IDEAS home Printed from https://ideas.repec.org/a/gam/jsusta/v13y2021i22p12737-d681624.html
   My bibliography  Save this article

Production of Biodiesel from Spirogyra elongata , a Common Freshwater Green Algae with High Oil Content

Author

Listed:
  • Aasma Saeed

    (Nano and Biomaterials Lab (NBL), Department of Chemistry, University of Agriculture, Faisalabad 38040, Pakistan)

  • Muhammad Asif Hanif

    (Nano and Biomaterials Lab (NBL), Department of Chemistry, University of Agriculture, Faisalabad 38040, Pakistan)

  • Asma Hanif

    (Department of Chemistry, Government College Women University Faisalabad (GCWUF), Faisalabad 38000, Pakistan)

  • Umer Rashid

    (Institute of Nanoscience and Nanotechnology (ION2), Universiti Putra Malaysia, Serdang 43400, Selangor, Malaysia)

  • Javed Iqbal

    (Department of Chemistry, University of Agriculture, Faisalabad 38040, Pakistan)

  • Muhammad Irfan Majeed

    (Department of Chemistry, University of Agriculture, Faisalabad 38040, Pakistan)

  • Bryan R. Moser

    (Bio-Oils Research Unit, National Center for Agricultural Utilization Research, Agricultural Research Service, United States Department of Agriculture, Peoria, IL 61604, USA)

  • Ali Alsalme

    (Chemistry Department, College of Science, King Saud University, Riyadh 1145, Saudi Arabia)

Abstract

The need for exploring nonfood low-cost sustainable sources for biodiesel production is ever increasing. Commercial and industrial algae cultivation has numerous uses in biodiesel production. This study explores S. elongata as a new algal feedstock for the production of biodiesel that does not compete with food production. The major fatty acids identified in S. elongata oil were oleic (30.5%), lauric (29.9%), myristic (17.0%), and palmitic (14.2%) acids. Transesterification to FAME was conducted using basic (KOH), acidic (HCl), and Zeolitic catalysts for assessment. The yields with acidic (54.6%) and zeolitic (72.7%) catalysts were unremarkable during initial screening. The highest biodiesel yield (99.9%) was achieved using KOH, which was obtained with the optimum reaction conditions of 1.0% catalyst, 60 °C, 4 h, and an oil-to-methanol volume ratio of 1:4. The resulting S. elongata oil methyl esters exhibited densities, CNs, and IVs, that were within the ranges specified in the American (ASTM D6751) and European (EN 14214) biodiesel standards, where applicable. In addition, the high SVs and the moderately high CPs and PPs were attributed to the presence of large quantities of short-chain and saturated FAME, respectively. Overall, the composition and properties of FAME prepared from S. elongaae oil indicate that S. elongata is suitable as an alternative algal feedstock for the production of biodiesel.

Suggested Citation

  • Aasma Saeed & Muhammad Asif Hanif & Asma Hanif & Umer Rashid & Javed Iqbal & Muhammad Irfan Majeed & Bryan R. Moser & Ali Alsalme, 2021. "Production of Biodiesel from Spirogyra elongata , a Common Freshwater Green Algae with High Oil Content," Sustainability, MDPI, vol. 13(22), pages 1-10, November.
    • Handle: RePEc:gam:jsusta:v:13:y:2021:i:22:p:12737-:d:681624
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2071-1050/13/22/12737/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2071-1050/13/22/12737/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Teuku Meurah Indra Riayatsyah & Razali Thaib & Arridina Susan Silitonga & Jassinnee Milano & Abd. Halim Shamsuddin & Abdi Hanra Sebayang & Rahmawaty & Joko Sutrisno & Teuku Meurah Indra Mahlia, 2021. "Biodiesel Production from Reutealis trisperma Oil Using Conventional and Ultrasonication through Esterification and Transesterification," Sustainability, MDPI, vol. 13(6), pages 1-15, March.
    2. Mohamed A. Zaki & Mohamed Ashour & Ahmed M. M. Heneash & Mohamed M. Mabrouk & Ahmed E. Alprol & Hanan M. Khairy & Abdelaziz M. Nour & Abdallah Tageldein Mansour & Hesham A. Hassanien & Ahmed Gaber & M, 2021. "Potential Applications of Native Cyanobacterium Isolate ( Arthrospira platensis NIOF17/003) for Biodiesel Production and Utilization of Its Byproduct in Marine Rotifer ( Brachionus plicatilis ) Produc," Sustainability, MDPI, vol. 13(4), pages 1-16, February.
    3. Shahir, S.A. & Masjuki, H.H. & Kalam, M.A. & Imran, A. & Fattah, I.M. Rizwanul & Sanjid, A., 2014. "Feasibility of diesel–biodiesel–ethanol/bioethanol blend as existing CI engine fuel: An assessment of properties, material compatibility, safety and combustion," Renewable and Sustainable Energy Reviews, Elsevier, vol. 32(C), pages 379-395.
    4. Subhadra, Bobban G., 2010. "Sustainability of algal biofuel production using integrated renewable energy park (IREP) and algal biorefinery approach," Energy Policy, Elsevier, vol. 38(10), pages 5892-5901, October.
    5. Subhadra, Bobban & Edwards, Mark, 2010. "An integrated renewable energy park approach for algal biofuel production in United States," Energy Policy, Elsevier, vol. 38(9), pages 4897-4902, September.
    6. George Anastopoulos & Ypatia Zannikou & Stamoulis Stournas & Stamatis Kalligeros, 2009. "Transesterification of Vegetable Oils with Ethanol and Characterization of the Key Fuel Properties of Ethyl Esters," Energies, MDPI, vol. 2(2), pages 1-15, June.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Budzianowski, Wojciech M. & Postawa, Karol, 2016. "Total Chain Integration of sustainable biorefinery systems," Applied Energy, Elsevier, vol. 184(C), pages 1432-1446.
    2. Singh, Anoop & Olsen, Stig Irving, 2011. "A critical review of biochemical conversion, sustainability and life cycle assessment of algal biofuels," Applied Energy, Elsevier, vol. 88(10), pages 3548-3555.
    3. Alvin B. Culaba & Aristotle T. Ubando & Phoebe Mae L. Ching & Wei-Hsin Chen & Jo-Shu Chang, 2020. "Biofuel from Microalgae: Sustainable Pathways," Sustainability, MDPI, vol. 12(19), pages 1-19, September.
    4. Jambo, Siti Azmah & Abdulla, Rahmath & Mohd Azhar, Siti Hajar & Marbawi, Hartinie & Gansau, Jualang Azlan & Ravindra, Pogaku, 2016. "A review on third generation bioethanol feedstock," Renewable and Sustainable Energy Reviews, Elsevier, vol. 65(C), pages 756-769.
    5. Subhadra, Bobban G., 2011. "Water management policies for the algal biofuel sector in the Southwestern United States," Applied Energy, Elsevier, vol. 88(10), pages 3492-3498.
    6. Subhadra, Bobban G., 2011. "Macro-level integrated renewable energy production schemes for sustainable development," Energy Policy, Elsevier, vol. 39(4), pages 2193-2196, April.
    7. Subhadra, Bobban G. & Edwards, Mark, 2011. "Coproduct market analysis and water footprint of simulated commercial algal biorefineries," Applied Energy, Elsevier, vol. 88(10), pages 3515-3523.
    8. Vlachokostas, Ch. & Michailidou, A.V. & Achillas, Ch., 2021. "Multi-Criteria Decision Analysis towards promoting Waste-to-Energy Management Strategies: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 138(C).
    9. Erika Carnevale & Giovanni Molari & Matteo Vittuari, 2017. "Used Cooking Oils in the Biogas Chain: A Technical and Economic Assessment," Energies, MDPI, vol. 10(2), pages 1-13, February.
    10. Kasivisvanathan, Harresh & Barilea, Ivan Dale U. & Ng, Denny K.S. & Tan, Raymond R., 2013. "Optimal operational adjustment in multi-functional energy systems in response to process inoperability," Applied Energy, Elsevier, vol. 102(C), pages 492-500.
    11. Lean, Hooi Hooi & Smyth, Russell, 2013. "Are fluctuations in US production of renewable energy permanent or transitory?," Applied Energy, Elsevier, vol. 101(C), pages 483-488.
    12. Mendiburu, Andrés Z. & Lauermann, Carlos H. & Hayashi, Thamy C. & Mariños, Diego J. & Rodrigues da Costa, Roberto Berlini & Coronado, Christian J.R. & Roberts, Justo J. & de Carvalho, João A., 2022. "Ethanol as a renewable biofuel: Combustion characteristics and application in engines," Energy, Elsevier, vol. 257(C).
    13. Mahmudul, H.M. & Hagos, F.Y. & Mamat, R. & Adam, A. Abdul & Ishak, W.F.W. & Alenezi, R., 2017. "Production, characterization and performance of biodiesel as an alternative fuel in diesel engines – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 72(C), pages 497-509.
    14. Panchal, Tirth M. & Patel, Ankit & Chauhan, D.D. & Thomas, Merlin & Patel, Jigar V., 2017. "A methodological review on bio-lubricants from vegetable oil based resources," Renewable and Sustainable Energy Reviews, Elsevier, vol. 70(C), pages 65-70.
    15. Shimaa M. Hassan & Mohamed Ashour & Nobumitsu Sakai & Lixin Zhang & Hesham A. Hassanien & Ahmed Gaber & Gamal Ammar, 2021. "Impact of Seaweed Liquid Extract Biostimulant on Growth, Yield, and Chemical Composition of Cucumber ( Cucumis sativus )," Agriculture, MDPI, vol. 11(4), pages 1-16, April.
    16. Hagos, Ftwi Y. & Ali, Obed M. & Mamat, Rizalman & Abdullah, Abdul A., 2017. "Effect of emulsification and blending on the oxygenation and substitution of diesel fuel for compression ignition engine," Renewable and Sustainable Energy Reviews, Elsevier, vol. 75(C), pages 1281-1294.
    17. Singh, Paramvir & Chauhan, S.R. & Goel, Varun, 2018. "Assessment of diesel engine combustion, performance and emission characteristics fuelled with dual fuel blends," Renewable Energy, Elsevier, vol. 125(C), pages 501-510.
    18. Aslan, Volkan & Eryilmaz, Tanzer, 2020. "Polynomial regression method for optimization of biodiesel production from black mustard (Brassica nigra L.) seed oil using methanol, ethanol, NaOH, and KOH," Energy, Elsevier, vol. 209(C).
    19. Vargün, Mustafa & Özsezen, Ahmet Necati, 2023. "Evaluation of the effect of the fuel injection phase on the combustion and exhaust characteristics in a diesel engine operating with alcohol-diesel mixtures," Energy, Elsevier, vol. 270(C).
    20. Ghadikolaei, Meisam Ahmadi & Wong, Pak Kin & Cheung, Chun Shun & Ning, Zhi & Yung, Ka-Fu & Zhao, Jing & Gali, Nirmal Kumar & Berenjestanaki, Alireza Valipour, 2021. "Impact of lower and higher alcohols on the physicochemical properties of particulate matter from diesel engines: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 143(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jsusta:v:13:y:2021:i:22:p:12737-:d:681624. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.