IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v260y2022ics0360544222020394.html
   My bibliography  Save this article

Two-step coal-assisted water electrolysis for energy-saving hydrogen production at cell voltage of 1.2 V with current densities larger than 150 mA/cm2

Author

Listed:
  • Zhou, Wei
  • Chen, Shuai
  • Meng, Xiaoxiao
  • Li, Jiayi
  • Huang, Yuming
  • Gao, Jihui
  • Zhao, Guangbo
  • He, Yong
  • Qin, Yukun

Abstract

The application of water electrolysis for hydrogen production is inhibited by high energy consumption, primarily due to the sluggish anodic oxygen evolution reaction (OER). Replacing OER with a thermodynamically favorable reaction is significant to decrease the energy consumption. Coal-assisted water electrolysis (CAWE), with a theoretical potential of only 0.21 V, received special attention. However, the conventional CAWE suffers from poor stability to maintain high current, the continuous collision of coal particles with electrodes and membranes also causes the abrasion of these components. Here, a two-step CAWE system with the electrolysis system (ES) and hydrothermal system (HS) was proposed. The homogeneous ES generates H2 assisted by the anodic Fe2+ oxidation (Fe2+→Fe3+), while the heterogeneous HS supplies Fe2+ via the reduction of Fe3+ by coal slurry (Fe3+→Fe2+). Results showed that key operating parameters significantly affected the Fe3+ reduction by coal in HS. Additionally, a homemade continuous proton exchange membrane electrolyzer was used to test the two-step CAWE concept. The current density can achieve 154 mA/cm2 and remain 136 mA/cm2 after 5 cycles, at a low cell voltage of 1.2 V, corresponding to a low power consumption of 2.87 kWh/Nm3(H2).

Suggested Citation

  • Zhou, Wei & Chen, Shuai & Meng, Xiaoxiao & Li, Jiayi & Huang, Yuming & Gao, Jihui & Zhao, Guangbo & He, Yong & Qin, Yukun, 2022. "Two-step coal-assisted water electrolysis for energy-saving hydrogen production at cell voltage of 1.2 V with current densities larger than 150 mA/cm2," Energy, Elsevier, vol. 260(C).
    • Handle: RePEc:eee:energy:v:260:y:2022:i:c:s0360544222020394
    DOI: 10.1016/j.energy.2022.125145
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544222020394
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2022.125145?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Ju, HyungKuk & Badwal, Sukhvinder & Giddey, Sarbjit, 2018. "A comprehensive review of carbon and hydrocarbon assisted water electrolysis for hydrogen production," Applied Energy, Elsevier, vol. 231(C), pages 502-533.
    2. Chen, Shuai & Zhou, Wei & Ding, Yani & Zhao, Guangbo & Gao, Jihui, 2021. "Fe3+-mediated coal-assisted water electrolysis for hydrogen production: Roles of mineral matter and oxygen-containing functional groups in coal," Energy, Elsevier, vol. 220(C).
    3. Wu-Jun Liu & Zhuoran Xu & Dongting Zhao & Xiao-Qiang Pan & Hong-Chao Li & Xiao Hu & Zhi-Yong Fan & Wei-Kang Wang & Guo-Hua Zhao & Song Jin & George W. Huber & Han-Qing Yu, 2020. "Efficient electrochemical production of glucaric acid and H2 via glucose electrolysis," Nature Communications, Nature, vol. 11(1), pages 1-11, December.
    4. Ge, Lan & Gong, Xuzhong & Wang, Zhi & Zhao, Lixin & Wang, Yuhua & Wang, Mingyong, 2016. "Insight of anode reaction for CWS (coal water slurry) electrolysis for hydrogen production," Energy, Elsevier, vol. 96(C), pages 372-382.
    5. Y. X. Chen & A. Lavacchi & H. A. Miller & M. Bevilacqua & J. Filippi & M. Innocenti & A. Marchionni & W. Oberhauser & L. Wang & F. Vizza, 2014. "Nanotechnology makes biomass electrolysis more energy efficient than water electrolysis," Nature Communications, Nature, vol. 5(1), pages 1-6, September.
    6. Liu, Peng & Zhang, Dexiang & Wang, Lanlan & Zhou, Yang & Pan, Tieying & Lu, Xilan, 2016. "The structure and pyrolysis product distribution of lignite from different sedimentary environment," Applied Energy, Elsevier, vol. 163(C), pages 254-262.
    7. Fu Sun & Jingshan Qin & Zhiyu Wang & Mengzhou Yu & Xianhong Wu & Xiaoming Sun & Jieshan Qiu, 2021. "Energy-saving hydrogen production by chlorine-free hybrid seawater splitting coupling hydrazine degradation," Nature Communications, Nature, vol. 12(1), pages 1-11, December.
    8. Gong, Xuzhong & Wang, Mingyong & Liu, Yang & Wang, Zhi & Guo, Zhancheng, 2014. "Variation with time of cell voltage for coal slurry electrolysis in sulfuric acid," Energy, Elsevier, vol. 65(C), pages 233-239.
    9. Ying, Zhi & Geng, Zhen & Zheng, Xiaoyuan & Dou, Binlin & Cui, Guomin, 2022. "Improving water electrolysis assisted by anodic biochar oxidation for clean hydrogen production," Energy, Elsevier, vol. 238(PB).
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Fan, Yuqiang & Guan, Jun & He, Demin & Hong, Yu & Zhang, Qiumin, 2023. "The influence of inherent minerals on the constant-current electrolysis process of coal-water slurry," Energy, Elsevier, vol. 285(C).
    2. Hu, Bo & Xu, Lianfei & Li, Yang & Sun, Fei & Wang, Zhuozhi & Yang, Mengchi & Zhang, Yangyang & Kong, Wenwen & Shen, Boxiong & Wang, Xin & Yang, Jiancheng, 2024. "Biochar and Fe2+ mediation in hydrogen production by water electrolysis: Effects of physicochemical properties of biochars," Energy, Elsevier, vol. 297(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Fan, Yuqiang & Guan, Jun & He, Demin & Hong, Yu & Zhang, Qiumin, 2023. "The influence of inherent minerals on the constant-current electrolysis process of coal-water slurry," Energy, Elsevier, vol. 285(C).
    2. Hu, Bo & Xu, Lianfei & Li, Yang & Sun, Fei & Wang, Zhuozhi & Yang, Mengchi & Zhang, Yangyang & Kong, Wenwen & Shen, Boxiong & Wang, Xin & Yang, Jiancheng, 2024. "Biochar and Fe2+ mediation in hydrogen production by water electrolysis: Effects of physicochemical properties of biochars," Energy, Elsevier, vol. 297(C).
    3. Chen, Shuai & Zhou, Wei & Ding, Yani & Zhao, Guangbo & Gao, Jihui, 2021. "Fe3+-mediated coal-assisted water electrolysis for hydrogen production: Roles of mineral matter and oxygen-containing functional groups in coal," Energy, Elsevier, vol. 220(C).
    4. Huang, Yuming & Zhou, Wei & Xie, Liang & Li, Jiayi & He, Yong & Chen, Shuai & Meng, Xiaoxiao & Gao, Jihui & Qin, Yukun, 2022. "Edge and defect sites in porous activated coke enable highly efficient carbon-assisted water electrolysis for energy-saving hydrogen production," Renewable Energy, Elsevier, vol. 195(C), pages 283-292.
    5. Ying, Zhi & Geng, Zhen & Zheng, Xiaoyuan & Dou, Binlin & Cui, Guomin, 2022. "Improving water electrolysis assisted by anodic biochar oxidation for clean hydrogen production," Energy, Elsevier, vol. 238(PB).
    6. Kou, Kaikai & Zhou, Wei & Chen, Shuai & Gao, Jihui, 2021. "Mechanism investigation of carboxyl functional groups catalytic oxidation in coal assisted water electrolysis cell," Energy, Elsevier, vol. 226(C).
    7. Ju, HyungKuk & Badwal, Sukhvinder & Giddey, Sarbjit, 2018. "A comprehensive review of carbon and hydrocarbon assisted water electrolysis for hydrogen production," Applied Energy, Elsevier, vol. 231(C), pages 502-533.
    8. Hao Shi & Tanyuan Wang & Jianyun Liu & Weiwei Chen & Shenzhou Li & Jiashun Liang & Shuxia Liu & Xuan Liu & Zhao Cai & Chao Wang & Dong Su & Yunhui Huang & Lior Elbaz & Qing Li, 2023. "A sodium-ion-conducted asymmetric electrolyzer to lower the operation voltage for direct seawater electrolysis," Nature Communications, Nature, vol. 14(1), pages 1-11, December.
    9. Ding, Lu & Dai, Zhenghua & Guo, Qinghua & Yu, Guangsuo, 2017. "Effects of in-situ interactions between steam and coal on pyrolysis and gasification characteristics of pulverized coals and coal water slurry," Applied Energy, Elsevier, vol. 187(C), pages 627-639.
    10. Fan Li & Dong Liu & Ke Sun & Songheng Yang & Fangzheng Peng & Kexin Zhang & Guodong Guo & Yuan Si, 2024. "Towards a Future Hydrogen Supply Chain: A Review of Technologies and Challenges," Sustainability, MDPI, vol. 16(5), pages 1-36, February.
    11. Tao, Meng & Jl, Xie & Xm, Li & Jw, Ma & Yang, Yue, 2020. "Experimental study on the evolutional trend of pore structures and fractal dimension of low-rank coal rich clay subjected to a coupled thermo-hydro-mechanical-chemical environment," Energy, Elsevier, vol. 203(C).
    12. Ganceng Yang & Yanqing Jiao & Haijing Yan & Ying Xie & Chungui Tian & Aiping Wu & Yu Wang & Honggang Fu, 2022. "Unraveling the mechanism for paired electrocatalysis of organics with water as a feedstock," Nature Communications, Nature, vol. 13(1), pages 1-12, December.
    13. Liu, Hongwei & Wang, Yongzhen & Lv, Liang & Liu, Xiao & Wang, Ziqi & Liu, Jun, 2023. "Oxygen-enriched hierarchical porous carbons derived from lignite for high-performance supercapacitors," Energy, Elsevier, vol. 269(C).
    14. Jun Qi & Yadong Du & Qi Yang & Na Jiang & Jiachun Li & Yi Ma & Yangjun Ma & Xin Zhao & Jieshan Qiu, 2023. "Energy-saving and product-oriented hydrogen peroxide electrosynthesis enabled by electrochemistry pairing and product engineering," Nature Communications, Nature, vol. 14(1), pages 1-12, December.
    15. Libo Zhu & Jian Huang & Ge Meng & Tiantian Wu & Chang Chen & Han Tian & Yafeng Chen & Fantao Kong & Ziwei Chang & Xiangzhi Cui & Jianlin Shi, 2023. "Active site recovery and N-N bond breakage during hydrazine oxidation boosting the electrochemical hydrogen production," Nature Communications, Nature, vol. 14(1), pages 1-13, December.
    16. Yang Gao & Yurui Xue & Lu Qi & Chengyu Xing & Xuchen Zheng & Feng He & Yuliang Li, 2022. "Rhodium nanocrystals on porous graphdiyne for electrocatalytic hydrogen evolution from saline water," Nature Communications, Nature, vol. 13(1), pages 1-11, December.
    17. Liu, Peng & Le, Jiawei & Wang, Lanlan & Pan, Tieying & Lu, Xilan & Zhang, Dexiang, 2016. "Relevance of carbon structure to formation of tar and liquid alkane during coal pyrolysis," Applied Energy, Elsevier, vol. 183(C), pages 470-477.
    18. Efstathios E. Michaelides, 2021. "Thermodynamics, Energy Dissipation, and Figures of Merit of Energy Storage Systems—A Critical Review," Energies, MDPI, vol. 14(19), pages 1-41, September.
    19. Zhang, Xu & Wang, Qing & Cui, Da & Sun, Shipeng & Wang, Zhichao & Wang, Yuqi & Xu, Faxing & Wang, Zhenye & Zhang, Jinghui, 2024. "Mechanism of supercritical water gasification of corn stover for hydrogen-rich syngas: Composition of reaction products," Energy, Elsevier, vol. 288(C).
    20. Khalid Almutairi & Ali Mostafaeipour & Ehsan Jahanshahi & Erfan Jooyandeh & Youcef Himri & Mehdi Jahangiri & Alibek Issakhov & Shahariar Chowdhury & Seyyed Jalaladdin Hosseini Dehshiri & Seyyed Shahab, 2021. "Ranking Locations for Hydrogen Production Using Hybrid Wind-Solar: A Case Study," Sustainability, MDPI, vol. 13(8), pages 1-25, April.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:260:y:2022:i:c:s0360544222020394. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.