IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v101y2017icp1094-1101.html

Catalytic Hydrotreatment of algal biocrude from fast Hydrothermal Liquefaction

Author

Listed:
  • Patel, Bhavish
  • Arcelus-Arrillaga, Pedro
  • Izadpanah, Arash
  • Hellgardt, Klaus

Abstract

Hydrotreatment(HDT) of algal biocrude produced via a continuous flow reactor system at reaction condition of 380 °C and 0.5 min is conducted over a range of commercially available C and mesoporous gamma Al2O3 supported, 5 wt% loaded Pt, Pd, Ru and NiMo catalysts. Upgraded Biocrude(UBC) yield of over 60 wt% was achieved with the highest yield gained via NiMo/Al2O3 catalysed reaction. The change in elemental composition resulted in the UBC attaining deoxygenation levels similar to crude oil with oxygen level in the region of 6.07–1.60 wt%, and a maximum denitrogenation of 42.7%. The low O content of the UBC increased the Higher Heating Value(HHV) in the range of 38.36–45.40 MJ/kg from a value of 36.54 MJ/kg for the biocrude feedstock. Similarly, combined with the yield, an Energy Recovery (ER) figure in the range of 0.76 and 1.03 was calculated for the Ru/Al2O3 and control HDT reactions, respectively. Simulated Distillation(SIMDIST) of the UBC showed redistribution of gas oil fraction (271–343 °C) to lower and higher boiling point fractions, confirming both cracking and polymerisation reactions, also confirmed via Size Exclusion Chromatography(SEC). Additional analysis via ATR FT-IR showed formation of aromatics and GC-MS shed light on some of the molecular species present in the UBC.

Suggested Citation

  • Patel, Bhavish & Arcelus-Arrillaga, Pedro & Izadpanah, Arash & Hellgardt, Klaus, 2017. "Catalytic Hydrotreatment of algal biocrude from fast Hydrothermal Liquefaction," Renewable Energy, Elsevier, vol. 101(C), pages 1094-1101.
    • Handle: RePEc:eee:renene:v:101:y:2017:i:c:p:1094-1101
    DOI: 10.1016/j.renene.2016.09.056
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148116308461
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2016.09.056?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Tian, Chunyan & Li, Baoming & Liu, Zhidan & Zhang, Yuanhui & Lu, Haifeng, 2014. "Hydrothermal liquefaction for algal biorefinery: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 38(C), pages 933-950.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Xiao, Chao & Fu, Qian & Liao, Qiang & Huang, Yun & Xia, Ao & Chen, Hao & Zhu, Xun, 2020. "Life cycle and economic assessments of biogas production from microalgae biomass with hydrothermal pretreatment via anaerobic digestion," Renewable Energy, Elsevier, vol. 151(C), pages 70-78.
    2. Jeon, Kyung-Won & Shim, Jae-Oh & Jang, Won-Jun & Lee, Da-We & Na, Hyun-Suk & Kim, Hak-Min & Lee, Yeol-Lim & Yoo, Seong-Yeun & Roh, Hyun-Seog & Jeon, Byong-Hun & Bae, Jong Wook & Ko, Chang Hyun, 2019. "Effect of calcination temperature on the association between free NiO species and catalytic activity of Ni−Ce0.6Zr0.4O2 deoxygenation catalysts for biodiesel production," Renewable Energy, Elsevier, vol. 131(C), pages 144-151.
    3. Daniele Castello & Thomas Helmer Pedersen & Lasse Aistrup Rosendahl, 2018. "Continuous Hydrothermal Liquefaction of Biomass: A Critical Review," Energies, MDPI, vol. 11(11), pages 1-35, November.
    4. Sharma, Nishesh & Jaiswal, Krishna Kumar & Kumar, Vinod & Vlaskin, Mikhail S. & Nanda, Manisha & Rautela, Indra & Tomar, Mahipal Singh & Ahmad, Waseem, 2021. "Effect of catalyst and temperature on the quality and productivity of HTL bio-oil from microalgae: A review," Renewable Energy, Elsevier, vol. 174(C), pages 810-822.
    5. Huang, Xinghua & Dong, Shengfei & Yang, Xiaoyi, 2022. "Refining lipid for aviation biofuel at the molecular level," Renewable Energy, Elsevier, vol. 201(P1), pages 148-159.
    6. Castello, Daniele & Haider, Muhammad Salman & Rosendahl, Lasse Aistrup, 2019. "Catalytic upgrading of hydrothermal liquefaction biocrudes: Different challenges for different feedstocks," Renewable Energy, Elsevier, vol. 141(C), pages 420-430.
    7. Shahbeik, Hossein & Kazemi Shariat Panahi, Hamed & Dehhaghi, Mona & Guillemin, Gilles J. & Fallahi, Alireza & Hosseinzadeh-Bandbafha, Homa & Amiri, Hamid & Rehan, Mohammad & Raikwar, Deepak & Latine, , 2024. "Biomass to biofuels using hydrothermal liquefaction: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 189(PB).
    8. Das, Bikashbindu & Mohanty, Kaustubha, 2019. "A review on advances in sustainable energy production through various catalytic processes by using catalysts derived from waste red mud," Renewable Energy, Elsevier, vol. 143(C), pages 1791-1811.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Khoshnevisan, Benyamin & Duan, Na & Tsapekos, Panagiotis & Awasthi, Mukesh Kumar & Liu, Zhidan & Mohammadi, Ali & Angelidaki, Irini & Tsang, Daniel CW. & Zhang, Zengqiang & Pan, Junting & Ma, Lin & Ag, 2021. "A critical review on livestock manure biorefinery technologies: Sustainability, challenges, and future perspectives," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    2. Florian Delrue & Pablo David Álvarez-Díaz & Sophie Fon-Sing & Gatien Fleury & Jean-François Sassi, 2016. "The Environmental Biorefinery: Using Microalgae to Remediate Wastewater, a Win-Win Paradigm," Energies, MDPI, vol. 9(3), pages 1-19, February.
    3. Wu, Xiao-Fei & Yin, Shuang-Shuang & Zhou, Qian & Li, Ming-Fei & Peng, Feng & Xiao, Xiao, 2019. "Subcritical liquefaction of lignocellulose for the production of bio-oils in ethanol/water system," Renewable Energy, Elsevier, vol. 136(C), pages 865-872.
    4. Chen, Xinfei & Ma, Xiaoqian & Zeng, Xianghao & Zheng, Chupeng & Lu, Xiaoluan, 2020. "Ethanol addition during aqueous phase recirculation for further improving bio-oil yield and quality," Applied Energy, Elsevier, vol. 262(C).
    5. Soltanian, Salman & Kalogirou, Soteris A. & Ranjbari, Meisam & Amiri, Hamid & Mahian, Omid & Khoshnevisan, Benyamin & Jafary, Tahereh & Nizami, Abdul-Sattar & Gupta, Vijai Kumar & Aghaei, Siavash & Pe, 2022. "Exergetic sustainability analysis of municipal solid waste treatment systems: A systematic critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 156(C).
    6. Guo, Shuai & Wang, Xuhai & Gao, Long & Zhao, Chenchen & Li, Xingcan & Song, Dean, 2025. "Co-hydrothermal carbonization of tobacco stems assisted by activated carbon from coal-gasification fine slag: Efficient wastewater purification and enhanced combustion performance of co-hydrochar," Energy, Elsevier, vol. 331(C).
    7. Xu, Donghai & Lin, Guike & Guo, Shuwei & Wang, Shuzhong & Guo, Yang & Jing, Zefeng, 2018. "Catalytic hydrothermal liquefaction of algae and upgrading of biocrude: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 97(C), pages 103-118.
    8. Hu, Yulin & Gong, Mengyue & Feng, Shanghuan & Xu, Chunbao (Charles) & Bassi, Amarjeet, 2019. "A review of recent developments of pre-treatment technologies and hydrothermal liquefaction of microalgae for bio-crude oil production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 101(C), pages 476-492.
    9. Oumer, A.N. & Hasan, M.M. & Baheta, Aklilu Tesfamichael & Mamat, Rizalman & Abdullah, A.A., 2018. "Bio-based liquid fuels as a source of renewable energy: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 88(C), pages 82-98.
    10. Feng, Junfeng & Yang, Zhongzhi & Hse, Chung-yun & Su, Qiuli & Wang, Kui & Jiang, Jianchun & Xu, Junming, 2017. "In situ catalytic hydrogenation of model compounds and biomass-derived phenolic compounds for bio-oil upgrading," Renewable Energy, Elsevier, vol. 105(C), pages 140-148.
    11. Ahmad, Nabeel & Ahmad, Nauman & Maafa, Ibrahim M. & Ahmed, Usama & Akhter, Parveen & Shehzad, Nasir & Amjad, Um-e-salma & Hussain, Murid & Javaid, Momina, 2020. "Conversion of poly-isoprene based rubber to value-added chemicals and liquid fuel via ethanolysis: Effect of operating parameters on product quality and quantity," Energy, Elsevier, vol. 191(C).
    12. Zhang, Bo & Chen, Jixiang & He, Zhixia & Chen, Haitao & Kandasamy, Sabariswaran, 2019. "Hydrothermal liquefaction of fresh lemon-peel: Parameter optimisation and product chemistry," Renewable Energy, Elsevier, vol. 143(C), pages 512-519.
    13. Gu, X. & Martinez-Fernandez, J.S. & Pang, N. & Fu, X. & Chen, S., 2020. "Recent development of hydrothermal liquefaction for algal biorefinery," Renewable and Sustainable Energy Reviews, Elsevier, vol. 121(C).
    14. Gollakota, A.R.K. & Kishore, Nanda & Gu, Sai, 2018. "A review on hydrothermal liquefaction of biomass," Renewable and Sustainable Energy Reviews, Elsevier, vol. 81(P1), pages 1378-1392.
    15. Subhash Paul & Animesh Dutta & Fantahun Defersha, 2018. "Mechanical and Alkaline Hydrothermal Treated Corn Residue Conversion in to Bioenergy and Biofertilizer: A Resource Recovery Concept," Energies, MDPI, vol. 11(3), pages 1-20, February.
    16. Bai, Jing & Li, Lefei & Chen, Zhiyong & Chang, Chun & Pang, Shusheng & Li, Pan, 2023. "Study on the optimization of hydrothermal liquefaction performance of tobacco stem and the high value utilization of catalytic products," Energy, Elsevier, vol. 281(C).
    17. Yoo, Gursong & Park, Min S. & Yang, Ji-Won & Choi, Minkee, 2015. "Lipid content in microalgae determines the quality of biocrude and Energy Return On Investment of hydrothermal liquefaction," Applied Energy, Elsevier, vol. 156(C), pages 354-361.
    18. Moreno-Sader, K. & Meramo-Hurtado, S.I. & González-Delgado, A.D., 2019. "Computer-aided environmental and exergy analysis as decision-making tools for selecting bio-oil feedstocks," Renewable and Sustainable Energy Reviews, Elsevier, vol. 112(C), pages 42-57.
    19. Khalekuzzaman, Md & Jahan, Nusrat & Bin Kabir, Sadib & Hasan, Mehedi, 2024. "An integrated energy recovery approach of biohythane-biocrude production from microalgae-sludge through co-digestion and co-liquefaction," Renewable Energy, Elsevier, vol. 225(C).
    20. Nazari, Laleh & Yuan, Zhongshun & Ray, Madhumita B. & Xu, Chunbao (Charles), 2017. "Co-conversion of waste activated sludge and sawdust through hydrothermal liquefaction: Optimization of reaction parameters using response surface methodology," Applied Energy, Elsevier, vol. 203(C), pages 1-10.

    More about this item

    Keywords

    ;
    ;
    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:101:y:2017:i:c:p:1094-1101. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.