IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v12y2019i23p4511-d291425.html
   My bibliography  Save this article

Experimental Investigations and Operational Performance Analysis on Compressed Natural Gas Home Refueling System (CNG-HRS)

Author

Listed:
  • Szymon Kuczyński

    (Drilling, Oil and Gas Faculty, AGH University of Science and Technology, 30-059 Krakow, Poland)

  • Krystian Liszka

    (Independent Expert, 32-020 Wieliczka, Poland)

  • Mariusz Łaciak

    (Drilling, Oil and Gas Faculty, AGH University of Science and Technology, 30-059 Krakow, Poland)

  • Andrzej Olijnyk

    (Drilling, Oil and Gas Faculty, AGH University of Science and Technology, 30-059 Krakow, Poland)

  • Adam Szurlej

    (Drilling, Oil and Gas Faculty, AGH University of Science and Technology, 30-059 Krakow, Poland)

Abstract

Compressed natural gas can be globally used as fuel for combustion engines to reduce CO 2 emission without negative impact on economy. Lack of refueling infrastructure is one of reason why NGVs shares only ~1.6% in total vehicle fleet worldwide. Operational tests of CNG home fast refueling station were performed to investigate: (i) natural gas demand, m 3 /h; (ii) energy consumption, kW/h; and (iii) total cost of one refueling. Two scenarios for operational tests were developed to monitor and collect data. Safety tests for leakage, fill pressure change, interrupted power and gas supply, temperature, and unexpected failures were performed. This article present results of operational and safety tests of compressed natural gas home, fast refueling station (CNG-HRS) based on one stage hydraulic compressor. The average duration of HRS full operating cycle was 7 h and 32 min (buffering and refueling mode). The average electric energy and natural gas consumption for one full cycle was 5.52 kWh and 7.5 m 3 , respectively. Safety tests results for leakage, fill pressure change, interrupted power and gas supply, temperature and unexpected failures demonstrated valid operation of HRS which positively affects the general safety level. To compare HRS with large scale CNG refueling infrastructure the costs of 1 Nm 3 CNG was estimated for both solutions. Results shows that home refueling appliance might be become a solution for filling the gap in CNG refueling infrastructure.

Suggested Citation

  • Szymon Kuczyński & Krystian Liszka & Mariusz Łaciak & Andrzej Olijnyk & Adam Szurlej, 2019. "Experimental Investigations and Operational Performance Analysis on Compressed Natural Gas Home Refueling System (CNG-HRS)," Energies, MDPI, vol. 12(23), pages 1-15, November.
    • Handle: RePEc:gam:jeners:v:12:y:2019:i:23:p:4511-:d:291425
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/12/23/4511/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/12/23/4511/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Ogden, Joan & Jaffe, Amy Myers & Scheitrum, Daniel & McDonald, Zane & Miller, Marshall, 2018. "Natural gas as a bridge to hydrogen transportation fuel: Insights from the literature," Energy Policy, Elsevier, vol. 115(C), pages 317-329.
    2. Steven Chu & Arun Majumdar, 2012. "Opportunities and challenges for a sustainable energy future," Nature, Nature, vol. 488(7411), pages 294-303, August.
    3. Li, Xuping & Ogden, Joan M. & Kurani, Kenneth S., 2009. "An Overview of Automotive Home and Neighborhood Refueling," Institute of Transportation Studies, Working Paper Series qt75m7618w, Institute of Transportation Studies, UC Davis.
    4. Abbanat, Brian A., 2001. "Alternative Fuel Vehicles: The Case of Compressed Natural Gas (CNG) Vehicles in California Households," Institute of Transportation Studies, Working Paper Series qt13q9r34w, Institute of Transportation Studies, UC Davis.
    5. Engerer, Hella & Horn, Manfred, 2010. "Natural gas vehicles: An option for Europe," Energy Policy, Elsevier, vol. 38(2), pages 1017-1029, February.
    6. Kelley, Scott & Kuby, Michael, 2017. "Decentralized refueling of compressed natural gas (CNG) fleet vehicles in Southern California," Energy Policy, Elsevier, vol. 109(C), pages 350-359.
    7. Khan, Muhammad Imran & Yasmin, Tabassum & Shakoor, Abdul, 2015. "Technical overview of compressed natural gas (CNG) as a transportation fuel," Renewable and Sustainable Energy Reviews, Elsevier, vol. 51(C), pages 785-797.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Łukasz Warguła & Mateusz Kukla & Piotr Lijewski & Michał Dobrzyński & Filip Markiewicz, 2020. "Impact of Compressed Natural Gas (CNG) Fuel Systems in Small Engine Wood Chippers on Exhaust Emissions and Fuel Consumption," Energies, MDPI, vol. 13(24), pages 1-21, December.
    2. Adam Saferna & Piotr Saferna & Szymon Kuczyński & Mariusz Łaciak & Adam Szurlej & Tomasz Włodek, 2021. "Thermodynamic Analysis of CNG Fast Filling Process of Composite Cylinder Type IV," Energies, MDPI, vol. 14(17), pages 1-20, September.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Malakoutirad, Mohammad & Bradley, Thomas H. & Hagen, Chris, 2015. "Design considerations for an engine-integral reciprocating natural gas compressor," Applied Energy, Elsevier, vol. 156(C), pages 129-137.
    2. Hao, Han & Liu, Zongwei & Zhao, Fuquan & Li, Weiqi, 2016. "Natural gas as vehicle fuel in China: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 62(C), pages 521-533.
    3. Ullah, Kafait & Hamid, Salman & Mirza, Faisal Mehmood & Shakoor, Usman, 2018. "Prioritizing the gaseous alternatives for the road transport sector of Pakistan: A multi criteria decision making analysis," Energy, Elsevier, vol. 165(PB), pages 1072-1084.
    4. Ravigné, E. & Da Costa, P., 2021. "Economic and environmental performances of natural gas for heavy trucks: A case study on the French automotive industry supply chain," Energy Policy, Elsevier, vol. 149(C).
    5. Girma T. Chala & Abd Rashid Abd Aziz & Ftwi Y. Hagos, 2018. "Natural Gas Engine Technologies: Challenges and Energy Sustainability Issue," Energies, MDPI, vol. 11(11), pages 1-44, October.
    6. Adam Saferna & Piotr Saferna & Szymon Kuczyński & Mariusz Łaciak & Adam Szurlej & Tomasz Włodek, 2021. "Thermodynamic Analysis of CNG Fast Filling Process of Composite Cylinder Type IV," Energies, MDPI, vol. 14(17), pages 1-20, September.
    7. Alejandro Ortega & Konstantinos Gkoumas & Anastasios Tsakalidis & Ferenc Pekár, 2021. "Low-Emission Alternative Energy for Transport in the EU: State of Play of Research and Innovation," Energies, MDPI, vol. 14(22), pages 1-22, November.
    8. Li, Xuping, 2012. "Understanding the Design and Performance of Distributed Tri-Generation Systems for Home and Neighborhood Refueling," Institute of Transportation Studies, Working Paper Series qt0h87d4sm, Institute of Transportation Studies, UC Davis.
    9. Chen, Long Xiang & Xie, Mei Na & Zhao, Pan Pan & Wang, Feng Xiang & Hu, Peng & Wang, Dong Xiang, 2018. "A novel isobaric adiabatic compressed air energy storage (IA-CAES) system on the base of volatile fluid," Applied Energy, Elsevier, vol. 210(C), pages 198-210.
    10. Xie, Yunkun & Li, Yangyang & Zhao, Zhichao & Dong, Hao & Wang, Shuqian & Liu, Jingping & Guan, Jinhuan & Duan, Xiongbo, 2020. "Microsimulation of electric vehicle energy consumption and driving range," Applied Energy, Elsevier, vol. 267(C).
    11. Sharafian, Amir & Talebian, Hoda & Blomerus, Paul & Herrera, Omar & Mérida, Walter, 2017. "A review of liquefied natural gas refueling station designs," Renewable and Sustainable Energy Reviews, Elsevier, vol. 69(C), pages 503-513.
    12. Chen, Xuejun & Yang, Yongming & Cui, Zhixin & Shen, Jun, 2019. "Vibration fault diagnosis of wind turbines based on variational mode decomposition and energy entropy," Energy, Elsevier, vol. 174(C), pages 1100-1109.
    13. Li, Shunxi & Su, Bowen & St-Pierre, David L. & Sui, Pang-Chieh & Zhang, Guofang & Xiao, Jinsheng, 2017. "Decision-making of compressed natural gas station siting for public transportation: Integration of multi-objective optimization, fuzzy evaluating, and radar charting," Energy, Elsevier, vol. 140(P1), pages 11-17.
    14. Muhammad Habib Ur Rehman & Luigi Coppola & Ernestino Lufrano & Isabella Nicotera & Cataldo Simari, 2023. "Enhancing Water Retention, Transport, and Conductivity Performance in Fuel Cell Applications: Nafion-Based Nanocomposite Membranes with Organomodified Graphene Oxide Nanoplatelets," Energies, MDPI, vol. 16(23), pages 1-11, November.
    15. Pin Li & Jinsuo Zhang, 2019. "Is China’s Energy Supply Sustainable? New Research Model Based on the Exponential Smoothing and GM(1,1) Methods," Energies, MDPI, vol. 12(2), pages 1-30, January.
    16. Konstantina Peloriadi & Petros Iliadis & Panagiotis Boutikos & Konstantinos Atsonios & Panagiotis Grammelis & Aristeidis Nikolopoulos, 2022. "Technoeconomic Assessment of LNG-Fueled Solid Oxide Fuel Cells in Small Island Systems: The Patmos Island Case Study," Energies, MDPI, vol. 15(11), pages 1-20, May.
    17. Sung-Fu Hung & Aoni Xu & Xue Wang & Fengwang Li & Shao-Hui Hsu & Yuhang Li & Joshua Wicks & Eduardo González Cervantes & Armin Sedighian Rasouli & Yuguang C. Li & Mingchuan Luo & Dae-Hyun Nam & Ning W, 2022. "A metal-supported single-atom catalytic site enables carbon dioxide hydrogenation," Nature Communications, Nature, vol. 13(1), pages 1-9, December.
    18. Zheng, Bobo & Xu, Jiuping & Ni, Ting & Li, Meihui, 2015. "Geothermal energy utilization trends from a technological paradigm perspective," Renewable Energy, Elsevier, vol. 77(C), pages 430-441.
    19. Mao, Guozhu & Zou, Hongyang & Chen, Guanyi & Du, Huibin & Zuo, Jian, 2015. "Past, current and future of biomass energy research: A bibliometric analysis," Renewable and Sustainable Energy Reviews, Elsevier, vol. 52(C), pages 1823-1833.
    20. Luo, Rongrong & Wang, Liuwei & Yu, Wei & Shao, Feilong & Shen, Haikuo & Xie, Huaqing, 2023. "High energy storage density titanium nitride-pentaerythritol solid–solid composite phase change materials for light-thermal-electric conversion," Applied Energy, Elsevier, vol. 331(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:12:y:2019:i:23:p:4511-:d:291425. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.