IDEAS home Printed from https://ideas.repec.org/a/gam/jagris/v11y2020i1p2-d466191.html
   My bibliography  Save this article

Suitability of Composting Process for the Disposal and Valorization of Brewer’s Spent Grain

Author

Listed:
  • Davide Assandri

    (Department of Agricultural Science, University of Sassari, Viale Italia 39, 07100 Sassari, Italy
    Institute of Sciences and Technologies for Sustainable Energy and Mobility of the National Research Council of Italy, Strada delle Cacce 73, 10135 Torino, Italy)

  • Niccolò Pampuro

    (Institute of Sciences and Technologies for Sustainable Energy and Mobility of the National Research Council of Italy, Strada delle Cacce 73, 10135 Torino, Italy)

  • Giacomo Zara

    (Department of Agricultural Science, University of Sassari, Viale Italia 39, 07100 Sassari, Italy)

  • Eugenio Cavallo

    (Institute of Sciences and Technologies for Sustainable Energy and Mobility of the National Research Council of Italy, Strada delle Cacce 73, 10135 Torino, Italy)

  • Marilena Budroni

    (Department of Agricultural Science, University of Sassari, Viale Italia 39, 07100 Sassari, Italy)

Abstract

The brewing industry is characterized by the large production of by-products. Following the fundamentals of a circular economy, several attempts to recycle brewers’ spent grain (BSG) have been investigated. However, little information is available on its use for composting. Considering the main parameters required for optimal development of composting, the objective of the present review was to analyze the literature to determine whether the microbial and physicochemical characteristics of BSG make it suitable for direct composting. As the main factors in the composting process, we considered the BSG moisture content, total carbon, total nitrogen, C/N ratio, and pH. As described in the literature, the BSG moisture content, C/N ratio, and pH range from 70.6% to 81.3%, 7.1 to 26.5, and 3.8 to 6.9, respectively. This C/N ratio range is lower than the composting target range (20–30). Instead, the mean moisture content in the literature is higher than the 60% to 65% recommended for composting. Optimum pH for aerobic stabilization of compost ranges from 5.5 to 7.5, while the BSG pH in the literature is typically more acidic. Therefore, BSG is not suitable for direct composting. Addition of lignocellulosic bulking agents improves the reduction of moisture content during composting, while also optimizing the substrate properties, such as C/N ratio, air spaces, and pH, to positively affect the composting process. Moreover, livestock manure should be included as a starting material to promote the composting process. In this context, two hypothetical initial mixtures of BSG plus a lignocellulosic bulking agent and livestock manure are presented.

Suggested Citation

  • Davide Assandri & Niccolò Pampuro & Giacomo Zara & Eugenio Cavallo & Marilena Budroni, 2020. "Suitability of Composting Process for the Disposal and Valorization of Brewer’s Spent Grain," Agriculture, MDPI, vol. 11(1), pages 1-12, December.
    • Handle: RePEc:gam:jagris:v:11:y:2020:i:1:p:2-:d:466191
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2077-0472/11/1/2/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2077-0472/11/1/2/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Sérgio Ferreira & Eliseu Monteiro & Paulo Brito & Carlos Castro & Luís Calado & Cândida Vilarinho, 2019. "Experimental Analysis of Brewers’ Spent Grains Steam Gasification in an Allothermal Batch Reactor," Energies, MDPI, vol. 12(5), pages 1-14, March.
    2. Mateusz Jackowski & Lukasz Niedzwiecki & Magdalena Lech & Mateusz Wnukowski & Amit Arora & Monika Tkaczuk-Serafin & Marcin Baranowski & Krystian Krochmalny & Vivek K. Veetil & Przemysław Seruga & Anna, 2020. "HTC of Wet Residues of the Brewing Process: Comprehensive Characterization of Produced Beer, Spent Grain and Valorized Residues," Energies, MDPI, vol. 13(8), pages 1-20, April.
    3. Niccolò Pampuro & Patrizia Busato & Eugenio Cavallo, 2018. "Effect of Densification Conditions on Specific Energy Requirements and Physical Properties of Compacts Made from Hop Cone," Energies, MDPI, vol. 11(9), pages 1-10, September.
    4. Rojas-Chamorro, José A. & Romero, Inmaculada & López-Linares, Juan C. & Castro, Eulogio, 2020. "Brewer’s spent grain as a source of renewable fuel through optimized dilute acid pretreatment," Renewable Energy, Elsevier, vol. 148(C), pages 81-90.
    5. Van Dyk, J.S. & Gama, R. & Morrison, D. & Swart, S. & Pletschke, B.I., 2013. "Food processing waste: Problems, current management and prospects for utilisation of the lignocellulose component through enzyme synergistic degradation," Renewable and Sustainable Energy Reviews, Elsevier, vol. 26(C), pages 521-531.
    6. Niccolò Pampuro & Carlo Bisaglia & Elio Romano & Massimo Brambilla & Ester Foppa Pedretti & Eugenio Cavallo, 2017. "Phytotoxicity and Chemical Characterization of Compost Derived from Pig Slurry Solid Fraction for Organic Pellet Production," Agriculture, MDPI, vol. 7(11), pages 1-10, November.
    7. Anubhav Pratap Singh & Ronit Mandal & Maryam Shojaei & Anika Singh & Przemysław Łukasz Kowalczewski & Marta Ligaj & Jarosław Pawlicz & Maciej Jarzębski, 2020. "Novel Drying Methods for Sustainable Upcycling of Brewers’ Spent Grains as a Plant Protein Source," Sustainability, MDPI, vol. 12(9), pages 1-17, May.
    8. Niccolò Pampuro & Christian Preti & Eugenio Cavallo, 2018. "Recycling Pig Slurry Solid Fraction Compost as a Sound Absorber," Sustainability, MDPI, vol. 10(1), pages 1-13, January.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Niccolò Pampuro & Patrizia Busato & Eugenio Cavallo, 2018. "Gaseous Emissions after Soil Application of Pellet Made from Composted Pig Slurry Solid Fraction: Effect of Application Method and Pellet Diameter," Agriculture, MDPI, vol. 8(8), pages 1-11, August.
    2. Mateusz Jackowski & Łukasz Niedźwiecki & Krzysztof Mościcki & Amit Arora & Muhammad Azam Saeed & Krystian Krochmalny & Jakub Pawliczek & Anna Trusek & Magdalena Lech & Jan Skřínský & Jakub Čespiva & J, 2021. "Synergetic Co-Production of Beer Colouring Agent and Solid Fuel from Brewers’ Spent Grain in the Circular Economy Perspective," Sustainability, MDPI, vol. 13(18), pages 1-17, September.
    3. Sérgio Ferreira & Eliseu Monteiro & Luís Calado & Valter Silva & Paulo Brito & Cândida Vilarinho, 2019. "Experimental and Modeling Analysis of Brewers´ Spent Grains Gasification in a Downdraft Reactor," Energies, MDPI, vol. 12(23), pages 1-18, November.
    4. Maria Królak & Hanna Górska-Warsewicz & Magdalena Mądra-Sawicka & Krystyna Rejman & Sylwia Żakowska-Biemans & Julita Szlachciuk & Maksymilian Czeczotko & Bartosz Kwiatkowski & Robert Zaremba & Michał , 2022. "Towards Sustainable Innovation in the Bakery Sector—An Example of Fibre-Enriched Bread," Sustainability, MDPI, vol. 14(5), pages 1-19, February.
    5. María Eugenia Beily & Brian Jonathan Young & Patricia Alina Bres & Nicolás Iván Riera & Wenguo Wang & Diana Elvira Crespo & Dimitrios Komilis, 2023. "Relationships among Physicochemical, Microbiological, and Parasitological Parameters, Ecotoxicity, and Biochemical Methane Potential of Pig Slurry," Sustainability, MDPI, vol. 15(4), pages 1-16, February.
    6. HajiHashemi, MohammadSina & Mazhkoo, Shahin & Dadfar, Hossein & Livani, Ehsan & Naseri Varnosefaderani, Aliakbar & Pourali, Omid & Najafi Nobar, Shima & Dutta, Animesh, 2023. "Combined heat and power production in a pilot-scale biomass gasification system: Experimental study and kinetic simulation using ASPEN Plus," Energy, Elsevier, vol. 276(C).
    7. Adriana Reyes-Lúa & Julian Straus & Vidar T. Skjervold & Goran Durakovic & Tom Ståle Nordtvedt, 2021. "A Novel Concept for Sustainable Food Production Utilizing Low Temperature Industrial Surplus Heat," Sustainability, MDPI, vol. 13(17), pages 1-23, August.
    8. Sunčica Beluhan & Katarina Mihajlovski & Božidar Šantek & Mirela Ivančić Šantek, 2023. "The Production of Bioethanol from Lignocellulosic Biomass: Pretreatment Methods, Fermentation, and Downstream Processing," Energies, MDPI, vol. 16(19), pages 1-38, October.
    9. Tiziana Amoriello & Roberto Ciccoritti, 2021. "Sustainability: Recovery and Reuse of Brewing-Derived By-Products," Sustainability, MDPI, vol. 13(4), pages 1-4, February.
    10. Wagner, Evelyn & Sierra-Ibarra, Estefanía & Rojas, Natalia L. & Martinez, Alfredo, 2022. "One-pot bioethanol production from brewery spent grain using the ethanologenic Escherichia coli MS04," Renewable Energy, Elsevier, vol. 189(C), pages 717-725.
    11. Krystian Krochmalny & Halina Pawlak-Kruczek & Norbert Skoczylas & Mateusz Kudasik & Aleksandra Gajda & Renata Gnatowska & Monika Serafin-Tkaczuk & Tomasz Czapka & Amit K. Jaiswal & Vishwajeet & Amit A, 2022. "Use of Hydrothermal Carbonization and Cold Atmospheric Plasma for Surface Modification of Brewer’s Spent Grain and Activated Carbon," Energies, MDPI, vol. 15(12), pages 1-11, June.
    12. Niccolò Pampuro & Federica Caffaro & Eugenio Cavallo, 2018. "Reuse of Animal Manure: A Case Study on Stakeholders’ Perceptions about Pelletized Compost in Northwestern Italy," Sustainability, MDPI, vol. 10(6), pages 1-10, June.
    13. Rosamaria Iadecola & Roberto Ciccoritti & Brunella Ceccantoni & Andrea Bellincontro & Tiziana Amoriello, 2022. "Optimization of Phenolic Compound Extraction from Brewers’ Spent Grain Using Ultrasound Technologies Coupled with Response Surface Methodology," Sustainability, MDPI, vol. 14(6), pages 1-17, March.
    14. Yukio Watanabe & Wataru Aoki & Mitsuyoshi Ueda, 2021. "Sustainable Biological Ammonia Production towards a Carbon-Free Society," Sustainability, MDPI, vol. 13(17), pages 1-13, August.
    15. Janajreh, Isam & Adeyemi, Idowu & Raza, Syed Shabbar & Ghenai, Chaouki, 2021. "A review of recent developments and future prospects in gasification systems and their modeling," Renewable and Sustainable Energy Reviews, Elsevier, vol. 138(C).
    16. Niccolò Pampuro & Federica Caffaro & Eugenio Cavallo, 2020. "Farmers’ Attitudes toward On-Farm Adoption of Soil Organic Matter in Piedmont Region, Italy," Agriculture, MDPI, vol. 10(1), pages 1-7, January.
    17. Jerzy Chojnacki & Jan Najser & Krzysztof Rokosz & Vaclav Peer & Jan Kielar & Bogusława Berner, 2020. "Syngas Composition: Gasification of Wood Pellet with Water Steam through a Reactor with Continuous Biomass Feed System," Energies, MDPI, vol. 13(17), pages 1-14, August.
    18. Florian Rösler & Judith Kreyenschmidt & Guido Ritter, 2021. "Recommendation of Good Practice in the Food-Processing Industry for Preventing and Handling Food Loss and Waste," Sustainability, MDPI, vol. 13(17), pages 1-30, August.
    19. Muhammad Yousaf Arshad & Muhammad Azam Saeed & Muhammad Wasim Tahir & Ahsan Raza & Anam Suhail Ahmad & Fasiha Tahir & Bartłomiej Borkowski & Tadeusz Mączka & Lukasz Niedzwiecki, 2023. "Role of Experimental, Modeling, and Simulation Studies of Plasma in Sustainable Green Energy," Sustainability, MDPI, vol. 15(19), pages 1-35, September.
    20. Sandra Untoria & Abel Rouboa & Eliseu Monteiro, 2024. "Hydrogen-Rich Syngas Production from Gasification of Sewage Sludge: Catalonia Case," Energies, MDPI, vol. 17(6), pages 1-13, March.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jagris:v:11:y:2020:i:1:p:2-:d:466191. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.