IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v211y2023icp202-213.html
   My bibliography  Save this article

Two-phase analytical modeling and intelligence parameter estimation of proton exchange membrane electrolyzer for hydrogen production

Author

Listed:
  • Wang, Bowen
  • Ni, Meng
  • Zhang, Shiye
  • Liu, Zhi
  • Jiang, Shangfeng
  • Zhang, Longhai
  • Zhou, Feikun
  • Jiao, Kui

Abstract

The proton exchange membrane electrolyzer (PEME) is a promising tool for hydrogen production, and internal two-phase transport significantly influences its performance. In this study, a two-phase analytical PEME model incorporating the liquid saturation jump effect was developed, and intelligent parameter estimation using a genetic algorithm was proposed to achieve high-efficiency model validation. In-house experiments and experimental results from numerous papers in the literature were employed to prove the effectiveness of the proposed intelligent parameter estimation. Moreover, the two-phase simulation results demonstrated that the PEME voltage increased significantly when the current density reached the limiting value, and the liquid saturation in the anode catalyst layer (ACL) dropped to nearly zero. Increasing ACL porosity, decreasing ACL permeability, and decreasing ACL thickness could increase the limiting current density within the investigated range. The simulated limiting current density could be > 5 A cm−2 through proper design of the ACL parameters. For high-pressure cathode operation, increasing the cathode pressure and membrane permeability generally benefits water management inside the PEME and therefore increases the limiting current density. This study provides critical support for the design of cells and operating conditions for future PEME studies.

Suggested Citation

  • Wang, Bowen & Ni, Meng & Zhang, Shiye & Liu, Zhi & Jiang, Shangfeng & Zhang, Longhai & Zhou, Feikun & Jiao, Kui, 2023. "Two-phase analytical modeling and intelligence parameter estimation of proton exchange membrane electrolyzer for hydrogen production," Renewable Energy, Elsevier, vol. 211(C), pages 202-213.
    • Handle: RePEc:eee:renene:v:211:y:2023:i:c:p:202-213
    DOI: 10.1016/j.renene.2023.04.090
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148123005402
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2023.04.090?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Wang, Zhiming & Wang, Xueye & Chen, Zhichao & Liao, Zhirong & Xu, Chao & Du, Xiaoze, 2021. "Energy and exergy analysis of a proton exchange membrane water electrolysis system without additional internal cooling," Renewable Energy, Elsevier, vol. 180(C), pages 1333-1343.
    2. Hernández-Gómez, Ángel & Ramirez, Victor & Guilbert, Damien & Saldivar, Belem, 2021. "Cell voltage static-dynamic modeling of a PEM electrolyzer based on adaptive parameters: Development and experimental validation," Renewable Energy, Elsevier, vol. 163(C), pages 1508-1522.
    3. Cheng, Chaochao & Yang, Zirong & Liu, Zhi & Tongsh, Chasen & Zhang, Guobin & Xie, Biao & He, Shaoqing & Jiao, Kui, 2021. "Numerical investigation on the feasibility of metal foam as flow field in alkaline anion exchange membrane fuel cell," Applied Energy, Elsevier, vol. 302(C).
    4. Espinosa-López, Manuel & Darras, Christophe & Poggi, Philippe & Glises, Raynal & Baucour, Philippe & Rakotondrainibe, André & Besse, Serge & Serre-Combe, Pierre, 2018. "Modelling and experimental validation of a 46 kW PEM high pressure water electrolyzer," Renewable Energy, Elsevier, vol. 119(C), pages 160-173.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Yuanyuan Li & Xiaoyu Xu & Daorina Bao & Bakhramzhan Rasakhodzhaev & Akhadov Jobir & Chun Chang & Mingzhi Zhao, 2023. "Research on Hydrogen Production System Technology Based on Photovoltaic-Photothermal Coupling Electrolyzer," Energies, MDPI, vol. 16(24), pages 1-27, December.
    2. Xu, Boshi & Yang, Yang & Li, Jun & Wang, Yang & Ye, Dingding & Zhang, Liang & Zhu, Xun & Liao, Qiang, 2024. "Computational assessment of response to fluctuating load of renewable energy in proton exchange membrane water electrolyzer," Renewable Energy, Elsevier, vol. 232(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Sun, Mingjia & Zhang, Yumeng & Liu, Luyao & Nian, Xingheng & Zhang, Hanfei & Duan, Liqiang, 2025. "Dynamic performance analysis of hydrogen production and hot standby dual-mode system via proton exchange membrane electrolyzer and phase change material-based heat storage," Applied Energy, Elsevier, vol. 377(PC).
    2. Zhu, Yanxi & Zhang, Yixiang & Bin, Shiyu & Chen, Zeyi & Zhang, Fanhang & Gong, Shihao & Xia, Yan & Duan, Xiongbo, 2024. "Effects of key design and operating parameters on the performance of the PEM water electrolysis for hydrogen production," Renewable Energy, Elsevier, vol. 235(C).
    3. Lin, Jianhui & Gu, Yujiong & Wang, Zijie & Zhao, Ziliang & Zhu, Ping, 2024. "Operational characteristics of an integrated island energy system based on multi-energy complementarity," Renewable Energy, Elsevier, vol. 230(C).
    4. Du, Banghua & Li, Yongkang & Li, Yang & Xie, Changjun & Wang, Xinming & Zhu, Wenchao & Yang, Yang & You, Li & Zhang, Leiqi & Zhao, Bo, 2025. "Modeling of PEMEL hydrogen production systems: Comprehensive multivariate sensitivity analysis considering mass-energy dynamic equilibrium," Applied Energy, Elsevier, vol. 377(PC).
    5. Gallo, María Angélica & García Clúa, José Gabriel, 2023. "Sizing and analytical optimization of an alkaline water electrolyzer powered by a grid-assisted wind turbine to minimize grid power exchange," Renewable Energy, Elsevier, vol. 216(C).
    6. Zhang, Yong & He, Shirong & Jiang, Xiaohui & Xiong, Mu & Ye, Yuntao & Yang, Xi, 2023. "Three-dimensional multi-phase simulation of proton exchange membrane fuel cell performance considering constriction straight channel," Energy, Elsevier, vol. 267(C).
    7. Sumit Sood & Om Prakash & Mahdi Boukerdja & Jean-Yves Dieulot & Belkacem Ould-Bouamama & Mathieu Bressel & Anne-Lise Gehin, 2020. "Generic Dynamical Model of PEM Electrolyser under Intermittent Sources," Energies, MDPI, vol. 13(24), pages 1-34, December.
    8. Ahmad Alzahrani & Senthil Kumar Ramu & Gunapriya Devarajan & Indragandhi Vairavasundaram & Subramaniyaswamy Vairavasundaram, 2022. "A Review on Hydrogen-Based Hybrid Microgrid System: Topologies for Hydrogen Energy Storage, Integration, and Energy Management with Solar and Wind Energy," Energies, MDPI, vol. 15(21), pages 1-32, October.
    9. Tang, Yinglun & Su, Shangchun & Niu, Xiaoxuan & Song, Zhehui & Li, Wenjia, 2024. "A gradient porous transport layer enabling a high-performance proton-exchange membrane electrolysis cell," Renewable Energy, Elsevier, vol. 237(PC).
    10. Taehyung Koo & Rockkil Ko & Dongwoo Ha & Jaeyoung Han, 2023. "Development of Model-Based PEM Water Electrolysis HILS (Hardware-in-the-Loop Simulation) System for State Evaluation and Fault Detection," Energies, MDPI, vol. 16(8), pages 1-18, April.
    11. Duchaud, Jean-Laurent & Notton, Gilles & Darras, Christophe & Voyant, Cyril, 2019. "Multi-Objective Particle Swarm optimal sizing of a renewable hybrid power plant with storage," Renewable Energy, Elsevier, vol. 131(C), pages 1156-1167.
    12. Zhang, Hong & Yuan, Tiejiang, 2022. "Optimization and economic evaluation of a PEM electrolysis system considering its degradation in variable-power operations," Applied Energy, Elsevier, vol. 324(C).
    13. Chen, Jingxian & Wang, Sen & Sun, Yongwen & Zhang, Cunman & Lv, Hong, 2025. "Multi-dimensional performance evaluation and energy analysis of proton exchange membrane water electrolyzer," Applied Energy, Elsevier, vol. 377(PB).
    14. Cai, Jingyong & Weng, Chu & Zhang, Ruonan & Li, Qifen & Zhang, Tao & Shi, Zhengrong, 2023. "Comparative analysis on the dynamic operation performance of photovoltaic/thermal powered proton exchange membrane water electrolysis cogeneration system (PV/T-PEMWE) under different connection modes," Renewable Energy, Elsevier, vol. 219(P2).
    15. Damien Guilbert & Gianpaolo Vitale, 2019. "Dynamic Emulation of a PEM Electrolyzer by Time Constant Based Exponential Model," Energies, MDPI, vol. 12(4), pages 1-17, February.
    16. Wang, Zhiming & Wang, Xueye & Chen, Zhichao & Liao, Zhirong & Xu, Chao & Du, Xiaoze, 2021. "Energy and exergy analysis of a proton exchange membrane water electrolysis system without additional internal cooling," Renewable Energy, Elsevier, vol. 180(C), pages 1333-1343.
    17. Zhang, Lu & Liu, Jie & Du, Shaojie & Zhao, Chen, 2024. "Multiphase flow dynamics in metal foam proton exchange membrane fuel cell," Renewable Energy, Elsevier, vol. 226(C).
    18. Cao, Ruifeng & Li, Weiqiang & Chen, Ziqi & Li, Yawei, 2024. "Development and assessment of a novel isobaric compressed hydrogen energy storage system integrated with pumped hydro storage and high-pressure proton exchange membrane water electrolyzer," Energy, Elsevier, vol. 294(C).
    19. Frank Gambou & Damien Guilbert & Michel Zasadzinski & Hugues Rafaralahy, 2022. "A Comprehensive Survey of Alkaline Electrolyzer Modeling: Electrical Domain and Specific Electrolyte Conductivity," Energies, MDPI, vol. 15(9), pages 1-20, May.
    20. Zheng, Nan & Zhang, Hanfei & Duan, Liqiang & Wang, Qiushi & Bischi, Aldo & Desideri, Umberto, 2023. "Techno-economic analysis of a novel solar-driven PEMEC-SOFC-based multi-generation system coupled parabolic trough photovoltaic thermal collector and thermal energy storage," Applied Energy, Elsevier, vol. 331(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:211:y:2023:i:c:p:202-213. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.