IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v240y2025ics0960148124022274.html
   My bibliography  Save this article

CFD simulation investigation of size-induced thermophysical characteristics of biomass materials in a fast pyrolysis reactor

Author

Listed:
  • Chen, Yuyang
  • Yang, Shiliang
  • Wang, Shuai
  • Wang, Hua

Abstract

Biomass pyrolysis is a crucial method for improving energy efficiency. However, the effects of segregation on the thermochemical properties of biomass pyrolysis in bubbling fluidized beds (BFB) are still not well understood. This study investigates biomass pyrolysis in a lab-scale BFB using the MP-PIC model, considering both heterogeneous and homogeneous reactions. After validating the model with experimental data, the size- and reaction-induced segregation and thermochemical properties were analyzed. The results show that axial segregation due to reaction and particle size differences leads to a continuous decrease in sand particle size along the bed height, significantly affecting solid heat and mass transfer. The heat transfer coefficient (HTC) of biomass and sand particles peaks near the biomass inlet but decreases for biomass as it moves upward. Increasing superficial velocity enhances biomass pyrolysis and improves the uniformity of temperature and heat carrier quality. Additionally, raising the bed temperature increases both biomass temperature and HTC. For sand particles of varying sizes, larger particles show higher temperatures, lower HTC, greater slip velocity, and reduced dispersion, while smaller particles exhibit the opposite. These findings provide valuable insights into segregation and thermochemical behavior in BFBs during high-temperature pyrolysis.

Suggested Citation

  • Chen, Yuyang & Yang, Shiliang & Wang, Shuai & Wang, Hua, 2025. "CFD simulation investigation of size-induced thermophysical characteristics of biomass materials in a fast pyrolysis reactor," Renewable Energy, Elsevier, vol. 240(C).
    • Handle: RePEc:eee:renene:v:240:y:2025:i:c:s0960148124022274
    DOI: 10.1016/j.renene.2024.122159
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148124022274
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2024.122159?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Yu, Hongshi & Sun, Haoran & Yang, Shiliang & Bao, Guirong & Wang, Hua, 2024. "Numerical simulation study of impact of polydispersity on biomass pyrolysis in draft-tube spouted reactor with fountain confiner," Renewable Energy, Elsevier, vol. 223(C).
    2. Kraft, Stephan & Kirnbauer, Friedrich & Hofbauer, Hermann, 2017. "CPFD simulations of an industrial-sized dual fluidized bed steam gasification system of biomass with 8MW fuel input," Applied Energy, Elsevier, vol. 190(C), pages 408-420.
    3. Sun, Haoran & Bao, Guirong & Yang, Shiliang & Hu, Jianhang & Wang, Hua, 2023. "Numerical study of the biomass gasification process in an industrial-scale dual fluidized bed gasifier with 8MWth input," Renewable Energy, Elsevier, vol. 211(C), pages 681-696.
    4. Park, Hoon Chae & Choi, Hang Seok, 2019. "Fast pyrolysis of biomass in a spouted bed reactor: Hydrodynamics, heat transfer and chemical reaction," Renewable Energy, Elsevier, vol. 143(C), pages 1268-1284.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Chen, Yuyang & Yang, Shiliang & Hu, Jianhang & Wang, Hua, 2023. "Investigation of the oxy-fuel combustion process in the full-loop circulating fluidized bed," Energy, Elsevier, vol. 283(C).
    2. Kuba, Matthias & Kraft, Stephan & Kirnbauer, Friedrich & Maierhans, Frank & Hofbauer, Hermann, 2018. "Influence of controlled handling of solid inorganic materials and design changes on the product gas quality in dual fluid bed gasification of woody biomass," Applied Energy, Elsevier, vol. 210(C), pages 230-240.
    3. Bai, Zhang & Gu, Yucheng & Wang, Shuoshuo & Jiang, Tieliu & Kong, Debin & Li, Qi, 2023. "Applying the solar solid particles as heat carrier to enhance the solar-driven biomass gasification with dynamic operation power generation performance analysis," Applied Energy, Elsevier, vol. 351(C).
    4. Armando Vitale & Andrea Di Carlo & Pier Ugo Foscolo & Alessandro Antonio Papa, 2024. "Kinetic Model Implementation of Fluidized Bed Devolatilization," Energies, MDPI, vol. 17(13), pages 1-17, June.
    5. Yang, Shiliang & Dong, Ruihan & Du, Yanxiang & Wang, Shuai & Wang, Hua, 2021. "Numerical study of the biomass pyrolysis process in a spouted bed reactor through computational fluid dynamics," Energy, Elsevier, vol. 214(C).
    6. Bartela, Łukasz & Kotowicz, Janusz & Dubiel-Jurgaś, Klaudia, 2018. "Investment risk for biomass integrated gasification combined heat and power unit with an internal combustion engine and a Stirling engine," Energy, Elsevier, vol. 150(C), pages 601-616.
    7. Zhou, Mengmeng & Wang, Shuai & Luo, Kun & Fan, Jianren, 2022. "Three-dimensional modeling study of the oxy-fuel co-firing of coal and biomass in a bubbling fluidized bed," Energy, Elsevier, vol. 247(C).
    8. Wan, Zhanghao & Hu, Jianhang & Qi, Xianjin, 2021. "Numerical analysis of hydrodynamics and thermochemical property of biomass gasification in a pilot-scale circulating fluidized bed," Energy, Elsevier, vol. 225(C).
    9. Lin, Junjie & Luo, Kun & Wang, Shuai & Sun, Liyan & Fan, Jianren, 2022. "Particle-scale study of coal-direct chemical looping combustion (CLC)," Energy, Elsevier, vol. 250(C).
    10. Sang Kyu Choi & Yeon Seok Choi & Yeon Woo Jeong & So Young Han & Quynh Van Nguyen, 2020. "Simulation of the Fast Pyrolysis of Coffee Ground in a Tilted-Slide Reactor," Energies, MDPI, vol. 13(24), pages 1-19, December.
    11. Mayu Hamazaki & Shan Miao & Mitsuo Kameyama & Hisashi Kamiuchi & Kiyoshi Dowaki, 2024. "CFD Simulation of Moving-Bed Pyrolizer for Sewage Sludge Considering Gas and Tar Behavior," Sustainability, MDPI, vol. 16(22), pages 1-20, November.
    12. Stanger, Lukas & Bartik, Alexander & Hammerschmid, Martin & Jankovic, Stefan & Benedikt, Florian & Müller, Stefan & Schirrer, Alexander & Jakubek, Stefan & Kozek, Martin, 2024. "Model predictive control of a dual fluidized bed gasification plant," Applied Energy, Elsevier, vol. 361(C).
    13. Nguyen, Nhut M. & Alobaid, Falah & May, Jan & Peters, Jens & Epple, Bernd, 2020. "Experimental study on steam gasification of torrefied woodchips in a bubbling fluidized bed reactor," Energy, Elsevier, vol. 202(C).
    14. Sun, Haoran & Yang, Shiliang & Bao, Guirong & Hu, Jianhang & Wang, Hua, 2023. "Numerical evaluation of multi-scale properties in biomass fast pyrolysis in fountain confined conical spouted bed," Energy, Elsevier, vol. 283(C).
    15. Wan, Zhanghao & Yang, Shiliang & Hu, Jianhang & Wang, Hua, 2023. "Catalyst-scale investigation of polydispersity effect on thermophysical properties in a commercial-scale catalytic MTO fluidized bed reactor," Energy, Elsevier, vol. 262(PA).
    16. Yang, Shiliang & Zhou, Tao & Wei, Yonggang & Hu, Jianhang & Wang, Hua, 2020. "Dynamical and thermal property of rising bubbles in the bubbling fluidized biomass gasifier with wide particle size distribution," Applied Energy, Elsevier, vol. 259(C).
    17. Klimanek, Adam & Bigda, Joanna, 2018. "CFD modelling of CO2 enhanced gasification of coal in a pressurized circulating fluidized bed reactor," Energy, Elsevier, vol. 160(C), pages 710-719.
    18. Yang, Shiliang & Wan, Zhanghao & Wang, Shuai & Wang, Hua, 2020. "Computational fluid study of radial and axial segregation characteristics in a dual fluidized bed reactor system," Energy, Elsevier, vol. 209(C).
    19. Rajan Jaiswal & Britt. M. E. Moldestad & Marianne S. Eikeland & Henrik K. Nielsen & Rajan Kumar Thapa, 2022. "Image Processing and Measurement of the Bubble Properties in a Bubbling Fluidized Bed Reactor," Energies, MDPI, vol. 15(21), pages 1-18, October.
    20. Lee, Byoung-Hwa & Kim, Kang-Min & Bae, Yoon-Ho & Oh, Hyun-Suk & Kim, Gyu-Bo & Jeon, Chung-Hwan & Ahn, Young-Heon, 2022. "Effect of bed particle size on the gas-particle hydrodynamics and wall erosion characteristics in a 550 MWe USC CFB boiler using CPFD simulation," Energy, Elsevier, vol. 254(PA).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:240:y:2025:i:c:s0960148124022274. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.