer & Saiman, Mohd Izham & Tan, Yen Ping & Alsultan, G. Abdulkareem & Taufiq-Yap, Yun Hin, 2018. "Modified waste egg shell derived bifunctional catalyst for biodiesel production from high FFA waste cooking oil. A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 82(P3), pages 3645-3655.
    10. Czekała, Wojciech & Łukomska, Aleksandra & Pulka, Jakub & Bojarski, Wiktor & Pochwatka, Patrycja & Kowalczyk-Juśko, Alina & Oniszczuk, Anna & Dach, Jacek, 2023. "Waste-to-energy: Biogas potential of waste from coffee production and consumption," Energy, Elsevier, vol. 276(C).
    11. Sivaramakrishnan, Ramachandran & Suresh, Subramaniyam & Incharoensakdi, Aran, 2023. "Improvement of methyl ester and itaconic acid production utilizing biorefinery approach on Scenedesmus sp," Renewable Energy, Elsevier, vol. 215(C).
    12. Tie, Xinlong & Li, Yun & Yuan, Kai & Tan, Zhengxin & Liu, Yitian & Liu, Jiang & Wang, Hongyan & Zhang, Chengjia & Wan, Yuanzhe & Zou, Chong & Wang, Tielin & Feng, Weiliang & Duan, Xiaoling, 2025. "Functionalized chitosan-derived porous carbon as a promising catalyst in one-pot conversion of soybean oil to biodiesel," Renewable Energy, Elsevier, vol. 245(C).
    13. Zhang, Xingyilong & Lu, Houfang & Wu, Kejing & Liu, Yingying & Wu, Jian & Zhu, Yingming & Liang, Bin, 2024. "Synergistic activation of hydroxyl groups by hierarchical acid sites and deep eutectic solvents for the dehydration of fructose to 5-hydroxymethylfurfural under mild temperature," Renewable Energy, Elsevier, vol. 233(C).
    14. Yesilyurt, Murat Kadir & Eryilmaz, Tanzer & Arslan, Mevlüt, 2018. "A comparative analysis of the engine performance, exhaust emissions and combustion behaviors of a compression ignition engine fuelled with biodiesel/diesel/1-butanol (C4 alcohol) and biodiesel/diesel/," Energy, Elsevier, vol. 165(PB), pages 1332-1351.
    15. Shunli Feng & Yihan Guo & Yulu Ran & Qingzhuoma Yang & Xiyue Cao & Huahao Yang & Yu Cao & Qingrui Xu & Dairong Qiao & Hui Xu & Yi Cao, 2023. "Production of Microbial Lipids by Saitozyma podzolica Zwy2-3 Using Corn Straw Hydrolysate, the Analysis of Lipid Composition, and the Prediction of Biodiesel Properties," Energies, MDPI, vol. 16(18), pages 1-22, September.
    16. Dar, Rouf Ahmad & Tsui, To-Hung & Zhang, Le & Tong, Yen Wah & Sharon, Sigal & Shoseyov, Oded & Liu, Ronghou, 2024. "Fermentation of organic wastes through oleaginous microorganisms for lipid production - Challenges and opportunities," Renewable and Sustainable Energy Reviews, Elsevier, vol. 195(C).
    17. Yu, Hewei & Cao, Yunlong & Li, Heyao & Zhao, Gaiju & Zhang, Xingyu & Cheng, Shen & Wei, Wei, 2021. "An efficient heterogeneous acid catalyst derived from waste ginger straw for biodiesel production," Renewable Energy, Elsevier, vol. 176(C), pages 533-542.
    18. Sooraj Kumar & Suhail Ahmed Soomro & Khanji Harijan & Mohammad Aslam Uqaili & Laveet Kumar, 2023. "Advancements of Biochar-Based Catalyst for Improved Production of Biodiesel: A Comprehensive Review," Energies, MDPI, vol. 16(2), pages 1-20, January.
    19. Goh, Brandon Han Hoe & Ong, Hwai Chyuan & Cheah, Mei Yee & Chen, Wei-Hsin & Yu, Kai Ling & Mahlia, Teuku Meurah Indra, 2019. "Sustainability of direct biodiesel synthesis from microalgae biomass: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 107(C), pages 59-74.
    20. Ko, Ja Kyong & Lee, Jae Hoon & Jung, Je Hyeong & Lee, Sun-Mi, 2020. "Recent advances and future directions in plant and yeast engineering to improve lignocellulosic biofuel production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:241:y:2025:i:c:s0960148125000035. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.