IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v14y2021i19p6412-d651315.html
   My bibliography  Save this article

Impact of Weather Conditions on the Operation of Power Unit Cooling Towers 905 MWe

Author

Listed:
  • Zbigniew Buryn

    (Faculty of Production Engineering and Logistics, Opole University of Technology, Prószkowska 76, 45-758 Opole, Poland)

  • Anna Kuczuk

    (Faculty of Mechanical Engineering, Opole University of Technology, Prószkowska 76, 45-758 Opole, Poland)

  • Janusz Pospolita

    (Faculty of Mechanical Engineering, Opole University of Technology, Prószkowska 76, 45-758 Opole, Poland)

  • Rafał Smejda

    (PGE GIK S.A. Branch Opole Power Plant, Brzezie k., 46-021 Opola, Poland)

  • Katarzyna Widera

    (Faculty of Economics and Management, Opole University of Technology, Prószkowska 76, 45-758 Opole, Poland)

Abstract

The paper presents the results of measurements and calculations concerning the influence of weather conditions on the operation of wet cooling towers of 905 MWe units of the Opole Power Plant (Poland). The research concerned the influence of temperature and relative humidity of air, wind and power unit load on the water temperature at the outlet from the cooling tower, the level of water cooling, cooling efficiency and cooling water losses. In the cooling water loss, the evaporation loss stream and the drift loss stream were distinguished. In the analyzed operating conditions of the power unit, for example, an increase in T a m b air by 5 °C (from 20 – 22 ° C to 25 – 27 ° C ) causes an increase in temperature at the outlet of the cooling tower by 3 – 4 ° C . The influence of air temperature and humidity on the level of water cooling Δ T w and cooling efficiency ε were also found. In the case of Δ T w , the effect is in the order of 0.1 – 0.2 ° C and results from the change in cooling water temperature and the heat exchange in the condenser. The ε value is influenced by air temperature and humidity, which determine the wet bulb temperature value. Within the range of power changes of the unit from 400 to 900 MWe , the evaporated water stream m ˙ e v , depending on the environmental conditions, increases from 400 – 600 tons / h to the value of 1000 – 1400 tons / h . It was determined that in the case of the average power of the unit at the level of 576.6 MWe , the average values of the evaporation and drift streams were respectively 0.78 % and 0.15 % of the cooling water stream. Using statistical methods, it was found that the influence of wind on the level of water cooling, cooling efficiency and cooling water losses was statistically significant.

Suggested Citation

  • Zbigniew Buryn & Anna Kuczuk & Janusz Pospolita & Rafał Smejda & Katarzyna Widera, 2021. "Impact of Weather Conditions on the Operation of Power Unit Cooling Towers 905 MWe," Energies, MDPI, vol. 14(19), pages 1-19, October.
    • Handle: RePEc:gam:jeners:v:14:y:2021:i:19:p:6412-:d:651315
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/14/19/6412/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/14/19/6412/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Clemente García Cutillas & Javier Ruiz Ramírez & Manuel Lucas Miralles, 2017. "Optimum Design and Operation of an HVAC Cooling Tower for Energy and Water Conservation," Energies, MDPI, vol. 10(3), pages 1-27, March.
    2. Jun Fan & Haotian Dong & Xiangyang Xu & De Teng & Bo Yan & Yuanbin Zhao, 2019. "Numerical Investigation on the Influence of Mechanical Draft Wet-Cooling Towers on the Cooling Performance of Air-Cooled Condenser with Complex Building Environment," Energies, MDPI, vol. 12(23), pages 1-16, November.
    3. George W. Divine & H. James Norton & Anna E. Barón & Elizabeth Juarez-Colunga, 2018. "The Wilcoxon–Mann–Whitney Procedure Fails as a Test of Medians," The American Statistician, Taylor & Francis Journals, vol. 72(3), pages 278-286, July.
    4. Wei Yuan & Fengzhong Sun & Ruqing Liu & Xuehong Chen & Ying Li, 2020. "The Effect of Air Parameters on the Evaporation Loss in a Natural Draft Counter-Flow Wet Cooling Tower," Energies, MDPI, vol. 13(23), pages 1-16, November.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Janusz Pospolita & Anna Kuczuk & Katarzyna Widera & Zbigniew Buryn & Robert Cholewa & Andrzej Drajczyk & Mirosław Pietrucha & Rafał Smejda, 2022. "Water Losses in the Condenser Cooling System at the 905 MWe Power Unit," Energies, MDPI, vol. 15(16), pages 1-25, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Janusz Pospolita & Anna Kuczuk & Katarzyna Widera & Zbigniew Buryn & Robert Cholewa & Andrzej Drajczyk & Mirosław Pietrucha & Rafał Smejda, 2022. "Water Losses in the Condenser Cooling System at the 905 MWe Power Unit," Energies, MDPI, vol. 15(16), pages 1-25, August.
    2. Jiannan Lu & Yunshu Zhang & Peng Ding, 2020. "Sharp bounds on the relative treatment effect for ordinal outcomes," Biometrics, The International Biometric Society, vol. 76(2), pages 664-669, June.
    3. Haotian Dong & Dawei Wan & Minghua Liu & Tiefeng Chen & Shasha Gao & Yuanbin Zhao, 2020. "Evaluation of the Hot Air Recirculation Effect and Relevant Empirical Formulae Applicability for Mechanical Draft Wet Cooling Towers," Energies, MDPI, vol. 13(13), pages 1-20, June.
    4. Awais Shah & Deqing Huang & Yixing Chen & Xin Kang & Na Qin, 2017. "Robust Sliding Mode Control of Air Handling Unit for Energy Efficiency Enhancement," Energies, MDPI, vol. 10(11), pages 1-21, November.
    5. Wei Yuan & Fengzhong Sun & Ruqing Liu & Xuehong Chen & Ying Li, 2020. "The Effect of Air Parameters on the Evaporation Loss in a Natural Draft Counter-Flow Wet Cooling Tower," Energies, MDPI, vol. 13(23), pages 1-16, November.
    6. Swapnil S. Shinde & Nitin P. Gulhane & Jan Taler & Paweł Ocłoń & Dawid Taler & Roberto de Lieto Vollaro, 2023. "Analysis of the Effect of Packing Materials (Fills) and Flow Rate on the Range and Efficiency of a Forced Draft Evaporative Cooling Tower," Energies, MDPI, vol. 16(14), pages 1-15, July.
    7. Carlos Alós-Ferrer & Georg D. Granic, 2023. "Does choice change preferences? An incentivized test of the mere choice effect," Experimental Economics, Springer;Economic Science Association, vol. 26(3), pages 499-521, July.
    8. Barth, Florian & Schüppler, Simon & Menberg, Kathrin & Blum, Philipp, 2023. "Estimating cooling capacities from aerial images using convolutional neural networks," Applied Energy, Elsevier, vol. 349(C).
    9. Hao, Guochen & Han, Kewu & Shi, Kebin, 2023. "Effect of floating balls on evaporation inhibition, surface energy balance and biological water quality parameters at different coverage fractions," Agricultural Water Management, Elsevier, vol. 287(C).
    10. Altaf Hussain Rajpar & Imran Ali & Ahmad E. Eladwi & Mohamed Bashir Ali Bashir, 2021. "Recent Development in the Design of Wind Deflectors for Vertical Axis Wind Turbine: A Review," Energies, MDPI, vol. 14(16), pages 1-23, August.
    11. Toru Yamamoto & Hirofumi Hayama & Takao Hayashi, 2020. "Formulation of Coefficient of Performance Characteristics of Water-cooled Chillers and Evaluation of Composite COP for Combined Chillers," Energies, MDPI, vol. 13(5), pages 1-20, March.
    12. Awais Shah & Deqing Huang & Tianpeng Huang & Umar Farid, 2018. "Optimization of BuildingsEnergy Consumption by Designing Sliding Mode Control for Multizone VAV Air Conditioning Systems," Energies, MDPI, vol. 11(11), pages 1-18, October.
    13. Whei-Min Lin & Chung-Yuen Yang & Ming-Tang Tsai & Hong-Jey Gow, 2019. "The Optimized Energy Saving of a Refrigerating Chamber," Energies, MDPI, vol. 12(10), pages 1-16, May.
    14. Belzunce, Félix & Martínez-Riquelme, Carolina, 2023. "A new stochastic dominance criterion for dependent random variables with applications," Insurance: Mathematics and Economics, Elsevier, vol. 108(C), pages 165-176.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:14:y:2021:i:19:p:6412-:d:651315. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.