IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v192y2022icp805-814.html
   My bibliography  Save this article

Inequalities in photovoltaics modules reliability: From packaging to PV installation site

Author

Listed:
  • Dhimish, Mahmoud
  • Ahmad, Ameer
  • Tyrrell, Andy M.

Abstract

In recent years, the determination of the reliability of photovoltaic (PV) modules has been of ubiquitous interest to the PV industry. Therefore, this work reports on the reliability and degradation mechanism of 186 PV modules from packaging to installation stage. The paper shows that no cracks or hotspots affecting the PV modules before the packaging stage, while a minor reduction in the output power was observed at ±0.3%. The same PV modules were delivered using standard practice, and no further precautions were considered. Electroluminescent (EL) images of all PV modules were taken at the PV installation site, and it was discovered that 2.2% evolved cracks. Depending on the crack size, the estimated output power losses under standard test conditions varied from 0.53% to 1.43%. Furthermore, the PV modules were thermally inspected six months after being installed. It was found that hotspots developed in all the cracked PV modules, and their temperature increased from 10 °C to 20 °C. In addition, a potential induced degradation (PID) test was performed on the cracked PV modules and compared with a crack-free module. It was found that PID affected the modules with cracks more than the crack-free module.

Suggested Citation

  • Dhimish, Mahmoud & Ahmad, Ameer & Tyrrell, Andy M., 2022. "Inequalities in photovoltaics modules reliability: From packaging to PV installation site," Renewable Energy, Elsevier, vol. 192(C), pages 805-814.
    • Handle: RePEc:eee:renene:v:192:y:2022:i:c:p:805-814
    DOI: 10.1016/j.renene.2022.04.156
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148122006243
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2022.04.156?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Carlos Olalla & Md. Nazmul Hasan & Chris Deline & Dragan Maksimović, 2018. "Mitigation of Hot-Spots in Photovoltaic Systems Using Distributed Power Electronics," Energies, MDPI, vol. 11(4), pages 1-16, March.
    2. Dhimish, Mahmoud, 2020. "Micro cracks distribution and power degradation of polycrystalline solar cells wafer: Observations constructed from the analysis of 4000 samples," Renewable Energy, Elsevier, vol. 145(C), pages 466-477.
    3. Mahmoud Dhimish & Yihua Hu & Nigel Schofield & Romênia G. Vieira, 2020. "Mitigating Potential-Induced Degradation (PID) Using SiO 2 ARC Layer," Energies, MDPI, vol. 13(19), pages 1-12, October.
    4. Dhimish, Mahmoud & Badran, Ghadeer, 2020. "Current limiter circuit to avoid photovoltaic mismatch conditions including hot-spots and shading," Renewable Energy, Elsevier, vol. 145(C), pages 2201-2216.
    5. Akram, M. Waqar & Li, Guiqiang & Jin, Yi & Chen, Xiao & Zhu, Changan & Zhao, Xudong & Khaliq, Abdul & Faheem, M. & Ahmad, Ashfaq, 2019. "CNN based automatic detection of photovoltaic cell defects in electroluminescence images," Energy, Elsevier, vol. 189(C).
    6. Alex Mirtchev & Theodoros Mouselinos & Stylianos Syrigos & Emmanuel Tatakis, 2021. "Behavioral Analysis of Potential Induced Degradation on Photovoltaic Cells, Regeneration and Artificial Creation," Energies, MDPI, vol. 14(13), pages 1-16, June.
    7. Papargyri, Lamprini & Theristis, Marios & Kubicek, Bernhard & Krametz, Thomas & Mayr, Christoph & Papanastasiou, Panos & Georghiou, George E., 2020. "Modelling and experimental investigations of microcracks in crystalline silicon photovoltaics: A review," Renewable Energy, Elsevier, vol. 145(C), pages 2387-2408.
    8. Islam, M.A. & Hasanuzzaman, M. & Rahim, Nasrudin Abd, 2018. "A comparative investigation on in-situ and laboratory standard test of the potential induced degradation of crystalline silicon photovoltaic modules," Renewable Energy, Elsevier, vol. 127(C), pages 102-113.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Pramod R. Sonawane & Sheetal Bhandari & Rajkumar Bhimgonda Patil & Sameer Al-Dahidi, 2023. "Reliability and Criticality Analysis of a Large-Scale Solar Photovoltaic System Using Fault Tree Analysis Approach," Sustainability, MDPI, vol. 15(5), pages 1-24, March.
    2. Paweł Kut & Katarzyna Pietrucha-Urbanik, 2022. "Most Searched Topics in the Scientific Literature on Failures in Photovoltaic Installations," Energies, MDPI, vol. 15(21), pages 1-14, October.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Waqar Akram, M. & Li, Guiqiang & Jin, Yi & Chen, Xiao, 2022. "Failures of Photovoltaic modules and their Detection: A Review," Applied Energy, Elsevier, vol. 313(C).
    2. Mathhar Bdour & Zakariya Dalala & Mohammad Al-Addous & Ashraf Radaideh & Aseel Al-Sadi, 2020. "A Comprehensive Evaluation on Types of Microcracks and Possible Effects on Power Degradation in Photovoltaic Solar Panels," Sustainability, MDPI, vol. 12(16), pages 1-22, August.
    3. Tuhibur Rahman & Ahmed Al Mansur & Molla Shahadat Hossain Lipu & Md. Siddikur Rahman & Ratil H. Ashique & Mohamad Abou Houran & Rajvikram Madurai Elavarasan & Eklas Hossain, 2023. "Investigation of Degradation of Solar Photovoltaics: A Review of Aging Factors, Impacts, and Future Directions toward Sustainable Energy Management," Energies, MDPI, vol. 16(9), pages 1-30, April.
    4. Koo Lee & Sung Bae Cho & Junsin Yi & Hyo Sik Chang, 2022. "Simplified Recovery Process for Resistive Solder Bond (RSB) Hotspots Caused by Poor Soldering of Crystalline Silicon Photovoltaic Modules Using Resin," Energies, MDPI, vol. 15(13), pages 1-19, June.
    5. Mahmoud Dhimish, 2020. "Performance Ratio and Degradation Rate Analysis of 10-Year Field Exposed Residential Photovoltaic Installations in the UK and Ireland," Clean Technol., MDPI, vol. 2(2), pages 1-14, May.
    6. Ramadoss Janarthanan & R. Uma Maheshwari & Prashant Kumar Shukla & Piyush Kumar Shukla & Seyedali Mirjalili & Manoj Kumar, 2021. "Intelligent Detection of the PV Faults Based on Artificial Neural Network and Type 2 Fuzzy Systems," Energies, MDPI, vol. 14(20), pages 1-19, October.
    7. Chiwu Bu & Tao Liu & Tao Wang & Hai Zhang & Stefano Sfarra, 2023. "A CNN-Architecture-Based Photovoltaic Cell Fault Classification Method Using Thermographic Images," Energies, MDPI, vol. 16(9), pages 1-13, April.
    8. Waqas Ahmed & Jamil Ahmed Sheikh & Shahjadi Hisan Farjana & M. A. Parvez Mahmud, 2021. "Defects Impact on PV System GHG Mitigation Potential and Climate Change," Sustainability, MDPI, vol. 13(14), pages 1-9, July.
    9. Pratt, Lawrence & Govender, Devashen & Klein, Richard, 2021. "Defect detection and quantification in electroluminescence images of solar PV modules using U-net semantic segmentation," Renewable Energy, Elsevier, vol. 178(C), pages 1211-1222.
    10. Mahmoud Dhimish & Pavlos I. Lazaridis, 2022. "Approximating Shading Ratio Using the Total-Sky Imaging System: An Application for Photovoltaic Systems," Energies, MDPI, vol. 15(21), pages 1-16, November.
    11. Huang, Pengluan & Hu, Guoqiang & Zhao, Xiaodong & Lu, Luyi & Ding, Honggang & Li, Jianlan, 2022. "Effect of organics on the adhesion of dust to PV panel surfaces under condensation," Energy, Elsevier, vol. 261(PB).
    12. Liang, Tao & Fu, Tong & Hu, Cong & Chen, Xiaohang & Su, Shanhe & Chen, Jincan, 2021. "Optimum matching of photovoltaic–thermophotovoltaic cells efficiently utilizing full-spectrum solar energy," Renewable Energy, Elsevier, vol. 173(C), pages 942-952.
    13. Shirzad, Hossein & Barati, Ali Akbar & Ehteshammajd, Shaghayegh & Goli, Imaneh & Siamian, Narges & Moghaddam, Saghi Movahhed & Pour, Mahdad & Tan, Rong & Janečková, Kristina & Sklenička, Petr & Azadi,, 2022. "Agricultural land tenure system in Iran: An overview," Land Use Policy, Elsevier, vol. 123(C).
    14. Mirza, Adeel Feroz & Mansoor, Majad & Zhan, Keyu & Ling, Qiang, 2021. "High-efficiency swarm intelligent maximum power point tracking control techniques for varying temperature and irradiance," Energy, Elsevier, vol. 228(C).
    15. Sofiane Boulhidja & Adel Mellit & Sebastian Voswinckel & Vanni Lughi & Alessandro Ciocia & Filippo Spertino & Alessandro Massi Pavan, 2020. "Experimental Evidence of PID Effect on CIGS Photovoltaic Modules," Energies, MDPI, vol. 13(3), pages 1-16, January.
    16. Ji-Hoon Lim & Dong-In Lee & Ye-Ji Hyeon & Jae-Hyuk Choi & Han-Shin Youn, 2022. "Differential Power Processing Converter with an Integrated Transformer and Secondary Switch for Power Generation Optimization of Multiple Photovoltaic Submodules," Energies, MDPI, vol. 15(3), pages 1-18, February.
    17. Papargyri, Lamprini & Papanastasiou, Panos & Georghiou, George E., 2022. "Effect of materials and design on PV cracking under mechanical loading," Renewable Energy, Elsevier, vol. 199(C), pages 433-444.
    18. Natei Ermias Benti & Mesfin Diro Chaka & Addisu Gezahegn Semie, 2023. "Forecasting Renewable Energy Generation with Machine Learning and Deep Learning: Current Advances and Future Prospects," Sustainability, MDPI, vol. 15(9), pages 1-33, April.
    19. Hyunji Lee & Katherine A. Kim, 2018. "Design Considerations for Parallel Differential Power Processing Converters in a Photovoltaic-Powered Wearable Application," Energies, MDPI, vol. 11(12), pages 1-17, November.
    20. Li, B. & Delpha, C. & Diallo, D. & Migan-Dubois, A., 2021. "Application of Artificial Neural Networks to photovoltaic fault detection and diagnosis: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 138(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:192:y:2022:i:c:p:805-814. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.