IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v191y2020ics0360544219322716.html
   My bibliography  Save this article

Dynamic behavior of supercritical organic Rankine cycle using zeotropic mixture working fluids

Author

Listed:
  • Chen, Xiaoxue
  • Liu, Chao
  • Li, Qibin
  • Wang, Xurong
  • Wang, Shukun

Abstract

As a prominent technology for recovering low-grade waste heat, supercritical organic Rankine cycle (ORC) exhibits a better performance due to the higher endothermic temperature and better thermal match with the heat source. The irreversibility in system can be reduced greatly when the zeotropic mixtures are used as working fluid to match the heat source and sink profiles. Affected by the fluctuations in waste heat sources, there is a challenge for ORC to recovery waste heat. An improved dynamic model of supercritical ORC using zeotropic mixture R134a/R32 as working fluid is developed and dynamic behaviors of supercritical ORC are analyzed. It is found that an abnormal fluctuation may occur in some parameters due to the effects around pseudo-critical point and thermal inertia of the heater. A fitting correlation to predict the response time based on different heat transfer coefficients of heater is found. Besides, three dynamic regimes are defined to investigate the effects of heat source frequencies and system thermal inertia on the dynamic response. As the heat source frequency increases or the heat exchange in the heater is enhanced, the fluctuation amplitude of the pressure decreases in the heater.

Suggested Citation

  • Chen, Xiaoxue & Liu, Chao & Li, Qibin & Wang, Xurong & Wang, Shukun, 2020. "Dynamic behavior of supercritical organic Rankine cycle using zeotropic mixture working fluids," Energy, Elsevier, vol. 191(C).
    • Handle: RePEc:eee:energy:v:191:y:2020:i:c:s0360544219322716
    DOI: 10.1016/j.energy.2019.116576
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544219322716
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2019.116576?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Jahedul Islam Chowdhury & Bao Kha Nguyen & David Thornhill & Yukun Hu & Payam Soulatiantork & Nazmiye Balta-Ozkan & Liz Varga, 2018. "Fuzzy Nonlinear Dynamic Evaporator Model in Supercritical Organic Rankine Cycle Waste Heat Recovery Systems," Energies, MDPI, vol. 11(4), pages 1-24, April.
    2. Xu, Heng & Gao, Naiping & Zhu, Tong, 2016. "Investigation on the fluid selection and evaporation parametric optimization for sub- and supercritical organic Rankine cycle," Energy, Elsevier, vol. 96(C), pages 59-68.
    3. Schuster, A. & Karellas, S. & Aumann, R., 2010. "Efficiency optimization potential in supercritical Organic Rankine Cycles," Energy, Elsevier, vol. 35(2), pages 1033-1039.
    4. Jiménez-Arreola, Manuel & Pili, Roberto & Wieland, Christoph & Romagnoli, Alessandro, 2018. "Analysis and comparison of dynamic behavior of heat exchangers for direct evaporation in ORC waste heat recovery applications from fluctuating sources," Applied Energy, Elsevier, vol. 216(C), pages 724-740.
    5. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen, 2019. "Design and performance analyses for a novel organic Rankine cycle with supercritical-subcritical heat absorption process coupling," Applied Energy, Elsevier, vol. 235(C), pages 1400-1414.
    6. Xie, Hui & Yang, Can, 2013. "Dynamic behavior of Rankine cycle system for waste heat recovery of heavy duty diesel engines under driving cycle," Applied Energy, Elsevier, vol. 112(C), pages 130-141.
    7. Le, Van Long & Kheiri, Abdelhamid & Feidt, Michel & Pelloux-Prayer, Sandrine, 2014. "Thermodynamic and economic optimizations of a waste heat to power plant driven by a subcritical ORC (Organic Rankine Cycle) using pure or zeotropic working fluid," Energy, Elsevier, vol. 78(C), pages 622-638.
    8. Quoilin, Sylvain & Aumann, Richard & Grill, Andreas & Schuster, Andreas & Lemort, Vincent & Spliethoff, Hartmut, 2011. "Dynamic modeling and optimal control strategy of waste heat recovery Organic Rankine Cycles," Applied Energy, Elsevier, vol. 88(6), pages 2183-2190, June.
    9. Chen, Huijuan & Goswami, D. Yogi & Rahman, Muhammad M. & Stefanakos, Elias K., 2011. "A supercritical Rankine cycle using zeotropic mixture working fluids for the conversion of low-grade heat into power," Energy, Elsevier, vol. 36(1), pages 549-555.
    10. Yağlı, Hüseyin & Koç, Yıldız & Koç, Ali & Görgülü, Adnan & Tandiroğlu, Ahmet, 2016. "Parametric optimization and exergetic analysis comparison of subcritical and supercritical organic Rankine cycle (ORC) for biogas fuelled combined heat and power (CHP) engine exhaust gas waste heat," Energy, Elsevier, vol. 111(C), pages 923-932.
    11. He, Chao & Liu, Chao & Gao, Hong & Xie, Hui & Li, Yourong & Wu, Shuangying & Xu, Jinliang, 2012. "The optimal evaporation temperature and working fluids for subcritical organic Rankine cycle," Energy, Elsevier, vol. 38(1), pages 136-143.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Wang, Zhiqi & Pan, Huihui & Xia, Xiaoxia & Xie, Baoqi & Peng, Deqi & Yang, Huya, 2022. "Experimental investigation on steady and dynamic performance of organic Rankine cycle with R245fa/R141b under different cooling and expander speed conditions," Energy, Elsevier, vol. 241(C).
    2. Cheng, Ziyang & Wang, Jiangfeng & Yang, Peijun & Wang, Yaxiong & Chen, Gang & Zhao, Pan & Dai, Yiping, 2022. "Comparison of control strategies and dynamic behaviour analysis of a Kalina cycle driven by a low-grade heat source," Energy, Elsevier, vol. 242(C).
    3. Du, Yang & Liu, Tingting & Wang, Yaxiong & Chen, Kang & Zhao, Pan & Wang, Jiangfeng & Dai, Yiping, 2021. "Transient behavior investigation of a regenerative dual-evaporator organic Rankine cycle with different forms of disturbances: Towards coordinated feedback control realization," Energy, Elsevier, vol. 235(C).
    4. Tailu Li & Zeyu Wang & Jingyi Wang & Xiang Gao, 2023. "Dynamic Performance of Organic Rankine Cycle Driven by Fluctuant Industrial Waste Heat for Building Power Supply," Energies, MDPI, vol. 16(2), pages 1-24, January.
    5. Wang, Enhua & Zhang, Mengru & Meng, Fanxiao & Zhang, Hongguang, 2022. "Zeotropic working fluid selection for an organic Rankine cycle bottoming with a marine engine," Energy, Elsevier, vol. 243(C).
    6. Miao, Zheng & Wang, Zhanbo & Varbanov, Petar Sabev & Klemeš, Jiří Jaromír & Xu, Jinliang, 2023. "Development of selection criteria of zeotropic mixtures as working fluids for the trans-critical organic Rankine cycle," Energy, Elsevier, vol. 278(PA).
    7. Ma, Xiaofeng & Jiang, Peixue & Zhu, Yinhai, 2022. "Dynamic simulation model with virtual interfaces of supercritical working fluid heat exchanger based on moving boundary method," Energy, Elsevier, vol. 254(PB).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Song, Chongzhi & Gu, Mingyan & Miao, Zheng & Liu, Chao & Xu, Jinliang, 2019. "Effect of fluid dryness and critical temperature on trans-critical organic Rankine cycle," Energy, Elsevier, vol. 174(C), pages 97-109.
    2. Jahedul Islam Chowdhury & Bao Kha Nguyen & David Thornhill & Yukun Hu & Payam Soulatiantork & Nazmiye Balta-Ozkan & Liz Varga, 2018. "Fuzzy Nonlinear Dynamic Evaporator Model in Supercritical Organic Rankine Cycle Waste Heat Recovery Systems," Energies, MDPI, vol. 11(4), pages 1-24, April.
    3. Liu, Wei & Meinel, Dominik & Gleinser, Moritz & Wieland, Christoph & Spliethoff, Hartmut, 2015. "Optimal Heat Source Temperature for thermodynamic optimization of sub-critical Organic Rankine Cycles," Energy, Elsevier, vol. 88(C), pages 897-906.
    4. Zhai, Huixing & An, Qingsong & Shi, Lin & Lemort, Vincent & Quoilin, Sylvain, 2016. "Categorization and analysis of heat sources for organic Rankine cycle systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 64(C), pages 790-805.
    5. Yu, Haoshui & Gundersen, Truls & Feng, Xiao, 2018. "Process integration of organic Rankine cycle (ORC) and heat pump for low temperature waste heat recovery," Energy, Elsevier, vol. 160(C), pages 330-340.
    6. Satanphol, K. & Pridasawas, W. & Suphanit, B., 2017. "A study on optimal composition of zeotropic working fluid in an Organic Rankine Cycle (ORC) for low grade heat recovery," Energy, Elsevier, vol. 123(C), pages 326-339.
    7. Liu, Chao & He, Chao & Gao, Hong & Xie, Hui & Li, Yourong & Wu, Shuangying & Xu, Jinliang, 2013. "The environmental impact of organic Rankine cycle for waste heat recovery through life-cycle assessment," Energy, Elsevier, vol. 56(C), pages 144-154.
    8. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen & Liu, Qiang, 2018. "Parametric optimization and thermodynamic performance comparison of single-pressure and dual-pressure evaporation organic Rankine cycles," Applied Energy, Elsevier, vol. 217(C), pages 409-421.
    9. Braimakis, Konstantinos & Mikelis, Angelos & Charalampidis, Antonios & Karellas, Sotirios, 2020. "Exergetic performance of CO2 and ultra-low GWP refrigerant mixtures as working fluids in ORC for waste heat recovery," Energy, Elsevier, vol. 203(C).
    10. Li, Xiaoya & Xu, Bin & Tian, Hua & Shu, Gequn, 2021. "Towards a novel holistic design of organic Rankine cycle (ORC) systems operating under heat source fluctuations and intermittency," Renewable and Sustainable Energy Reviews, Elsevier, vol. 147(C).
    11. Hong Gao & Chao Liu & Chao He & Xiaoxiao Xu & Shuangying Wu & Yourong Li, 2012. "Performance Analysis and Working Fluid Selection of a Supercritical Organic Rankine Cycle for Low Grade Waste Heat Recovery," Energies, MDPI, vol. 5(9), pages 1-15, August.
    12. Xuan Wang & Hua Tian & Gequn Shu, 2016. "Part-Load Performance Prediction and Operation Strategy Design of Organic Rankine Cycles with a Medium Cycle Used for Recovering Waste Heat from Gaseous Fuel Engines," Energies, MDPI, vol. 9(7), pages 1-21, July.
    13. Jahedul Islam Chowdhury & Bao Kha Nguyen & David Thornhill, 2015. "Modelling of Evaporator in Waste Heat Recovery System using Finite Volume Method and Fuzzy Technique," Energies, MDPI, vol. 8(12), pages 1-20, December.
    14. Le, Van Long & Feidt, Michel & Kheiri, Abdelhamid & Pelloux-Prayer, Sandrine, 2014. "Performance optimization of low-temperature power generation by supercritical ORCs (organic Rankine cycles) using low GWP (global warming potential) working fluids," Energy, Elsevier, vol. 67(C), pages 513-526.
    15. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen, 2019. "Design and performance analyses for a novel organic Rankine cycle with supercritical-subcritical heat absorption process coupling," Applied Energy, Elsevier, vol. 235(C), pages 1400-1414.
    16. Wang, Mingtao & Zhang, Juan & Liu, Qiyi & Tan, Luzhi, 2020. "Effects of critical temperature, critical pressure and dryness of working fluids on the performance of the transcritical organic rankine cycle," Energy, Elsevier, vol. 202(C).
    17. Miao, Zheng & Wang, Zhanbo & Varbanov, Petar Sabev & Klemeš, Jiří Jaromír & Xu, Jinliang, 2023. "Development of selection criteria of zeotropic mixtures as working fluids for the trans-critical organic Rankine cycle," Energy, Elsevier, vol. 278(PA).
    18. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen, 2019. "Effects of heat source temperature and mixture composition on the combined superiority of dual-pressure evaporation organic Rankine cycle and zeotropic mixtures," Energy, Elsevier, vol. 174(C), pages 436-449.
    19. Li, Tailu & Zhu, Jialing & Hu, Kaiyong & Kang, Zhenhua & Zhang, Wei, 2014. "Implementation of PDORC (parallel double-evaporator organic Rankine cycle) to enhance power output in oilfield," Energy, Elsevier, vol. 68(C), pages 680-687.
    20. Roberto Pili & Hartmut Spliethoff & Christoph Wieland, 2017. "Dynamic Simulation of an Organic Rankine Cycle—Detailed Model of a Kettle Boiler," Energies, MDPI, vol. 10(4), pages 1-28, April.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:191:y:2020:i:c:s0360544219322716. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.