IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v253y2019ic102.html
   My bibliography  Save this article

Integrated membrane distillation-reverse electrodialysis system for energy-efficient seawater desalination

Author

Listed:
  • Tufa, Ramato Ashu
  • Noviello, Ylenia
  • Di Profio, Gianluca
  • Macedonio, Francesca
  • Ali, Aamer
  • Drioli, Enrico
  • Fontananova, Enrica
  • Bouzek, Karel
  • Curcio, Efrem

Abstract

Although desalination market is today dominated by Seawater Reverse Osmosis (SWRO), important technological issues remain unaddressed, specifically: relatively low water recovery factor (around 50%) and consequent huge amount of brine discharged, and energy consumption (3–5 kWh/m3) still far from the minimum thermodynamic value (∼1 kWh/m3). Herein, the energy performance of an innovative systems combining SWRO, Membrane Distillation (MD) and Reverse Electrodialysis (RED) for simultaneous production of water and energy is investigated. The valorization of hypersaline waste brine by Salinity Gradient Power production via RED and the achievement of high recovery factors (since MD is not limited by osmotic phenomena) represent a step forward to the practical implementation of Zero Liquid Discharge and low-energy desalination. The analysis is supported by lab-scale experimental tests carried out on MD and RED over a broad set of operational conditions. Among the different case studies investigated, exergetic efficiency reached 49% for the best scenario, i.e. MD feed temperature of 60 °C, MD brine concentration of 5 M NaCl, RED power density of 2.2 W/m2MP (MP: membrane pair). Compared to the benchmark flowsheet (only SWRO), up to 23% reduction in electrical energy consumption and 16.6% decrease in specific energy consumption were achieved when including a RED unit. The analysis also indicates that optimization of thermal energy input at the MD stage is critical, although it can potentially be fulfilled by low-grade waste heat or solar-thermal renewable sources. Overall, the proposed integrated system is coherent with the emergent paradigm of Circular Economy and the logic of Process Intensification.

Suggested Citation

  • Tufa, Ramato Ashu & Noviello, Ylenia & Di Profio, Gianluca & Macedonio, Francesca & Ali, Aamer & Drioli, Enrico & Fontananova, Enrica & Bouzek, Karel & Curcio, Efrem, 2019. "Integrated membrane distillation-reverse electrodialysis system for energy-efficient seawater desalination," Applied Energy, Elsevier, vol. 253(C), pages 1-1.
    • Handle: RePEc:eee:appene:v:253:y:2019:i:c:102
    DOI: 10.1016/j.apenergy.2019.113551
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261919312255
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2019.113551?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Tan, Yong Zen & Han, Le & Chew, Nick Guan Pin & Chow, Wai Hoong & Wang, Rong & Chew, Jia Wei, 2018. "Membrane distillation hybridized with a thermoelectric heat pump for energy-efficient water treatment and space cooling," Applied Energy, Elsevier, vol. 231(C), pages 1079-1088.
    2. Tufa, Ramato Ashu & Pawlowski, Sylwin & Veerman, Joost & Bouzek, Karel & Fontananova, Enrica & di Profio, Gianluca & Velizarov, Svetlozar & Goulão Crespo, João & Nijmeijer, Kitty & Curcio, Efrem, 2018. "Progress and prospects in reverse electrodialysis for salinity gradient energy conversion and storage," Applied Energy, Elsevier, vol. 225(C), pages 290-331.
    3. Li, Qiyuan & Beier, Lisa-Jil & Tan, Joel & Brown, Celia & Lian, Boyue & Zhong, Wenwei & Wang, Yuan & Ji, Chao & Dai, Pan & Li, Tianyu & Le Clech, Pierre & Tyagi, Himanshu & Liu, Xuefei & Leslie, Greg , 2019. "An integrated, solar-driven membrane distillation system for water purification and energy generation," Applied Energy, Elsevier, vol. 237(C), pages 534-548.
    4. Chang, Huawei & Wan, Zhongmin & Zheng, Yao & Chen, Xi & Shu, Shuiming & Tu, Zhengkai & Chan, Siew Hwa & Chen, Rui & Wang, Xiaodong, 2017. "Energy- and exergy-based working fluid selection and performance analysis of a high-temperature PEMFC-based micro combined cooling heating and power system," Applied Energy, Elsevier, vol. 204(C), pages 446-458.
    5. Baghbanzadeh, Mohammadali & Rana, Dipak & Lan, Christopher Q. & Matsuura, Takeshi, 2017. "Zero thermal input membrane distillation, a zero-waste and sustainable solution for freshwater shortage," Applied Energy, Elsevier, vol. 187(C), pages 910-928.
    6. Farrell, Eanna & Hassan, Mohamed I. & Tufa, Ramato A. & Tuomiranta, Arttu & Avci, Ahmet H. & Politano, Antonio & Curcio, Efrem & Arafat, Hassan A., 2017. "Reverse electrodialysis powered greenhouse concept for water- and energy-self-sufficient agriculture," Applied Energy, Elsevier, vol. 187(C), pages 390-409.
    7. Li, Weiyi & Krantz, William B. & Cornelissen, Emile R. & Post, Jan W. & Verliefde, Arne R.D. & Tang, Chuyang Y., 2013. "A novel hybrid process of reverse electrodialysis and reverse osmosis for low energy seawater desalination and brine management," Applied Energy, Elsevier, vol. 104(C), pages 592-602.
    8. Swaminathan, Jaichander & Chung, Hyung Won & Warsinger, David M. & Lienhard V, John H., 2018. "Energy efficiency of membrane distillation up to high salinity: Evaluating critical system size and optimal membrane thickness," Applied Energy, Elsevier, vol. 211(C), pages 715-734.
    9. El-Emam, Rami Salah & Dincer, Ibrahim, 2014. "Thermodynamic and thermoeconomic analyses of seawater reverse osmosis desalination plant with energy recovery," Energy, Elsevier, vol. 64(C), pages 154-163.
    10. Tamburini, A. & Tedesco, M. & Cipollina, A. & Micale, G. & Ciofalo, M. & Papapetrou, M. & Van Baak, W. & Piacentino, A., 2017. "Reverse electrodialysis heat engine for sustainable power production," Applied Energy, Elsevier, vol. 206(C), pages 1334-1353.
    11. Avci, Ahmet H. & Tufa, Ramato A. & Fontananova, Enrica & Di Profio, Gianluca & Curcio, Efrem, 2018. "Reverse Electrodialysis for energy production from natural river water and seawater," Energy, Elsevier, vol. 165(PA), pages 512-521.
    12. Prante, Jeri L. & Ruskowitz, Jeffrey A. & Childress, Amy E. & Achilli, Andrea, 2014. "RO-PRO desalination: An integrated low-energy approach to seawater desalination," Applied Energy, Elsevier, vol. 120(C), pages 104-114.
    13. Li, Yaopeng & Jia, Ming & Chang, Yachao & Kokjohn, Sage L. & Reitz, Rolf D., 2016. "Thermodynamic energy and exergy analysis of three different engine combustion regimes," Applied Energy, Elsevier, vol. 180(C), pages 849-858.
    14. Daniilidis, Alexandros & Herber, Rien & Vermaas, David A., 2014. "Upscale potential and financial feasibility of a reverse electrodialysis power plant," Applied Energy, Elsevier, vol. 119(C), pages 257-265.
    15. Ali, Aamer & Tufa, Ramato Ashu & Macedonio, Francesca & Curcio, Efrem & Drioli, Enrico, 2018. "Membrane technology in renewable-energy-driven desalination," Renewable and Sustainable Energy Reviews, Elsevier, vol. 81(P1), pages 1-21.
    16. Olkis, C. & Santori, G. & Brandani, S., 2018. "An Adsorption Reverse Electrodialysis system for the generation of electricity from low-grade heat," Applied Energy, Elsevier, vol. 231(C), pages 222-234.
    17. Hong, Jin Gi & Zhang, Wen & Luo, Jian & Chen, Yongsheng, 2013. "Modeling of power generation from the mixing of simulated saline and freshwater with a reverse electrodialysis system: The effect of monovalent and multivalent ions," Applied Energy, Elsevier, vol. 110(C), pages 244-251.
    18. Luo, Yu & Wu, Xiao-yu & Shi, Yixiang & Ghoniem, Ahmed F. & Cai, Ningsheng, 2018. "Exergy analysis of an integrated solid oxide electrolysis cell-methanation reactor for renewable energy storage," Applied Energy, Elsevier, vol. 215(C), pages 371-383.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Mohammed Faleh Abd Al-Ogaili & Mohd Hafiz Dzarfan Othman & Mohammad Rava & Zhong Sheng Tai & Mohd Hafiz Puteh & Juhana Jaafar & Mukhlis A. Rahman & Tonni Agustiono Kurniawan & Ojo Samuel & Aniqa Imtia, 2023. "Enhancing Hydrophobic/Hydrophilic Dual-Layer Membranes for Membrane Distillation: The Influence of Polytetrafluoroethylene (PTFE) Particle Size and Concentration," Sustainability, MDPI, vol. 15(20), pages 1-31, October.
    2. Ma, Xiaolu & Zhao, Jin & Wang, Run & Li, Yuyao & Liu, Chuanyong & Liu, Yong, 2022. "Multi-angle wide-spectrum light-trapping nanofiber membrane for highly efficient solar desalination," Applied Energy, Elsevier, vol. 328(C).
    3. Tian, Hailong & Wang, Ying & Pei, Yuansheng & Crittenden, John C., 2020. "Unique applications and improvements of reverse electrodialysis: A review and outlook," Applied Energy, Elsevier, vol. 262(C).
    4. Sumina Namboorimadathil Backer & Ines Bouaziz & Nabeela Kallayi & Reny Thankam Thomas & Gopika Preethikumar & Mohd Sobri Takriff & Tahar Laoui & Muataz Ali Atieh, 2022. "Review: Brine Solution: Current Status, Future Management and Technology Development," Sustainability, MDPI, vol. 14(11), pages 1-47, May.
    5. Ahdab, Yvana D. & Schücking, Georg & Rehman, Danyal & Lienhard, John H., 2021. "Cost effectiveness of conventionally and solar powered monovalent selective electrodialysis for seawater desalination in greenhouses," Applied Energy, Elsevier, vol. 301(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Tufa, Ramato Ashu & Pawlowski, Sylwin & Veerman, Joost & Bouzek, Karel & Fontananova, Enrica & di Profio, Gianluca & Velizarov, Svetlozar & Goulão Crespo, João & Nijmeijer, Kitty & Curcio, Efrem, 2018. "Progress and prospects in reverse electrodialysis for salinity gradient energy conversion and storage," Applied Energy, Elsevier, vol. 225(C), pages 290-331.
    2. Tian, Hailong & Wang, Ying & Pei, Yuansheng & Crittenden, John C., 2020. "Unique applications and improvements of reverse electrodialysis: A review and outlook," Applied Energy, Elsevier, vol. 262(C).
    3. Chen, Man & Mei, Ying & Yu, Yuqing & Zeng, Raymond Jianxiong & Zhang, Fang & Zhou, Shungui & Tang, Chuyang Y., 2019. "An internal-integrated RED/ED system for energy-saving seawater desalination: A model study," Energy, Elsevier, vol. 170(C), pages 139-148.
    4. Patricia Palenzuela & Marina Micari & Bartolomé Ortega-Delgado & Francesco Giacalone & Guillermo Zaragoza & Diego-César Alarcón-Padilla & Andrea Cipollina & Alessandro Tamburini & Giorgio Micale, 2018. "Performance Analysis of a RED-MED Salinity Gradient Heat Engine," Energies, MDPI, vol. 11(12), pages 1-23, December.
    5. Long, Rui & Zhao, Yanan & Li, Mingliang & Pan, Yao & Liu, Zhichun & Liu, Wei, 2021. "Evaluations of adsorbents and salt-methanol solutions for low-grade heat driven osmotic heat engines," Energy, Elsevier, vol. 229(C).
    6. Giacalone, F. & Papapetrou, M. & Kosmadakis, G. & Tamburini, A. & Micale, G. & Cipollina, A., 2019. "Application of reverse electrodialysis to site-specific types of saline solutions: A techno-economic assessment," Energy, Elsevier, vol. 181(C), pages 532-547.
    7. Farrell, Eanna & Hassan, Mohamed I. & Tufa, Ramato A. & Tuomiranta, Arttu & Avci, Ahmet H. & Politano, Antonio & Curcio, Efrem & Arafat, Hassan A., 2017. "Reverse electrodialysis powered greenhouse concept for water- and energy-self-sufficient agriculture," Applied Energy, Elsevier, vol. 187(C), pages 390-409.
    8. Olkis, C. & Santori, G. & Brandani, S., 2018. "An Adsorption Reverse Electrodialysis system for the generation of electricity from low-grade heat," Applied Energy, Elsevier, vol. 231(C), pages 222-234.
    9. Ortega-Delgado, B. & Giacalone, F. & Cipollina, A. & Papapetrou, M. & Kosmadakis, G. & Tamburini, A. & Micale, G., 2019. "Boosting the performance of a Reverse Electrodialysis – Multi-Effect Distillation Heat Engine by novel solutions and operating conditions," Applied Energy, Elsevier, vol. 253(C), pages 1-1.
    10. Long, Rui & Zhao, Yanan & Luo, Zuoqing & Li, Lei & Liu, Zhichun & Liu, Wei, 2020. "Alternative thermal regenerative osmotic heat engines for low-grade heat harvesting," Energy, Elsevier, vol. 195(C).
    11. Qasem, Naef A.A. & Lawal, Dahiru U. & Aljundi, Isam H. & Abdallah, Ayman M. & Panchal, Hitesh, 2022. "Novel integration of a parallel-multistage direct contact membrane distillation plant with a double-effect absorption refrigeration system," Applied Energy, Elsevier, vol. 323(C).
    12. Altaee, Ali & Palenzuela, Patricia & Zaragoza, Guillermo & AlAnezi, Adnan Alhathal, 2017. "Single and dual stage closed-loop pressure retarded osmosis for power generation: Feasibility and performance," Applied Energy, Elsevier, vol. 191(C), pages 328-345.
    13. Wan, Chun Feng & Chung, Tai-Shung, 2016. "Energy recovery by pressure retarded osmosis (PRO) in SWRO–PRO integrated processes," Applied Energy, Elsevier, vol. 162(C), pages 687-698.
    14. Nami, Hossein & Anvari-Moghaddam, Amjad, 2020. "Small-scale CCHP systems for waste heat recovery from cement plants: Thermodynamic, sustainability and economic implications," Energy, Elsevier, vol. 192(C).
    15. Mai, Van-Phung & Yang, Ruey-Jen, 2020. "Boosting power generation from salinity gradient on high-density nanoporous membrane using thermal effect," Applied Energy, Elsevier, vol. 274(C).
    16. Wan, Chun Feng & Chung, Tai-Shung, 2018. "Techno-economic evaluation of various RO+PRO and RO+FO integrated processes," Applied Energy, Elsevier, vol. 212(C), pages 1038-1050.
    17. Giacalone, F. & Olkis, C. & Santori, G. & Cipollina, A. & Brandani, S. & Micale, G., 2019. "Novel solutions for closed-loop reverse electrodialysis: Thermodynamic characterisation and perspective analysis," Energy, Elsevier, vol. 166(C), pages 674-689.
    18. Omar, Amr & Nashed, Amir & Li, Qiyuan & Leslie, Greg & Taylor, Robert A., 2020. "Pathways for integrated concentrated solar power - Desalination: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 119(C).
    19. Avci, Ahmet H. & Tufa, Ramato A. & Fontananova, Enrica & Di Profio, Gianluca & Curcio, Efrem, 2018. "Reverse Electrodialysis for energy production from natural river water and seawater," Energy, Elsevier, vol. 165(PA), pages 512-521.
    20. He, Wei & Wang, Yang & Shaheed, Mohammad Hasan, 2015. "Stand-alone seawater RO (reverse osmosis) desalination powered by PV (photovoltaic) and PRO (pressure retarded osmosis)," Energy, Elsevier, vol. 86(C), pages 423-435.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:253:y:2019:i:c:102. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.