IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v172y2021icp239-250.html
   My bibliography  Save this article

Design and performance evaluation of an inclined nozzle and combustor of a downdraft moving bed gasifier for tar reduction

Author

Listed:
  • Rahman, Md Mashiur
  • Aravindakshan, Sreejith
  • Matin, Md Abdul

Abstract

Tar formation is one of the major problems during biomass gasification due to blocking and fouling processes in engines and turbines. Downstream gas cleanup process and conditioning are required to eliminate tar issues. For this reason, methods to reduce tar formation inside the gasifier are gaining more attention. In this work, a novel design for an inclined nozzle and a combustor was proposed and tested in a low-tar biomass (LTB) gasifier to evaluate the effect on tar reduction. The design process was based on a swirling flow created by an inclined nozzle that allows good mixing between pyrolysis gases and gasifying air. The swirl combustor created large internal annular and reverse flow zones with the help of swirl flow. Thus, the combustor had a positive effect on the combustion of the mixture of air and pyrolysis gases and induced thermal cracking in the partial oxidation zone. Recycling ratio (recycle gas/air, v/v) and combustion degree of volatiles were used to evaluate the performance of the inclined nozzle and combustor. The result showed that the tar yields in pyrolysis and partial oxidation zones were on average 1693 mg/Nm3 and 255 mg/Nm3, respectively which accounted for a reduction of 86.6% and 12.7% tar compounds in these zones, respectively. Besides, the producer gas leaving the gasifier had a tar content below 1%, and measured tar content was 7.4-27.14 mg/Nm3 for the tested biomass with moisture contents of 9–34%. Tar removal efficiency was found on average 84.9% after passing the pyrolysis gas through the partial oxidation zone, whereas tar in the producer gas was removed with an efficiency of 99.1% at the gas outlet zone. At an equivalence ratio of 0.35, the new design had the optimal performance with a recycling ratio of 0.35 and combustion degree of volatiles of 98.6%. The achieved producer gas could be directly fed to an internal combustion engine or a gas turbine at small to medium level power generation in remote rural off-grid areas.

Suggested Citation

  • Rahman, Md Mashiur & Aravindakshan, Sreejith & Matin, Md Abdul, 2021. "Design and performance evaluation of an inclined nozzle and combustor of a downdraft moving bed gasifier for tar reduction," Renewable Energy, Elsevier, vol. 172(C), pages 239-250.
    • Handle: RePEc:eee:renene:v:172:y:2021:i:c:p:239-250
    DOI: 10.1016/j.renene.2021.02.156
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148121003359
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2021.02.156?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Bhattacharya, S.C & Mizanur Rahman Siddique, A.H.Md & Pham, Hoang-Luong, 1999. "A study on wood gasification for low-tar gas production," Energy, Elsevier, vol. 24(4), pages 285-296.
    2. Park, Sung Jin & Son, Seong Hye & Kook, Jin Woo & Ra, Ho Won & Yoon, Sang Jun & Mun, Tae-Young & Moon, Ji Hong & Yoon, Sung Min & Kim, Jae Ho & Kim, Yong Ku & Lee, Jae Goo & Lee, Do-Yong & Seo, Myung , 2021. "Gasification operational characteristics of 20-tons-Per-Day rice husk fluidized-bed reactor," Renewable Energy, Elsevier, vol. 169(C), pages 788-798.
    3. Machin, Einara Blanco & Pedroso, Daniel Travieso & Proenza, Nestor & Silveira, José Luz & Conti, Leonetto & Braga, Lúcia Bollini & Machin, Adrian Blanco, 2015. "Tar reduction in downdraft biomass gasifier using a primary method," Renewable Energy, Elsevier, vol. 78(C), pages 478-483.
    4. Rahman, MD Mashiur & Henriksen, Ulrik Birk & Ahrenfeldt, Jesper & Arnavat, Maria Puig, 2020. "Design, construction and operation of a low-tar biomass (LTB) gasifier for power applications," Energy, Elsevier, vol. 204(C).
    5. Jiu Huang & Klaus Gerhard Schmidt & Zhengfu Bian, 2011. "Removal and Conversion of Tar in Syngas from Woody Biomass Gasification for Power Utilization Using Catalytic Hydrocracking," Energies, MDPI, vol. 4(8), pages 1-15, August.
    6. Zeng, Xi & Wang, Fang & Li, Hongling & Wang, Yin & Dong, Li & Yu, Jian & Xu, Guangwen, 2014. "Pilot verification of a low-tar two-stage coal gasification process with a fluidized bed pyrolyzer and fixed bed gasifier," Applied Energy, Elsevier, vol. 115(C), pages 9-16.
    7. Susastriawan, A.A.P. & Saptoadi, Harwin & Purnomo,, 2017. "Small-scale downdraft gasifiers for biomass gasification: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 76(C), pages 989-1003.
    8. Henriksen, Ulrik & Ahrenfeldt, Jesper & Jensen, Torben Kvist & Gøbel, Benny & Bentzen, Jens Dall & Hindsgaul, Claus & Sørensen, Lasse Holst, 2006. "The design, construction and operation of a 75kW two-stage gasifier," Energy, Elsevier, vol. 31(10), pages 1542-1553.
    9. Li, Chunshan & Suzuki, Kenzi, 2009. "Tar property, analysis, reforming mechanism and model for biomass gasification--An overview," Renewable and Sustainable Energy Reviews, Elsevier, vol. 13(3), pages 594-604, April.
    10. Al-attab, K.A. & Zainal, Z.A., 2011. "Design and performance of a pressurized cyclone combustor (PCC) for high and low heating value gas combustion," Applied Energy, Elsevier, vol. 88(4), pages 1084-1095, April.
    11. Baruah, Dipal & Baruah, D.C., 2014. "Modeling of biomass gasification: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 39(C), pages 806-815.
    12. S.D. Martinez-Boggio & S.S. Merola & P. Teixeira Lacava & A. Irimescu & P.L. Curto-Risso, 2019. "Effect of Fuel and Air Dilution on Syngas Combustion in an Optical SI Engine," Energies, MDPI, vol. 12(8), pages 1-23, April.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Vikram, Shruti & Deore, Sujeetkumar P. & De Blasio, Cataldo & Mahajani, Sanjay M. & Kumar, Sandeep, 2023. "Air gasification of high-ash solid waste in a pilot-scale downdraft gasifier: Experimental and numerical analysis," Energy, Elsevier, vol. 270(C).
    2. Álvarez-Bermúdez, César & Anca-Couce, Andrés & Chapela, Sergio & Scharler, Robert & Buchmayr, Markus & Gómez, Miguel Ángel & Porteiro, Jacobo, 2023. "Validation of a biomass conversion mechanism by Eulerian modelling of a fixed-bed system under low primary air conditions," Renewable Energy, Elsevier, vol. 215(C).
    3. Ghiwe, Suraj S. & Kalamkar, Vilas R. & Sharma, Sanjay K. & Sawarkar, Pravin D., 2023. "Numerical and experimental study on the performance of a hybrid draft biomass cookstove," Renewable Energy, Elsevier, vol. 205(C), pages 53-65.
    4. Silva, Isabelly P. & Lima, Rafael M.A. & Santana, Hortência E.P. & Silva, Gabriel F. & Ruzene, Denise S. & Silva, Daniel P., 2022. "Development of a semi-empirical model for woody biomass gasification based on stoichiometric thermodynamic equilibrium model," Energy, Elsevier, vol. 241(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Rahman, MD Mashiur & Henriksen, Ulrik Birk & Ahrenfeldt, Jesper & Arnavat, Maria Puig, 2020. "Design, construction and operation of a low-tar biomass (LTB) gasifier for power applications," Energy, Elsevier, vol. 204(C).
    2. Elsner, Witold & Wysocki, Marian & Niegodajew, Paweł & Borecki, Roman, 2017. "Experimental and economic study of small-scale CHP installation equipped with downdraft gasifier and internal combustion engine," Applied Energy, Elsevier, vol. 202(C), pages 213-227.
    3. Mehrpooya, Mehdi & Khalili, Maryam & Sharifzadeh, Mohammad Mehdi Moftakhari, 2018. "Model development and energy and exergy analysis of the biomass gasification process (Based on the various biomass sources)," Renewable and Sustainable Energy Reviews, Elsevier, vol. 91(C), pages 869-887.
    4. Li, Jian & Tao, Junyu & Yan, Beibei & Jiao, Liguo & Chen, Guanyi & Hu, Jianli, 2021. "Review of microwave-based treatments of biomass gasification tar," Renewable and Sustainable Energy Reviews, Elsevier, vol. 150(C).
    5. Tejasvi Sharma & Diego M. Yepes Maya & Francisco Regis M. Nascimento & Yunye Shi & Albert Ratner & Electo E. Silva Lora & Lourival Jorge Mendes Neto & Jose Carlos Escobar Palacios & Rubenildo Vieira A, 2018. "An Experimental and Theoretical Study of the Gasification of Miscanthus Briquettes in a Double-Stage Downdraft Gasifier: Syngas, Tar, and Biochar Characterization," Energies, MDPI, vol. 11(11), pages 1-23, November.
    6. Silva, Isabelly P. & Lima, Rafael M.A. & Santana, Hortência E.P. & Silva, Gabriel F. & Ruzene, Denise S. & Silva, Daniel P., 2022. "Development of a semi-empirical model for woody biomass gasification based on stoichiometric thermodynamic equilibrium model," Energy, Elsevier, vol. 241(C).
    7. Carlos Vargas-Salgado & Elías Hurtado-Pérez & David Alfonso-Solar & Anders Malmquist, 2021. "Empirical Design, Construction, and Experimental Test of a Small-Scale Bubbling Fluidized Bed Reactor," Sustainability, MDPI, vol. 13(3), pages 1-22, January.
    8. Yepes Maya, Diego Mauricio & Silva Lora, Electo Eduardo & Andrade, Rubenildo Vieira & Ratner, Albert & Martínez Angel, Juan Daniel, 2021. "Biomass gasification using mixtures of air, saturated steam, and oxygen in a two-stage downdraft gasifier. Assessment using a CFD modeling approach," Renewable Energy, Elsevier, vol. 177(C), pages 1014-1030.
    9. Ud Din, Zia & Zainal, Z.A., 2016. "Biomass integrated gasification–SOFC systems: Technology overview," Renewable and Sustainable Energy Reviews, Elsevier, vol. 53(C), pages 1356-1376.
    10. Machin, Einara Blanco & Pedroso, Daniel Travieso & Proenza, Nestor & Silveira, José Luz & Conti, Leonetto & Braga, Lúcia Bollini & Machin, Adrian Blanco, 2015. "Tar reduction in downdraft biomass gasifier using a primary method," Renewable Energy, Elsevier, vol. 78(C), pages 478-483.
    11. Susastriawan, A.A.P. & Saptoadi, Harwin & Purnomo,, 2017. "Small-scale downdraft gasifiers for biomass gasification: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 76(C), pages 989-1003.
    12. Sunil Thapa & Prakashbhai R. Bhoi & Ajay Kumar & Raymond L. Huhnke, 2017. "Effects of Syngas Cooling and Biomass Filter Medium on Tar Removal," Energies, MDPI, vol. 10(3), pages 1-12, March.
    13. Rakesh N, & Dasappa, S., 2018. "A critical assessment of tar generated during biomass gasification - Formation, evaluation, issues and mitigation strategies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 91(C), pages 1045-1064.
    14. Radenahmad, Nikdalila & Azad, Atia Tasfiah & Saghir, Muhammad & Taweekun, Juntakan & Bakar, Muhammad Saifullah Abu & Reza, Md Sumon & Azad, Abul Kalam, 2020. "A review on biomass derived syngas for SOFC based combined heat and power application," Renewable and Sustainable Energy Reviews, Elsevier, vol. 119(C).
    15. Silva, Isabelly P. & Lima, Rafael M.A. & Silva, Gabriel F. & Ruzene, Denise S. & Silva, Daniel P., 2019. "Thermodynamic equilibrium model based on stoichiometric method for biomass gasification: A review of model modifications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 114(C), pages 1-1.
    16. Zeng, Xi & Wang, Fang & Li, Hongling & Wang, Yin & Dong, Li & Yu, Jian & Xu, Guangwen, 2014. "Pilot verification of a low-tar two-stage coal gasification process with a fluidized bed pyrolyzer and fixed bed gasifier," Applied Energy, Elsevier, vol. 115(C), pages 9-16.
    17. Martínez, Juan Daniel & Mahkamov, Khamid & Andrade, Rubenildo V. & Silva Lora, Electo E., 2012. "Syngas production in downdraft biomass gasifiers and its application using internal combustion engines," Renewable Energy, Elsevier, vol. 38(1), pages 1-9.
    18. Raman, P. & Ram, N.K., 2013. "Performance analysis of an internal combustion engine operated on producer gas, in comparison with the performance of the natural gas and diesel engines," Energy, Elsevier, vol. 63(C), pages 317-333.
    19. Raman, P. & Ram, N.K. & Gupta, Ruchi, 2013. "A dual fired downdraft gasifier system to produce cleaner gas for power generation: Design, development and performance analysis," Energy, Elsevier, vol. 54(C), pages 302-314.
    20. Pereira, Emanuele Graciosa & da Silva, Jadir Nogueira & de Oliveira, Jofran L. & Machado, Cássio S., 2012. "Sustainable energy: A review of gasification technologies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 16(7), pages 4753-4762.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:172:y:2021:i:c:p:239-250. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.