IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v247y2022ics0360544222004479.html
   My bibliography  Save this article

Adaptive envelope protection control of wind turbines under varying operational conditions

Author

Listed:
  • Sahin, Mustafa
  • Yavrucuk, Ilkay

Abstract

This study introduces a new Envelope Protection System (EPS) algorithm for wind turbines. The algorithm is adaptive to turbine-changing operational conditions and can effectively reduce turbine excessive/ultimate loads. Through an adaptive neural network, the proposed algorithm continuously monitors instantaneous wind and turbine states. Simultaneously, it predicts the near future response of the turbine load and detects its future crossing with a predefined safe envelope limit by comparing the actual wind speed to a theoretically estimated wind speed. When required, a protection action is applied based on the comparison to keep the turbine load response within the safe limit. In this paper, the thrust force is used as the critical load and is chosen as the limit parameter. Simulations are carried out using the MS (Mustafa Sahin) Bladed Wind Turbine Simulation Model for the National Renewable Energy Laboratory (NREL) 5 MW turbine under normal turbulent winds with different mean values. Simulations show that the EPS algorithm adapts to varying operational conditions such as changes in turbine operating point in the below rated, transition, and above rated regions, as well as rotor blade icing and successfully reduces the excessive thrust forces. Performance analyses indicate that, for keeping the thrust force within the limit, the proposed EPS algorithm reduces the thrust force by 98.89%, 98.43%, 99.26% relative to standard baseline controls in the aforementioned regions, respectively and by 99.61% under blade icing. Also, the mean value and the fluctuations of thrust force are reduced up to 5.52% and 68.7%, respectively. Depending on the operating region, the mean power decreases up to 2.07% or increases up to 1.21%, while power fluctuations decrease up to 30.97%.

Suggested Citation

  • Sahin, Mustafa & Yavrucuk, Ilkay, 2022. "Adaptive envelope protection control of wind turbines under varying operational conditions," Energy, Elsevier, vol. 247(C).
    • Handle: RePEc:eee:energy:v:247:y:2022:i:c:s0360544222004479
    DOI: 10.1016/j.energy.2022.123544
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544222004479
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2022.123544?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Lin, Yonggang & Tu, Le & Liu, Hongwei & Li, Wei, 2016. "Fault analysis of wind turbines in China," Renewable and Sustainable Energy Reviews, Elsevier, vol. 55(C), pages 482-490.
    2. Njiri, Jackson G. & Beganovic, Nejra & Do, Manh H. & Söffker, Dirk, 2019. "Consideration of lifetime and fatigue load in wind turbine control," Renewable Energy, Elsevier, vol. 131(C), pages 818-828.
    3. Abhineet Gupta & Mario A. Rotea & Mayank Chetan & Mohammad S. Sakib & D. Todd Griffith, 2021. "A Methodology for Robust Load Reduction in Wind Turbine Blades Using Flow Control Devices," Energies, MDPI, vol. 14(12), pages 1-29, June.
    4. Zhang, Mingming & Yang, Honglei & Xu, Jianzhong, 2017. "Numerical investigation of azimuth dependent smart rotor control on a large-scale offshore wind turbine," Renewable Energy, Elsevier, vol. 105(C), pages 248-256.
    5. Zhang, Mingming & Li, Xin & Tong, Jingxin & Xu, Jianzhong, 2020. "Load control of floating wind turbine on a Tension-Leg-Platform subject to extreme wind condition," Renewable Energy, Elsevier, vol. 151(C), pages 993-1007.
    6. Camblong, H. & Nourdine, S. & Vechiu, I. & Tapia, G., 2012. "Control of wind turbines for fatigue loads reduction and contribution to the grid primary frequency regulation," Energy, Elsevier, vol. 48(1), pages 284-291.
    7. Petrović, Vlaho & Bottasso, Carlo L., 2017. "Wind turbine envelope protection control over the full wind speed range," Renewable Energy, Elsevier, vol. 111(C), pages 836-848.
    8. Bofeng Xu & Yue Yuan & Haoming Liu & Peng Jiang & Ziqi Gao & Xiang Shen & Xin Cai, 2020. "A Pitch Angle Controller Based on Novel Fuzzy-PI Control for Wind Turbine Load Reduction," Energies, MDPI, vol. 13(22), pages 1-16, November.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Chen, Peng & Han, Dezhi, 2023. "Reward adaptive wind power tracking control based on deep deterministic policy gradient," Applied Energy, Elsevier, vol. 348(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Truong, Hoai Vu Anh & Dang, Tri Dung & Vo, Cong Phat & Ahn, Kyoung Kwan, 2022. "Active control strategies for system enhancement and load mitigation of floating offshore wind turbines: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 170(C).
    2. Xingkang Jin & Wen Tan & Yarong Zou & Zijian Wang, 2022. "Active Disturbance Rejection Control for Wind Turbine Fatigue Load," Energies, MDPI, vol. 15(17), pages 1-15, August.
    3. López-Queija, Javier & Robles, Eider & Jugo, Josu & Alonso-Quesada, Santiago, 2022. "Review of control technologies for floating offshore wind turbines," Renewable and Sustainable Energy Reviews, Elsevier, vol. 167(C).
    4. Habibi, Hamed & Howard, Ian & Simani, Silvio, 2019. "Reliability improvement of wind turbine power generation using model-based fault detection and fault tolerant control: A review," Renewable Energy, Elsevier, vol. 135(C), pages 877-896.
    5. Sergiienko, N.Y. & da Silva, L.S.P. & Bachynski-Polić, E.E. & Cazzolato, B.S. & Arjomandi, M. & Ding, B., 2022. "Review of scaling laws applied to floating offshore wind turbines," Renewable and Sustainable Energy Reviews, Elsevier, vol. 162(C).
    6. Bofeng Xu & Yue Yuan & Haoming Liu & Peng Jiang & Ziqi Gao & Xiang Shen & Xin Cai, 2020. "A Pitch Angle Controller Based on Novel Fuzzy-PI Control for Wind Turbine Load Reduction," Energies, MDPI, vol. 13(22), pages 1-16, November.
    7. Wang, Xuefei & Zeng, Xiangwu & Li, Xinyao & Li, Jiale, 2019. "Investigation on offshore wind turbine with an innovative hybrid monopile foundation: An experimental based study," Renewable Energy, Elsevier, vol. 132(C), pages 129-141.
    8. Katharina Fischer & Michael Steffes & Karoline Pelka & Bernd Tegtmeier & Martin Dörenkämper, 2021. "Humidity in Power Converters of Wind Turbines—Field Conditions and Their Relation with Failures," Energies, MDPI, vol. 14(7), pages 1-27, March.
    9. Dali, Ali & Abdelmalek, Samir & Bakdi, Azzeddine & Bettayeb, Maamar, 2021. "A new robust control scheme: Application for MPP tracking of a PMSG-based variable-speed wind turbine," Renewable Energy, Elsevier, vol. 172(C), pages 1021-1034.
    10. Galih Bangga, 2022. "Progress and Outlook in Wind Energy Research," Energies, MDPI, vol. 15(18), pages 1-5, September.
    11. Moradi, Hamed & Vossoughi, Gholamreza, 2015. "Robust control of the variable speed wind turbines in the presence of uncertainties: A comparison between H∞ and PID controllers," Energy, Elsevier, vol. 90(P2), pages 1508-1521.
    12. Camblong, Haritza & Vechiu, Ionel & Guillaud, Xavier & Etxeberria, Aitor & Kreckelbergh, Stéphane, 2014. "Wind turbine controller comparison on an island grid in terms of frequency control and mechanical stress," Renewable Energy, Elsevier, vol. 63(C), pages 37-45.
    13. Wang, Han & Yan, Jie & Han, Shuang & Liu, Yongqian, 2020. "Switching strategy of the low wind speed wind turbine based on real-time wind process prediction for the integration of wind power and EVs," Renewable Energy, Elsevier, vol. 157(C), pages 256-272.
    14. Nejra Beganovic & Jackson G. Njiri & Dirk Söffker, 2018. "Reduction of Structural Loads in Wind Turbines Based on an Adapted Control Strategy Concerning Online Fatigue Damage Evaluation Models," Energies, MDPI, vol. 11(12), pages 1-15, December.
    15. Jijian Lian & Ou Cai & Xiaofeng Dong & Qi Jiang & Yue Zhao, 2019. "Health Monitoring and Safety Evaluation of the Offshore Wind Turbine Structure: A Review and Discussion of Future Development," Sustainability, MDPI, vol. 11(2), pages 1-29, January.
    16. Li, Qing'an & Cai, Chang & Kamada, Yasunari & Maeda, Takao & Hiromori, Yuto & Zhou, Shuni & Xu, Jianzhong, 2021. "Prediction of power generation of two 30 kW Horizontal Axis Wind Turbines with Gaussian model," Energy, Elsevier, vol. 231(C).
    17. Hossein Madi & Dmytro Lytvynenko & Tilman Schildhauer & Peter Jansohn, 2023. "Decarbonisation of Geographical Islands and the Feasibility of Green Hydrogen Production Using Excess Electricity," Energies, MDPI, vol. 16(10), pages 1-18, May.
    18. Rongyong Zhao & Daheng Dong & Cuiling Li & Steven Liu & Hao Zhang & Miyuan Li & Wenzhong Shen, 2020. "An Improved Power Control Approach for Wind Turbine Fatigue Balancing in an Offshore Wind Farm," Energies, MDPI, vol. 13(7), pages 1-20, March.
    19. Cevasco, D. & Koukoura, S. & Kolios, A.J., 2021. "Reliability, availability, maintainability data review for the identification of trends in offshore wind energy applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 136(C).
    20. Meng Li & Shuangxin Wang, 2019. "Dynamic Fault Monitoring of Pitch System in Wind Turbines using Selective Ensemble Small-World Neural Networks," Energies, MDPI, vol. 12(17), pages 1-20, August.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:247:y:2022:i:c:s0360544222004479. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.