IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v241y2025ics0960148125000527.html
   My bibliography  Save this article

Startup characteristics of long direct-steam-generation loop in parabolic trough solar plant

Author

Listed:
  • Wang, Yongqing
  • Li, Han
  • Guo, Zhenning
  • Li, Lu
  • Wang, Ke

Abstract

Concentrating solar energy direct-steam-generation (DSG) technology is promising in kinds of industry fields and power plant. Understanding the thermo-hydraulic behavior during startup is essential to stabilize the system. Therefore, a transient optical-thermo-hydraulic model for a 600-m-long parabolic trough collectors (PTC) DSG loop is established with the finite volume method (FVM). The response behavior of flow boiling in the loop is examined during startup stage. The results indicate that during startup, the flow patterns in the evaporation section transit from intermittent flow to annular flow. The initial pattern of the evaporation is intermittent flow, which subsequently evolves into annular flow. The study reveals critical response characters for key thermo-hydraulic parameters in the DSG loop. The outlet parameters (temperature, velocity, pressure) stabilize after 2363 s, and mass flow rate 1046 s, respectively. The velocity shows three distinct stages during startup, marked by local maxima and minima. The pressure variation closely follows the changes in outlet velocity. Furthermore, the transient dynamic distribution of the preheating, evaporation, and superheating regions was analyzed, with the evaporation zone occupying 66.76 % of the total loop length after stabilization. Following a thermal disturbance in the DSG loop, the redistribution of the HTF's flow patterns always stabilizes sequentially along the flow direction. Additionally, higher irradiance intensifies the speed of flow redistribution. Before and after the thermal disturbance, the change in the proportion of intermittent flow and annular flow within the evaporation section is less than 0.2 %, remaining roughly at 11 % and 89 %, respectively. This research provides valuable insights into the dynamic behavior of DSG systems, which is crucial for optimizing their operational efficiency and reliability.

Suggested Citation

  • Wang, Yongqing & Li, Han & Guo, Zhenning & Li, Lu & Wang, Ke, 2025. "Startup characteristics of long direct-steam-generation loop in parabolic trough solar plant," Renewable Energy, Elsevier, vol. 241(C).
    • Handle: RePEc:eee:renene:v:241:y:2025:i:c:s0960148125000527
    DOI: 10.1016/j.renene.2025.122390
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148125000527
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2025.122390?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Song, Yuhui & Wang, Jiaxing & Zhang, Junli & Li, Yiguo, 2024. "Temperature homogenization control of parabolic trough solar collector field based on hydraulic calculation and extended Kalman filter," Renewable Energy, Elsevier, vol. 226(C).
    2. Giglio, Andrea & Lanzini, Andrea & Leone, Pierluigi & Rodríguez García, Margarita M. & Zarza Moya, Eduardo, 2017. "Direct steam generation in parabolic-trough collectors: A review about the technology and a thermo-economic analysis of a hybrid system," Renewable and Sustainable Energy Reviews, Elsevier, vol. 74(C), pages 453-473.
    3. Lobón, David H. & Baglietto, Emilio & Valenzuela, Loreto & Zarza, Eduardo, 2014. "Modeling direct steam generation in solar collectors with multiphase CFD," Applied Energy, Elsevier, vol. 113(C), pages 1338-1348.
    4. Li, Lu & Sun, Jie & Li, Yinshi & He, Ya-Ling & Xu, Haojie, 2019. "Transient characteristics of a parabolic trough direct-steam-generation process," Renewable Energy, Elsevier, vol. 135(C), pages 800-810.
    5. Roldán, M.I. & Valenzuela, L. & Zarza, E., 2013. "Thermal analysis of solar receiver pipes with superheated steam," Applied Energy, Elsevier, vol. 103(C), pages 73-84.
    6. Serrano-Aguilera, J.J. & Valenzuela, L. & Parras, L., 2017. "Thermal hydraulic RELAP5 model for a solar direct steam generation system based on parabolic trough collectors operating in once-through mode," Energy, Elsevier, vol. 133(C), pages 796-807.
    7. Mohammed, Hussein A. & Vuthaluru, Hari B. & Liu, Shaomin, 2022. "Thermohydraulic and thermodynamics performance of hybrid nanofluids based parabolic trough solar collector equipped with wavy promoters," Renewable Energy, Elsevier, vol. 182(C), pages 401-426.
    8. Soares, João & Oliveira, Armando C. & Valenzuela, Loreto, 2021. "A dynamic model for once-through direct steam generation in linear focus solar collectors," Renewable Energy, Elsevier, vol. 163(C), pages 246-261.
    9. Guo, Su & Liu, Deyou & Chen, Xingying & Chu, Yinghao & Xu, Chang & Liu, Qunming & Zhou, Ling, 2017. "Model and control scheme for recirculation mode direct steam generation parabolic trough solar power plants," Applied Energy, Elsevier, vol. 202(C), pages 700-714.
    10. Pal, Ram Kumar & Kumar, K. Ravi, 2022. "Effect of transient concentrated solar flux profile on the absorber surface for direct steam generation in the parabolic trough solar collector," Renewable Energy, Elsevier, vol. 186(C), pages 226-249.
    11. Guo, Su & Liu, Deyou & Chu, Yinghao & Chen, Xingying & Xu, Chang & Liu, Qunming & Guo, Tiezheng, 2017. "Dynamic behavior and transfer function of collector field in once-through DSG solar trough power plants," Energy, Elsevier, vol. 121(C), pages 513-523.
    12. Wang, Anming & Liu, Jiping & Zhang, Shunqi & Liu, Ming & Yan, Junjie, 2020. "Steam generation system operation optimization in parabolic trough concentrating solar power plants under cloudy conditions," Applied Energy, Elsevier, vol. 265(C).
    13. Cundapí, Roger & Moya, Sara L. & Valenzuela, Loreto, 2017. "Approaches to modelling a solar field for direct generation of industrial steam," Renewable Energy, Elsevier, vol. 103(C), pages 666-681.
    14. Xu, Rong & Wiesner, Theodore F., 2015. "Closed-form modeling of direct steam generation in a parabolic trough solar receiver," Energy, Elsevier, vol. 79(C), pages 163-176.
    15. Alamdari, Pedram & Khatamifar, Mehdi & Lin, Wenxian, 2024. "Heat loss analysis review: Parabolic trough and linear Fresnel collectors," Renewable and Sustainable Energy Reviews, Elsevier, vol. 199(C).
    16. Hachicha, Ahmed Amine & Rodríguez, Ivette & Ghenai, Chaouki, 2018. "Thermo-hydraulic analysis and numerical simulation of a parabolic trough solar collector for direct steam generation," Applied Energy, Elsevier, vol. 214(C), pages 152-165.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Sandá, Antonio & Moya, Sara L. & Valenzuela, Loreto, 2019. "Modelling and simulation tools for direct steam generation in parabolic-trough solar collectors: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 113(C), pages 1-1.
    2. Pal, Ram Kumar & Kumar, K. Ravi, 2022. "Effect of transient concentrated solar flux profile on the absorber surface for direct steam generation in the parabolic trough solar collector," Renewable Energy, Elsevier, vol. 186(C), pages 226-249.
    3. Yılmaz, İbrahim Halil & Mwesigye, Aggrey, 2018. "Modeling, simulation and performance analysis of parabolic trough solar collectors: A comprehensive review," Applied Energy, Elsevier, vol. 225(C), pages 135-174.
    4. Soares, João & Oliveira, Armando C. & Valenzuela, Loreto, 2021. "A dynamic model for once-through direct steam generation in linear focus solar collectors," Renewable Energy, Elsevier, vol. 163(C), pages 246-261.
    5. Hachicha, Ahmed Amine & Rodríguez, Ivette & Ghenai, Chaouki, 2018. "Thermo-hydraulic analysis and numerical simulation of a parabolic trough solar collector for direct steam generation," Applied Energy, Elsevier, vol. 214(C), pages 152-165.
    6. de Sá, Alexandre Bittencourt & Pigozzo Filho, Victor César & Tadrist, Lounès & Passos, Júlio César, 2018. "Direct steam generation in linear solar concentration: Experimental and modeling investigation – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 90(C), pages 910-936.
    7. Islam, Md Tasbirul & Huda, Nazmul & Abdullah, A.B. & Saidur, R., 2018. "A comprehensive review of state-of-the-art concentrating solar power (CSP) technologies: Current status and research trends," Renewable and Sustainable Energy Reviews, Elsevier, vol. 91(C), pages 987-1018.
    8. Liu, Shuaishuai & Yang, Bin & Yu, Xiaohui, 2024. "Thermal transfer characteristics and thermoelasticity analysis of direct-steam-generation parabolic trough collector," Renewable Energy, Elsevier, vol. 234(C).
    9. Biencinto, Mario & González, Lourdes & Valenzuela, Loreto, 2016. "A quasi-dynamic simulation model for direct steam generation in parabolic troughs using TRNSYS," Applied Energy, Elsevier, vol. 161(C), pages 133-142.
    10. Pal, Ram Kumar & K., Ravi Kumar, 2021. "Two-fluid modeling of direct steam generation in the receiver of parabolic trough solar collector with non-uniform heat flux," Energy, Elsevier, vol. 226(C).
    11. González-Mora, Eduardo & Durán-García, Ma. Dolores, 2024. "Assessing parabolic trough collectors and linear Fresnel reflectors direct steam generation solar power plants in Northwest México," Renewable Energy, Elsevier, vol. 228(C).
    12. Cheng, Ze-Dong & Zhao, Xue-Ru & He, Ya-Ling, 2018. "Novel optical efficiency formulas for parabolic trough solar collectors: Computing method and applications," Applied Energy, Elsevier, vol. 224(C), pages 682-697.
    13. Yılmaz, İbrahim Halil & Mwesigye, Aggrey & Kılıç, Fatih, 2023. "Prioritization of heat transfer fluids in parabolic trough solar systems using CFD-assisted AHP-VIKOR approach," Renewable Energy, Elsevier, vol. 210(C), pages 751-768.
    14. Hongn, Marcos & Flores Larsen, Silvana, 2018. "Hydrothermal model for small-scale linear Fresnel absorbers with non-uniform stepwise solar distribution," Applied Energy, Elsevier, vol. 223(C), pages 329-346.
    15. Huang, Zhen & Li, Zeng-Yao & Tao, Wen-Quan, 2017. "Numerical study on combined natural and forced convection in the fully-developed turbulent region for a horizontal circular tube heated by non-uniform heat flux," Applied Energy, Elsevier, vol. 185(P2), pages 2194-2208.
    16. Fuqiang, Wang & Zhexiang, Tang & Xiangtao, Gong & Jianyu, Tan & Huaizhi, Han & Bingxi, Li, 2016. "Heat transfer performance enhancement and thermal strain restrain of tube receiver for parabolic trough solar collector by using asymmetric outward convex corrugated tube," Energy, Elsevier, vol. 114(C), pages 275-292.
    17. Li, Lu & Sun, Jie & Li, Yinshi & He, Ya-Ling & Xu, Haojie, 2019. "Transient characteristics of a parabolic trough direct-steam-generation process," Renewable Energy, Elsevier, vol. 135(C), pages 800-810.
    18. Lin, Meng & Reinhold, Jan & Monnerie, Nathalie & Haussener, Sophia, 2018. "Modeling and design guidelines for direct steam generation solar receivers," Applied Energy, Elsevier, vol. 216(C), pages 761-776.
    19. Serrano-Aguilera, J.J. & Valenzuela, L. & Parras, L., 2014. "Thermal 3D model for Direct Solar Steam Generation under superheated conditions," Applied Energy, Elsevier, vol. 132(C), pages 370-382.
    20. Hachicha, Ahmed Amine & Yousef, Bashria A.A. & Said, Zafar & Rodríguez, Ivette, 2019. "A review study on the modeling of high-temperature solar thermal collector systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 112(C), pages 280-298.

    More about this item

    Keywords

    ;
    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:241:y:2025:i:c:s0960148125000527. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.