IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v15y2022i21p7945-d953586.html
   My bibliography  Save this article

Exergoeconomic and Exergoenvironmental Analysis of a Novel Power and Cooling Cogeneration System Based on Organic Rankine Cycle and Ejector Refrigeration Cycle

Author

Listed:
  • Jinke Tao

    (School of Metallurgy and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, China)

  • Huitao Wang

    (School of Metallurgy and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, China)

  • Jianjun Wang

    (School of Metallurgy and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, China)

  • Chaojun Feng

    (School of Metallurgy and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, China)

Abstract

A novel combined power and refrigeration system is proposed based on organic Rankine and jet refrigeration cycles. The system has a wider application range and can be adjusted to different cooling and evaporation temperatures. To meet the needs of diverse populations, the cooling and evaporation temperature can be as low as −60 degrees Celsius. The genetic algorithm is used to optimize the system, and the proposed system’s energy, exergy, economy, and environment are analyzed under optimal conditions. The results desmonstrate that the exergy damage, environmental impact rate, and exergy economic coefficient of steam turbine are the largest. The system’s exergy damage and the turbine’s investment cost are reduced, and the system’s performance is improved. The condenser has the greatest potential for improvement and should be considered a priority component for system improvement. In addition, the system parameters are analyzed. Higher low-pressure steam generation temperature, dryness of low-pressure steam generator outlet, turbine steam extraction ratio, refrigeration evaporation temperature, and compressor compression ratio are advantageous to system cooling capacity output but not the system net power.High-pressure evaporation temperature is unfavorable to the system’s output of net power and cooling capacity. Still, it is beneficial to improve the thermal and energy efficiency of the system. Under the same operating conditions, compared with the system proposed by predecessors, the system’s net power is increased by 12.52 kW, the thermal efficiency is increased by 4.27%, and the energy efficiency is increased by 2.57%. The system was optimized by taking low-pressure evaporation temperature, high-pressure evaporation temperature, outlet dryness of low-pressure steam generator, suction ratio of steam turbine and compression ratio of compressor as decision variables, and thermal efficiency, exergy efficiency, SUCP and SUEP as objective functions. The low-pressure evaporation temperature, high-pressure evaporation temperature, outlet dryness of low-pressure steam generator, suction ratio of steam turbine, and compression ratio of compressor are 357.99 K, 385.72 K, 0.1, and 0, respectively. The system thermal efficiency is 15.01%, exergy efficiency is 43.18%, SUCP is 45.525USD/MWh, and SUEP is 5122.6 MPTS/MWh.

Suggested Citation

  • Jinke Tao & Huitao Wang & Jianjun Wang & Chaojun Feng, 2022. "Exergoeconomic and Exergoenvironmental Analysis of a Novel Power and Cooling Cogeneration System Based on Organic Rankine Cycle and Ejector Refrigeration Cycle," Energies, MDPI, vol. 15(21), pages 1-23, October.
    • Handle: RePEc:gam:jeners:v:15:y:2022:i:21:p:7945-:d:953586
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/15/21/7945/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/15/21/7945/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Mohammadkhani, F. & Shokati, N. & Mahmoudi, S.M.S. & Yari, M. & Rosen, M.A., 2014. "Exergoeconomic assessment and parametric study of a Gas Turbine-Modular Helium Reactor combined with two Organic Rankine Cycles," Energy, Elsevier, vol. 65(C), pages 533-543.
    2. Arabkoohsar, A. & Sadi, M., 2020. "A solar PTC powered absorption chiller design for Co-supply of district heating and cooling systems in Denmark," Energy, Elsevier, vol. 193(C).
    3. Yang, Jun Lan & Ma, Yi Tai & Li, Min Xia & Guan, Hai Qing, 2005. "Exergy analysis of transcritical carbon dioxide refrigeration cycle with an expander," Energy, Elsevier, vol. 30(7), pages 1162-1175.
    4. Moein Shamoushaki & Mehdi Aliehyaei & Farhad Taghizadeh-Hesary, 2021. "Energy, Exergy, Exergoeconomic, and Exergoenvironmental Assessment of Flash-Binary Geothermal Combined Cooling, Heating and Power Cycle," Energies, MDPI, vol. 14(15), pages 1-24, July.
    5. Adriano da S. Marques & Monica Carvalho & Álvaro A. V. Ochoa & Ronelly J. Souza & Carlos A. C. dos Santos, 2020. "Exergoeconomic Assessment of a Compact Electricity-Cooling Cogeneration Unit," Energies, MDPI, vol. 13(20), pages 1-18, October.
    6. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen & Liu, Qiang, 2018. "Parametric optimization and thermodynamic performance comparison of single-pressure and dual-pressure evaporation organic Rankine cycles," Applied Energy, Elsevier, vol. 217(C), pages 409-421.
    7. Ali Khalid Shaker Al-Sayyab & Joaquín Navarro-Esbrí & Victor Manuel Soto-Francés & Adrián Mota-Babiloni, 2021. "Conventional and Advanced Exergoeconomic Analysis of a Compound Ejector-Heat Pump for Simultaneous Cooling and Heating," Energies, MDPI, vol. 14(12), pages 1-27, June.
    8. Ahmadi, Pouria & Dincer, Ibrahim, 2010. "Exergoenvironmental analysis and optimization of a cogeneration plant system using Multimodal Genetic Algorithm (MGA)," Energy, Elsevier, vol. 35(12), pages 5161-5172.
    9. Manente, Giovanni & Lazzaretto, Andrea & Bonamico, Eleonora, 2017. "Design guidelines for the choice between single and dual pressure layouts in organic Rankine cycle (ORC) systems," Energy, Elsevier, vol. 123(C), pages 413-431.
    10. Wang, Lingbao & Bu, Xianbiao & Li, Huashan, 2020. "Multi-objective optimization and off-design evaluation of organic rankine cycle (ORC) for low-grade waste heat recovery," Energy, Elsevier, vol. 203(C).
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Paweł Ziółkowski & Marta Drosińska-Komor & Jerzy Głuch & Łukasz Breńkacz, 2023. "Review of Methods for Diagnosing the Degradation Process in Power Units Cooperating with Renewable Energy Sources Using Artificial Intelligence," Energies, MDPI, vol. 16(17), pages 1-28, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Niu, Jintao & Wang, Jiansheng & Liu, Xueling, 2023. "Thermodynamic and economic analysis of organic Rankine cycle combined with flash cycle and ejector," Energy, Elsevier, vol. 282(C).
    2. Xia, Xiaoxia & Yang, Chengwu & Wang, Zhiqi & Sun, Tong & Zhang, Hualong & Wu, Jinhao, 2024. "Multi-objective optimization of the dual-pressure organic Rankine cycle system based on the orthogonal design method under different external conditions," Energy, Elsevier, vol. 296(C).
    3. Kang, Lixia & Tang, Jianping & Liu, Yongzhong, 2020. "Optimal design of an organic Rankine cycle system considering the expected variations on heat sources," Energy, Elsevier, vol. 213(C).
    4. Kang, Lixia & Tang, Jianping & Liu, Yongzhong, 2021. "Optimal design of organic Rankine cycle system for multi-source waste heat recovery involving multi-period operation," Energy, Elsevier, vol. 235(C).
    5. Fan, Gang & Du, Yang & Li, Hang & Dai, Yiping, 2021. "Off-design behavior investigation of the combined supercritical CO2 and organic Rankine cycle," Energy, Elsevier, vol. 237(C).
    6. Surendran, Anandu & Seshadri, Satyanarayanan, 2020. "Design and performance analysis of a novel Transcritical Regenerative Series Two stage Organic Rankine Cycle for dual source waste heat recovery," Energy, Elsevier, vol. 203(C).
    7. Li, Jian & Peng, Xiayao & Yang, Zhen & Hu, Shuozhuo & Duan, Yuanyuan, 2022. "Design, improvements and applications of dual-pressure evaporation organic Rankine cycles: A review," Applied Energy, Elsevier, vol. 311(C).
    8. Jiansheng, Wang & Lide, Su & Qiang, Zhu & Jintao, Niu, 2022. "Numerical investigation on power generation performance of enhanced geothermal system with horizontal well," Applied Energy, Elsevier, vol. 325(C).
    9. Xinglin Yang & Qiang Lei & Junhu Zou & Xiaohui Lu & Zhenzhen Chen, 2023. "Green and Efficient Recovery and Optimization of Waste Heat and LNG Cold Energy in LNG-Powered Ship Engines," Energies, MDPI, vol. 16(24), pages 1-30, December.
    10. Li, Jian & Yang, Zhen & Shen, Jun & Duan, Yuanyuan, 2023. "Enhancement effects of adding internal heat exchanger on dual-pressure evaporation organic Rankine cycle," Energy, Elsevier, vol. 265(C).
    11. Zhang, Mingming & Timoshin, Anton & Al-Ammar, Essam A. & Sillanpaa, Mika & Zhang, Guiju, 2023. "Power, cooling, freshwater, and hydrogen production system from a new integrated system working with the zeotropic mixture, using a flash-binary geothermal system," Energy, Elsevier, vol. 263(PD).
    12. Yuan Zhao & Chenghao Gao & Chengjun Li & Jie Sun & Chunyan Wang & Qiang Liu & Jun Zhao, 2022. "Energy and Exergy Analyses of Geothermal Organic Rankine Cycles Considering the Effect of Brine Reinjection Temperature," Energies, MDPI, vol. 15(17), pages 1-20, August.
    13. Jesús García-Domínguez & J. Daniel Marcos, 2021. "Thermodynamic Analysis and Systematic Comparison of Solar-Heated Trigeneration Systems Based on ORC and Absorption Heat Pump," Energies, MDPI, vol. 14(16), pages 1-20, August.
    14. Athanasios G. Vallis & Theodoros C. Zannis & Evangelos V. Hristoforou & Elias A. Yfantis & Efthimios G. Pariotis & Dimitrios T. Hountalas & John S. Katsanis, 2022. "Design of Container Ship Main Engine Waste Heat Recovery Supercritical CO 2 Cycles, Optimum Cycle Selection through Thermo-Economic Optimization with Genetic Algorithm and Its Exergo-Economic and Exer," Energies, MDPI, vol. 15(15), pages 1-30, July.
    15. Liu, Xiaoliang & Ma, Lianghua & Liu, Haoyang & Ashraf Talesh, Seyed Saman, 2024. "Assessment of a sustainable power generation system utilizing supercritical carbon dioxide working fluid: Thermodynamic, economic, and environmental analysis," Energy, Elsevier, vol. 290(C).
    16. Wang, Mingtao & Qu, Lin & Liu, Huanwei & Chen, Pengji & Wang, Xuan, 2024. "Performance improvement analysis of the regenerative dual-pressure organic flash cycle assisted by ejectors," Energy, Elsevier, vol. 297(C).
    17. Li, Jian & Yang, Zhen & Hu, Shuozhuo & Yang, Fubin & Duan, Yuanyuan, 2020. "Thermo-economic analyses and evaluations of small-scale dual-pressure evaporation organic Rankine cycle system using pure fluids," Energy, Elsevier, vol. 206(C).
    18. Marcin Jankowski & Aleksandra Borsukiewicz & Kamel Hooman, 2020. "Development of Decision-Making Tool and Pareto Set Analysis for Bi-Objective Optimization of an ORC Power Plant," Energies, MDPI, vol. 13(20), pages 1-27, October.
    19. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen, 2019. "Design and performance analyses for a novel organic Rankine cycle with supercritical-subcritical heat absorption process coupling," Applied Energy, Elsevier, vol. 235(C), pages 1400-1414.
    20. Mohammadkhani, Farzad & Ranjbar, Faramarz & Yari, Mortaza, 2015. "A comparative study on the ammonia–water based bottoming power cycles: The exergoeconomic viewpoint," Energy, Elsevier, vol. 87(C), pages 425-434.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:15:y:2022:i:21:p:7945-:d:953586. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.