IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v304y2024ics0360544224018784.html

Design and operation of an adiabatic compressed air energy storage system incorporating a detailed heat exchanger model

Author

Listed:
  • Ma, Linrui
  • Zhang, Xuelin
  • Zhang, Tong
  • Xue, Xiaodai
  • Chen, Xiaotao
  • Si, Yang

Abstract

Heat exchangers (HEXs) are among the key components of adiabatic compressed air energy storage (A-CAES) systems. However, the existing HEX models applied in the A-CAES systems are overly simplistic, limiting research regarding design and operational simulation. For the first time, this study incorporates a comprehensive HEX model, including calculations for geometric dimensioning, heat transfer, and pressure drop, into the A-CAES system model; in addition, a novel layered, interactive system design and operational simulation algorithms are developed. The developed models and algorithms can facilitate the design process and yield reasonable operational simulation results with only basic parameters. The design algorithm can determine all key parameters of the system and assess the effect of the HEX pressure drop and heat transfer area on the system performance. The operational simulation algorithm considers the performance of all key equipment under off-design conditions. The design exergy efficiency and daily net income of the system are 73.15 % and $26,998, respectively; however, these values decrease during operation to 72.15 % and $25,034, respectively. A comprehensive analysis of the key parameters during operation revealed that the primary causes for the degradation were the sliding pressure in the energy storage process and variations in the air storage tank parameters.

Suggested Citation

  • Ma, Linrui & Zhang, Xuelin & Zhang, Tong & Xue, Xiaodai & Chen, Xiaotao & Si, Yang, 2024. "Design and operation of an adiabatic compressed air energy storage system incorporating a detailed heat exchanger model," Energy, Elsevier, vol. 304(C).
    • Handle: RePEc:eee:energy:v:304:y:2024:i:c:s0360544224018784
    DOI: 10.1016/j.energy.2024.132104
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544224018784
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2024.132104?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Erdogan, Anil & Colpan, Can Ozgur & Cakici, Duygu Melek, 2017. "Thermal design and analysis of a shell and tube heat exchanger integrating a geothermal based organic Rankine cycle and parabolic trough solar collectors," Renewable Energy, Elsevier, vol. 109(C), pages 372-391.
    2. Rao, R. Venkata & Saroj, Ankit, 2017. "Constrained economic optimization of shell-and-tube heat exchangers using elitist-Jaya algorithm," Energy, Elsevier, vol. 128(C), pages 785-800.
    3. Briola, Stefano & Di Marco, Paolo & Gabbrielli, Roberto & Riccardi, Juri, 2016. "A novel mathematical model for the performance assessment of diabatic compressed air energy storage systems including the turbomachinery characteristic curves," Applied Energy, Elsevier, vol. 178(C), pages 758-772.
    4. Guo, Huan & Xu, Yujie & Chen, Haisheng & Zhang, Xinjing & Qin, Wei, 2018. "Corresponding-point methodology for physical energy storage system analysis and application to compressed air energy storage system," Energy, Elsevier, vol. 143(C), pages 772-784.
    5. Xia, Caichu & Zhou, Yu & Zhou, Shuwei & Zhang, Pingyang & Wang, Fei, 2015. "A simplified and unified analytical solution for temperature and pressure variations in compressed air energy storage caverns," Renewable Energy, Elsevier, vol. 74(C), pages 718-726.
    6. Zhao, Pan & Gao, Lin & Wang, Jiangfeng & Dai, Yiping, 2016. "Energy efficiency analysis and off-design analysis of two different discharge modes for compressed air energy storage system using axial turbines," Renewable Energy, Elsevier, vol. 85(C), pages 1164-1177.
    7. Ma, Linrui & Xu, Ershu & Li, Jun & Xu, Li & Li, Xiaolei, 2018. "Analysis and validation of a thermal hydraulic dynamic model for the parabolic trough solar field," Energy, Elsevier, vol. 156(C), pages 430-443.
    8. Greenblatt, Jeffery B. & Succar, Samir & Denkenberger, David C. & Williams, Robert H. & Socolow, Robert H., 2007. "Baseload wind energy: modeling the competition between gas turbines and compressed air energy storage for supplemental generation," Energy Policy, Elsevier, vol. 35(3), pages 1474-1492, March.
    9. Zhang, Cheng & Liu, Chao & Wang, Shukun & Xu, Xiaoxiao & Li, Qibin, 2017. "Thermo-economic comparison of subcritical organic Rankine cycle based on different heat exchanger configurations," Energy, Elsevier, vol. 123(C), pages 728-741.
    10. Tong, Zheming & Cheng, Zhewu & Tong, Shuiguang, 2021. "A review on the development of compressed air energy storage in China: Technical and economic challenges to commercialization," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    11. Sarmast, Sepideh & Rouindej, Kamyar & Fraser, Roydon A. & Dusseault, Maurice B., 2024. "Optimizing near-adiabatic compressed air energy storage (NA-CAES) systems: Sizing and design considerations," Applied Energy, Elsevier, vol. 357(C).
    12. Li, Guangkuo & Chen, Laijun & Xue, Xiaodai & Guo, Zhongjie & Wang, Guohua & Xie, Ningning & Mei, Shengwei, 2022. "Multi-mode optimal operation of advanced adiabatic compressed air energy storage: Explore its value with condenser operation," Energy, Elsevier, vol. 248(C).
    13. He, Wei & Wang, Jihong & Wang, Yang & Ding, Yulong & Chen, Haisheng & Wu, Yuting & Garvey, Seamus, 2017. "Study of cycle-to-cycle dynamic characteristics of adiabatic Compressed Air Energy Storage using packed bed Thermal Energy Storage," Energy, Elsevier, vol. 141(C), pages 2120-2134.
    14. Guo, Huan & Xu, Yujie & Zhang, Xinjing & Zhou, Xuezhi & Chen, Haisheng, 2020. "Transmission characteristics of exergy for novel compressed air energy storage systems-from compression and expansion sections to the whole system," Energy, Elsevier, vol. 193(C).
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Yan Cui & Tong Jiang & Zhengda Chen, 2025. "A Constant-Pressure Air Storage Operation Strategy for an Isothermal Compressed Air Energy Storage System Based on a Linear-Drive Liquid Piston," Energies, MDPI, vol. 18(12), pages 1-24, June.
    2. He, Wentao & Chen, Xi & Xu, Jingxuan & Lu, Yilin & Sun, Jiabao, 2025. "Thermodynamic and economic analysis of an adiabatic compressed air energy storage system coupled with an air separation unit," Energy, Elsevier, vol. 335(C).
    3. Wei, Luzeng & Chen, Wei & Qin, Chengliang & Zhou, Yu & Xue, Xiaodai & Zhang, Xuelin, 2025. "Cross-scale dynamic simulation and operational strategy optimization of the compression process in aquifer-based compressed air energy storage systems," Energy, Elsevier, vol. 335(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Guo, Huan & Xu, Yujie & Kang, Haoyuan & Guo, Wenbing & Liu, Yu & Zhang, Xinjing & Zhou, Xuezhi & Chen, Haisheng, 2023. "From theory to practice: Evaluating the thermodynamic design landscape of compressed air energy storage systems," Applied Energy, Elsevier, vol. 352(C).
    2. Sarmast, Sepideh & Rouindej, Kamyar & Fraser, Roydon A. & Dusseault, Maurice B., 2024. "Optimizing near-adiabatic compressed air energy storage (NA-CAES) systems: Sizing and design considerations," Applied Energy, Elsevier, vol. 357(C).
    3. Jiménez-Arreola, Manuel & Pili, Roberto & Wieland, Christoph & Romagnoli, Alessandro, 2018. "Analysis and comparison of dynamic behavior of heat exchangers for direct evaporation in ORC waste heat recovery applications from fluctuating sources," Applied Energy, Elsevier, vol. 216(C), pages 724-740.
    4. Meng, Hui & Wang, Meihong & Olumayegun, Olumide & Luo, Xiaobo & Liu, Xiaoyan, 2019. "Process design, operation and economic evaluation of compressed air energy storage (CAES) for wind power through modelling and simulation," Renewable Energy, Elsevier, vol. 136(C), pages 923-936.
    5. Facci, Andrea L. & Sánchez, David & Jannelli, Elio & Ubertini, Stefano, 2015. "Trigenerative micro compressed air energy storage: Concept and thermodynamic assessment," Applied Energy, Elsevier, vol. 158(C), pages 243-254.
    6. Marcin Kopiczko & Jaroslaw Jaworski, 2021. "Characteristics of the Parameters of Lithium Iron Phosphate Energy Storage in the Context of their Usefulness in the Management of Distribution Grid," European Research Studies Journal, European Research Studies Journal, vol. 0(3 - Part ), pages 817-826.
    7. Zeng, Zhen & Ma, Hongling & Yang, Chunhe & Liao, Youqiang & Wang, Xuan & Cai, Rui & Fang, Jiangyu, 2025. "Effect of the dynamic humid environment in salt caverns on their performance of compressed air energy storage: A modeling study of thermo-moisture-fluid dynamics," Applied Energy, Elsevier, vol. 377(PA).
    8. Arabkoohsar, Ahmad & Rahrabi, Hamid Reza & Alsagri, Ali Sulaiman & Alrobaian, Abdulrahman A., 2020. "Impact of Off-design operation on the effectiveness of a low-temperature compressed air energy storage system," Energy, Elsevier, vol. 197(C).
    9. Zhang, Yuan & Yang, Ke & Hong, Hui & Zhong, Xiaohui & Xu, Jianzhong, 2016. "Thermodynamic analysis of a novel energy storage system with carbon dioxide as working fluid," Renewable Energy, Elsevier, vol. 99(C), pages 682-697.
    10. Guo, Huan & Xu, Yujie & Huang, Lujing & Sun, Jianting & Chen, Haisheng, 2023. "Optimization strategy using corresponding-point methodology (CPM) concerning finite time and heat conduction rate for CAES systems," Energy, Elsevier, vol. 266(C).
    11. Tong, Zheming & Cheng, Zhewu & Tong, Shuiguang, 2021. "A review on the development of compressed air energy storage in China: Technical and economic challenges to commercialization," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    12. repec:ers:journl:v:xxiv:y:2021:i:3b:p:817-826 is not listed on IDEAS
    13. Pei Lu & Zheng Liang & Xianglong Luo & Yangkai Xia & Jin Wang & Kaihuang Chen & Yingzong Liang & Jianyong Chen & Zhi Yang & Jiacheng He & Ying Chen, 2023. "Design and Optimization of Organic Rankine Cycle Based on Heat Transfer Enhancement and Novel Heat Exchanger: A Review," Energies, MDPI, vol. 16(3), pages 1-34, January.
    14. Guo, Pengyu & Fan, Jinyang & Li, Zongze & Fourmeau, Marion & Zou, Yang & Chen, Jie & Jiang, Deyi, 2025. "Exploring compressed air energy storage in abandoned flooded coal mine: Thermodynamic analysis and applicability study," Energy, Elsevier, vol. 341(C).
    15. Zhan, Junpeng & Ansari, Osama Aslam & Liu, Weijia & Chung, C.Y., 2019. "An accurate bilinear cavern model for compressed air energy storage," Applied Energy, Elsevier, vol. 242(C), pages 752-768.
    16. Stefano Ubertini & Andrea Luigi Facci & Luca Andreassi, 2017. "Hybrid Hydrogen and Mechanical Distributed Energy Storage," Energies, MDPI, vol. 10(12), pages 1-16, December.
    17. Roos, P. & Haselbacher, A., 2022. "Analytical modeling of advanced adiabatic compressed air energy storage: Literature review and new models," Renewable and Sustainable Energy Reviews, Elsevier, vol. 163(C).
    18. Hong Ke & Yingchuan Ma & Yue Xiang & Xinjin Wang & Yutao Hu & Zhuo Ma & Guohua Zhang, 2025. "Quantitative Estimation of Type Selection of Underground Lined Rock Caverns for Compressed Air Energy Storage Based on Numerical Simulations," Energies, MDPI, vol. 18(12), pages 1-27, June.
    19. Wang, Tingtao & Miao, Shihong & Yao, Fuxing & Tan, Haoyu & Wang, Jie & Wang, Baisheng & He, Wu & Hou, Xinyu & Wang, Jiaxu & Li, Xianwei, 2025. "A nonlinear dispatch model and its rapid solution method for large-scale adiabatic compressed air energy storage under variable working conditions," Energy, Elsevier, vol. 325(C).
    20. Guney, Mukrimin Sevket & Tepe, Yalcin, 2017. "Classification and assessment of energy storage systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 75(C), pages 1187-1197.
    21. Sun, Hongchuang & Qin, Jiang & Hung, Tzu-Chen & Huang, Hongyan & Yan, Peigang & Lin, Chih-Hung, 2019. "Effect of flow losses in heat exchangers on the performance of organic Rankine cycle," Energy, Elsevier, vol. 172(C), pages 391-400.

    More about this item

    Keywords

    ;
    ;
    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:304:y:2024:i:c:s0360544224018784. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.