IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v153y2020icp975-984.html

Effects of runner change on the Winter-Kennedy flow measurement method – A numerical study

Author

Listed:
  • Baidar, Binaya
  • Nicolle, Jonathan
  • Gandhi, Bhupendra K.
  • Cervantes, Michel J.

Abstract

The Winter-Kennedy (WK) method is a popular choice to estimate the relative flow rates, and thus the expected improvement in the efficiency of a low head turbine after its refurbishment. Runner refurbishment is a common way to improve the plant’s efficiency. However, a previous experiment on a model turbine reported deviations between the WK coefficients obtained from two different runners ‒ suggesting a deviation between the estimated and actual improvement in the efficiency. Without formal proof, the deviation was attributed to flow changes in the spiral casing. This paper presents a numerical investigation of the effects of a runner change on the WK method. For this purpose, unsteady Reynolds-averaged Navier-Stokes equations (URANS) simulations of a turbine model with two different runners were conducted. The runner’s impact on the average flow conditions upstream and its subsequent effect on the WK coefficients were studied. The study shows the dependence of the WK coefficients to the runner ‒ with a maximum deviation on the coefficient up to 0.7%. The larger deviations were observed in regions prone to strong secondary flow. Following a radial and circumferential sensitivity study, a suitable location to minimize the effects of runner change on the WK method is reported.

Suggested Citation

  • Baidar, Binaya & Nicolle, Jonathan & Gandhi, Bhupendra K. & Cervantes, Michel J., 2020. "Effects of runner change on the Winter-Kennedy flow measurement method – A numerical study," Renewable Energy, Elsevier, vol. 153(C), pages 975-984.
    • Handle: RePEc:eee:renene:v:153:y:2020:i:c:p:975-984
    DOI: 10.1016/j.renene.2020.02.055
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148120302421
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2020.02.055?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Trivedi, Chirag & Cervantes, Michel J., 2017. "Fluid-structure interactions in Francis turbines: A perspective review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P1), pages 87-101.
    2. Trivedi, Chirag & Agnalt, Einar & Dahlhaug, Ole Gunnar, 2018. "Experimental study of a Francis turbine under variable-speed and discharge conditions," Renewable Energy, Elsevier, vol. 119(C), pages 447-458.
    3. Jonsson, P.P. & Mulu, B.G. & Cervantes, M.J., 2012. "Experimental investigation of a Kaplan draft tube – Part II: Off-design conditions," Applied Energy, Elsevier, vol. 94(C), pages 71-83.
    4. Lai, Xi-De & Liang, Quan-Wei & Ye, Dao-Xing & Chen, Xiao-Ming & Xia, Mi-Mi, 2019. "Experimental investigation of flows inside draft tube of a high-head pump-turbine," Renewable Energy, Elsevier, vol. 133(C), pages 731-742.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ma, Weichao & Vagnoni, Elena & Hu, Jinhong & Lai, Xu & Yang, Jiandong & Zhao, Zhigao, 2025. "Predictions of transient pressure pulsations in a pump-turbine from measurements for enhanced flexible operations," Energy, Elsevier, vol. 335(C).
    2. Bosioc, Alin Ilie & Tănasă, Constantin, 2020. "Experimental study of swirling flow from conical diffusers using the water jet control method," Renewable Energy, Elsevier, vol. 152(C), pages 385-398.
    3. Ni, Dan & Zhang, Ning & Gao, Bo & Li, Zhong & Yang, Minguan, 2020. "Dynamic measurements on unsteady pressure pulsations and flow distributions in a nuclear reactor coolant pump," Energy, Elsevier, vol. 198(C).
    4. Cavazzini, Giovanna & Houdeline, Jean-Bernard & Pavesi, Giorgio & Teller, Olivier & Ardizzon, Guido, 2018. "Unstable behaviour of pump-turbines and its effects on power regulation capacity of pumped-hydro energy storage plants," Renewable and Sustainable Energy Reviews, Elsevier, vol. 94(C), pages 399-409.
    5. Trivedi, Chirag & Iliev, Igor & Dahlhaug, Ole Gunnar & Markov, Zoran & Engstrom, Fredrik & Lysaker, Henning, 2020. "Investigation of a Francis turbine during speed variation: Inception of cavitation," Renewable Energy, Elsevier, vol. 166(C), pages 147-162.
    6. Lai, Xi-De & Liang, Quan-Wei & Ye, Dao-Xing & Chen, Xiao-Ming & Xia, Mi-Mi, 2019. "Experimental investigation of flows inside draft tube of a high-head pump-turbine," Renewable Energy, Elsevier, vol. 133(C), pages 731-742.
    7. Xing Zhou & Changzheng Shi & Kazuyoshi Miyagawa & Hegao Wu & Jinhong Yu & Zhu Ma, 2020. "Investigation of Pressure Fluctuation and Pulsating Hydraulic Axial Thrust in Francis Turbines," Energies, MDPI, vol. 13(7), pages 1-16, April.
    8. Zhu, Di & Tao, Ran & Xiao, Ruofu & Pan, Litan, 2020. "Solving the runner blade crack problem for a Francis hydro-turbine operating under condition-complexity," Renewable Energy, Elsevier, vol. 149(C), pages 298-320.
    9. Raluca G. Iovănel & Georgiana Dunca & Diana M. Bucur & Michel J. Cervantes, 2020. "Numerical Simulation of the Flow in a Kaplan Turbine Model during Transient Operation from the Best Efficiency Point to Part Load," Energies, MDPI, vol. 13(12), pages 1-21, June.
    10. Sun, Longgang & Xu, Hongyang & Li, Chenxi & Guo, Pengcheng & Xu, Zhuofei, 2024. "Unsteady assessment and alleviation of inter-blade vortex in Francis turbine," Applied Energy, Elsevier, vol. 358(C).
    11. Krzemianowski, Zbigniew & Przybyliński, Tomasz & Karwacki, Jarosław & Tomaszewski, Adam, 2025. "Experimental research of a high specific speed low-head model Francis turbine – A case study with emphasis on flow visualisation under runner using PIV method and energy production analysis," Energy, Elsevier, vol. 334(C).
    12. Trivedi, Chirag & Cervantes, Michel J., 2017. "Fluid-structure interactions in Francis turbines: A perspective review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P1), pages 87-101.
    13. Sotoudeh, Nahale & Maddahian, Reza & Cervantes, Michel J., 2020. "Investigation of Rotating Vortex Rope formation during load variation in a Francis turbine draft tube," Renewable Energy, Elsevier, vol. 151(C), pages 238-254.
    14. Li, Puxi & Xiao, Ruofu & Tao, Ran, 2022. "Study of vortex rope based on flow energy dissipation and vortex identification," Renewable Energy, Elsevier, vol. 198(C), pages 1065-1081.
    15. Laouari, Ahmed & Ghenaiet, Adel, 2021. "Investigation of steady and unsteady cavitating flows through a small Francis turbine," Renewable Energy, Elsevier, vol. 172(C), pages 841-861.
    16. Sundstrom, L.R. Joel & Shiraghaee, Shahab & Jonsson, Pontus P. & Cervantes, Michel J., 2025. "Experimental investigation of vortex rope mitigation in a 10 MW axial turbine," Renewable Energy, Elsevier, vol. 238(C).
    17. Xiangyang Li & Jingwei Cao & Jianling Zhuang & Tongmao Wu & Hongyong Zheng & Yunfeng Wang & Wenqiang Zheng & Guoqing Lin & Zhengwei Wang, 2022. "Effect of Operating Head on Dynamic Behavior of a Pump–Turbine Runner in Turbine Mode," Energies, MDPI, vol. 15(11), pages 1-15, May.
    18. Chen, Huazheng & Liu, Xiangsong & Lu, Yonggang & Fu, Qiang & Zhu, Rongsheng & Li, Huairui & Su, Haonan, 2024. "Evolution mechanism of internal flow in the hump region and hump optimization of axial-flow reactor coolant pump," Energy, Elsevier, vol. 311(C).
    19. Atmaram Kayastha & Hari Prasad Neopane & Ole Gunnar Dahlhaug, 2025. "Experimental Approach to Evaluate Effectiveness of Vortex Generators on Francis Turbine Runner," Energies, MDPI, vol. 18(4), pages 1-20, February.
    20. Guo, Bao & Xiao, Yexiang & Rai, Anant Kumar & Zhang, Jin & Liang, Quanwei, 2020. "Sediment-laden flow and erosion modeling in a Pelton turbine injector," Renewable Energy, Elsevier, vol. 162(C), pages 30-42.

    More about this item

    Keywords

    ;
    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:153:y:2020:i:c:p:975-984. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.