IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v147y2020ip1p979-995.html
   My bibliography  Save this article

Experimental and numerical investigations on the thermal performance of a horizontal spiral-coil ground heat exchanger

Author

Listed:
  • Yang, Weibo
  • Xu, Rui
  • Wang, Feng
  • Chen, Shikun

Abstract

Horizontal spiral coil ground heat exchanger (HSGHE) has been used in ground source heat pump due to its efficiency and low cost. The influence laws of different factors on thermal performance of HSGHE are vital for its optimal design and operation. In this paper, a small scale test device of HSGHE was constructed to investigate thermal performance of HSGHE with different inlet temperatures, spiral pitches, surface wind speeds, and coil styles. The results indicate that the soil temperature interference distance is about 0.4 m for various inlet temperatures under the test conditions. At the same time, reducing spiral pitch can increase total HER, but it also decreases the HER per unit length of pipe. As for surface wind speed, the heat transfer of HSGHE can be enhanced by increasing surface wind speed, and the shallower the burial depth, the better the heat transfer enhancement effect. As far as heat transfer performance is concerned, the spiral coil is superior to slinky coil, but the slinky coil is higher than spiral coil in terms of soil thermal interference. From angle of improving heat exchange efficiency, it is advisable to increase wind speed and inlet fluid temperature, reduce the pitch and use spiral coil. A 3-D numerical model has been developed by COMSOL soft to further explore the influences of operation modes, soil types and coil diameters on thermal performance of HSGHE. The simulation results indicate that the soil temperature can be restored to a certain extent by using intermittent operation mode. The longer the interval time, the better the soil temperature resume and the more obvious the improvement of thermal performance. For the effects of soil type, the sandstone has the best heat transfer effect, followed by sand, and the clay is the worst. Nevertheless, in term of reducing the soil thermal interference, clay is the most advantageous. Additionally, increasing the coil diameter can improve total HER of HSGHE slightly, but it will also cause the reduction of the HER per unit length. Therefore, the coil diameter should be set reasonably according to the specific conditions in the engineering design.

Suggested Citation

  • Yang, Weibo & Xu, Rui & Wang, Feng & Chen, Shikun, 2020. "Experimental and numerical investigations on the thermal performance of a horizontal spiral-coil ground heat exchanger," Renewable Energy, Elsevier, vol. 147(P1), pages 979-995.
    • Handle: RePEc:eee:renene:v:147:y:2020:i:p1:p:979-995
    DOI: 10.1016/j.renene.2019.09.030
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148119313606
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2019.09.030?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Go, Gyu-Hyun & Lee, Seung-Rae & Yoon, Seok & Kim, Min-Jun, 2016. "Optimum design of horizontal ground-coupled heat pump systems using spiral-coil-loop heat exchangers," Applied Energy, Elsevier, vol. 162(C), pages 330-345.
    2. Selamat, Salsuwanda & Miyara, Akio & Kariya, Keishi, 2016. "Numerical study of horizontal ground heat exchangers for design optimization," Renewable Energy, Elsevier, vol. 95(C), pages 561-573.
    3. Xiong, Zeyu & Fisher, Daniel E. & Spitler, Jeffrey D., 2015. "Development and validation of a Slinky™ ground heat exchanger model," Applied Energy, Elsevier, vol. 141(C), pages 57-69.
    4. Yuan, Yanping & Cao, Xiaoling & Sun, Liangliang & Lei, Bo & Yu, Nanyang, 2012. "Ground source heat pump system: A review of simulation in China," Renewable and Sustainable Energy Reviews, Elsevier, vol. 16(9), pages 6814-6822.
    5. Jeon, Jun-Seo & Lee, Seung-Rae & Kim, Min-Jun, 2018. "A modified mathematical model for spiral coil-type horizontal ground heat exchangers," Energy, Elsevier, vol. 152(C), pages 732-743.
    6. Chengbin Zhang & Weibo Yang & Jingjing Yang & Suchen Wu & Yongping Chen, 2017. "Experimental Investigations and Numerical Simulation of Thermal Performance of a Horizontal Slinky-Coil Ground Heat Exchanger," Sustainability, MDPI, vol. 9(8), pages 1-22, August.
    7. Chong, Chiew Shan Anthony & Gan, Guohui & Verhoef, Anne & Garcia, Raquel Gonzalez & Vidale, Pier Luigi, 2013. "Simulation of thermal performance of horizontal slinky-loop heat exchangers for ground source heat pumps," Applied Energy, Elsevier, vol. 104(C), pages 603-610.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Jing, Zefeng & Wang, Huaijiu & Feng, Chenchen & Wang, Shuzhong, 2020. "Numerical study on the heat characteristics of a novel artificial seepage thermal storage based on the successive four seasons," Renewable Energy, Elsevier, vol. 160(C), pages 1185-1193.
    2. Hou, Gaoyang & Taherian, Hessam & Song, Ying & Jiang, Wei & Chen, Diyi, 2022. "A systematic review on optimal analysis of horizontal heat exchangers in ground source heat pump systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 154(C).
    3. Bulmez, A.M. & Ciofoaia, V. & Năstase, G. & Dragomir, G. & Brezeanu, A.I. & Şerban, A., 2022. "An experimental work on the performance of a solar-assisted ground-coupled heat pump using a horizontal ground heat exchanger," Renewable Energy, Elsevier, vol. 183(C), pages 849-865.
    4. Li, Zhibin & Huang, Wenbo & Chen, Juanwen & Cen, Jiwen & Cao, Wenjiong & Li, Feng & Jiang, Fangming, 2023. "An enhanced super-long gravity heat pipe geothermal system: Conceptual design and numerical study," Energy, Elsevier, vol. 267(C).
    5. Liu, Qinggong & Tao, Yao & Shi, Long & Huang, Yi & Peng, Yuanling & Wang, Yong & Tu, Jiyuan, 2023. "Experimental investigations on the thermal performance of a novel ground heat exchanger under the synergistic effects of shape-stabilized phase change material and nanofluid," Energy, Elsevier, vol. 284(C).
    6. Dinh, Ba Huu & Kim, Young-Sang & Yoon, Seok, 2022. "Experimental and numerical studies on the performance of horizontal U-type and spiral-coil-type ground heat exchangers considering economic aspects," Renewable Energy, Elsevier, vol. 186(C), pages 505-516.
    7. Shi, Yu & Cui, Qiliang & Song, Xianzhi & Xu, Fuqiang & Song, Guofeng, 2022. "Study on thermal performances of a horizontal ground heat exchanger geothermal system with different configurations and arrangements," Renewable Energy, Elsevier, vol. 193(C), pages 448-463.
    8. Yelnar Yerdesh & Tangnur Amanzholov & Abdurashid Aliuly & Abzal Seitov & Amankeldy Toleukhanov & Mohanraj Murugesan & Olivier Botella & Michel Feidt & Hua Sheng Wang & Alexandr Tsoy & Yerzhan Belyayev, 2022. "Experimental and Theoretical Investigations of a Ground Source Heat Pump System for Water and Space Heating Applications in Kazakhstan," Energies, MDPI, vol. 15(22), pages 1-25, November.
    9. Lee, Seokjae & Park, Sangwoo & Won, Jongmuk & Choi, Hangseok, 2021. "Influential factors on thermal performance of energy slabs equipped with an insulation layer," Renewable Energy, Elsevier, vol. 174(C), pages 823-834.
    10. Hang Zou & Peng Pei & Chen Wang & Dingyi Hao, 2021. "A numerical study on heat transfer performances of horizontal ground heat exchangers in ground-source heat pumps," PLOS ONE, Public Library of Science, vol. 16(5), pages 1-19, May.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Hou, Gaoyang & Taherian, Hessam & Song, Ying & Jiang, Wei & Chen, Diyi, 2022. "A systematic review on optimal analysis of horizontal heat exchangers in ground source heat pump systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 154(C).
    2. Chengbin Zhang & Weibo Yang & Jingjing Yang & Suchen Wu & Yongping Chen, 2017. "Experimental Investigations and Numerical Simulation of Thermal Performance of a Horizontal Slinky-Coil Ground Heat Exchanger," Sustainability, MDPI, vol. 9(8), pages 1-22, August.
    3. Bryś, Krystyna & Bryś, Tadeusz & Sayegh, Marderos Ara & Ojrzyńska, Hanna, 2020. "Characteristics of heat fluxes in subsurface shallow depth soil layer as a renewable thermal source for ground coupled heat pumps," Renewable Energy, Elsevier, vol. 146(C), pages 1846-1866.
    4. Jing, Zefeng & Wang, Huaijiu & Feng, Chenchen & Wang, Shuzhong, 2020. "Numerical study on the heat characteristics of a novel artificial seepage thermal storage based on the successive four seasons," Renewable Energy, Elsevier, vol. 160(C), pages 1185-1193.
    5. Md. Hasan Ali & Keishi Kariya & Akio Miyara, 2017. "Performance Analysis of Slinky Horizontal Ground Heat Exchangers for a Ground Source Heat Pump System," Resources, MDPI, vol. 6(4), pages 1-18, October.
    6. Jun-Seo Jeon & Seung-Rae Lee & Min-Jun Kim & Seok Yoon, 2018. "Suggestion of a Scale Factor to Design Spiral-Coil-Type Horizontal Ground Heat Exchangers," Energies, MDPI, vol. 11(10), pages 1-16, October.
    7. Tang, Fujiao & Nowamooz, Hossein, 2020. "Outlet temperatures of a slinky-type Horizontal Ground Heat Exchanger with the atmosphere-soil interaction," Renewable Energy, Elsevier, vol. 146(C), pages 705-718.
    8. Krzysztof Neupauer & Sebastian Pater & Krzysztof Kupiec, 2018. "Study of Ground Heat Exchangers in the Form of Parallel Horizontal Pipes Embedded in the Ground," Energies, MDPI, vol. 11(3), pages 1-16, February.
    9. Ľubomíra Gabániová & Dušan Kudelas & Martin Prčík, 2021. "Modelling Ground Collectors and Determination of the Influence of Technical Parameters, Installation and Geometry on the Soil," Energies, MDPI, vol. 14(21), pages 1-21, November.
    10. Somogyi, Viola & Sebestyén, Viktor & Nagy, Georgina, 2017. "Scientific achievements and regulation of shallow geothermal systems in six European countries – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P2), pages 934-952.
    11. Zhang, Guozhu & Cao, Ziming & Xiao, Suguang & Guo, Yimu & Li, Chenglin, 2022. "A promising technology of cold energy storage using phase change materials to cool tunnels with geothermal hazards," Renewable and Sustainable Energy Reviews, Elsevier, vol. 163(C).
    12. Sofyan, Sarwo Edhy & Hu, Eric & Kotousov, Andrei, 2016. "A new approach to modelling of a horizontal geo-heat exchanger with an internal source term," Applied Energy, Elsevier, vol. 164(C), pages 963-971.
    13. Jeon, Jun-Seo & Lee, Seung-Rae & Kim, Min-Jun, 2018. "A modified mathematical model for spiral coil-type horizontal ground heat exchangers," Energy, Elsevier, vol. 152(C), pages 732-743.
    14. Ogunleye, Oluwaseun & Singh, Rao Martand & Cecinato, Francesco & Chan Choi, Jung, 2020. "Effect of intermittent operation on the thermal efficiency of energy tunnels under varying tunnel air temperature," Renewable Energy, Elsevier, vol. 146(C), pages 2646-2658.
    15. Carotenuto, Alberto & Ciccolella, Michela & Massarotti, Nicola & Mauro, Alessandro, 2016. "Models for thermo-fluid dynamic phenomena in low enthalpy geothermal energy systems: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 60(C), pages 330-355.
    16. Selamat, Salsuwanda & Miyara, Akio & Kariya, Keishi, 2016. "Numerical study of horizontal ground heat exchangers for design optimization," Renewable Energy, Elsevier, vol. 95(C), pages 561-573.
    17. Yu Zhou & Asal Bidarmaghz & Nikolas Makasis & Guillermo Narsilio, 2021. "Ground-Source Heat Pump Systems: The Effects of Variable Trench Separations and Pipe Configurations in Horizontal Ground Heat Exchangers," Energies, MDPI, vol. 14(13), pages 1-15, June.
    18. Li, Biao & Han, Zongwei & Bai, Chenguang & Hu, Honghao, 2019. "The influence of soil thermal properties on the operation performance on ground source heat pump system," Renewable Energy, Elsevier, vol. 141(C), pages 903-913.
    19. Kayaci, Nurullah, 2020. "Energy and exergy analysis and thermo-economic optimization of the ground source heat pump integrated with radiant wall panel and fan-coil unit with floor heating or radiator," Renewable Energy, Elsevier, vol. 160(C), pages 333-349.
    20. Teguh Hady Ariwibowo & Akio Miyara, 2020. "Thermal Characteristics of Slinky-Coil Ground Heat Exchanger with Discrete Double Inclined Ribs," Resources, MDPI, vol. 9(9), pages 1-17, August.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:147:y:2020:i:p1:p:979-995. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.