IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v386y2025ics0306261925002958.html
   My bibliography  Save this article

Analysis of electrochemical degradation phenomena of a 60-cell SOC stack operated in reversible SOFC/SOEC cycling mode

Author

Listed:
  • Lang, M.
  • Lee, Y.S.
  • Lee, I.S.
  • Szabo, P.
  • Hong, J.
  • Cho, J.
  • Costa, R.

Abstract

The paper presents the performance and degradation of a 1 kW SOC stack with 60 cells, which has been operated for 4200 h mainly in reversible SOFC/SOEC cycling mode. The stack was manufactured by the industrial project partner E&KOA (Daejeon, Korea) within the frame of the Korean-German project “Solid Oxide Reversible Fuel Cell / Electrolysis Stack” (SORFES). This project focused on the operation and improvement of a commercial scale 1 kW SOC stack in reversible SOFC/SOEC cycling mode in order to enhance the hydrogen productivity and its utilization. The reversible SOFC/SOEC cycles aimed to cover stack operation with intermittent renewable electricity supply (e.g. of photovoltaics and/or wind) based on the scenario of future expansions of gas pipelines, H2 storage capacities and electrical power grids within Europe. At the beginning of operation high performances and electrical efficiencies of 1068 W and 57 % in SOFC and 1950 W and 116 % in SOEC were achieved at 80 % fuel utilization. The stack revealed good homogeneity along the height with uniform electrical contacts of the cells in the stack. During reversible SOFC/SOEC cycling a rather stable stack behavior with degradation rates of −1.7 %/kh in SOFC mode and + 2.3 %/kh in SOEC mode was observed. In both modes the repeat units in the middle of the stack showed higher degradation compared to the bottom and top, which can be explained by thermo-mechanical stresses due to temperature gradients along the stack height during reversible SOFC/SOEC cycling. The degradation was dominated by the increase of the ohmic- and gas concentration resistances, whereas the degradation of the electrochemical activity of the electrodes played a minor role. It is very likely that the geometrical contact area between the oxygen electrode and the interconnector plate might have degraded. Therefore, further activities concentrate on the optimization of the reversible switching procedure in terms of temperature changes and gradients and on the development of contact elements with higher tolerance towards thermo-mechanical stresses.

Suggested Citation

  • Lang, M. & Lee, Y.S. & Lee, I.S. & Szabo, P. & Hong, J. & Cho, J. & Costa, R., 2025. "Analysis of electrochemical degradation phenomena of a 60-cell SOC stack operated in reversible SOFC/SOEC cycling mode," Applied Energy, Elsevier, vol. 386(C).
    • Handle: RePEc:eee:appene:v:386:y:2025:i:c:s0306261925002958
    DOI: 10.1016/j.apenergy.2025.125565
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261925002958
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2025.125565?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Zarabi Golkhatmi, Sanaz & Asghar, Muhammad Imran & Lund, Peter D., 2022. "A review on solid oxide fuel cell durability: Latest progress, mechanisms, and study tools," Renewable and Sustainable Energy Reviews, Elsevier, vol. 161(C).
    2. Zeng, Zezhi & Qian, Yuping & Zhang, Yangjun & Hao, Changkun & Dan, Dan & Zhuge, Weilin, 2020. "A review of heat transfer and thermal management methods for temperature gradient reduction in solid oxide fuel cell (SOFC) stacks," Applied Energy, Elsevier, vol. 280(C).
    3. Wetzel, Manuel & Gils, Hans Christian & Bertsch, Valentin, 2023. "Green energy carriers and energy sovereignty in a climate neutral European energy system," Renewable Energy, Elsevier, vol. 210(C), pages 591-603.
    4. Norman, E.A. & Maestre, V.M. & Ortiz, A. & Ortiz, I., 2024. "Steam electrolysis for green hydrogen generation. State of the art and research perspective," Renewable and Sustainable Energy Reviews, Elsevier, vol. 202(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Wang, Jingyi & Hua, Jing & Li, Dangjiang & Pan, Zehua & Xu, Xinhai & Jiao, Zhenjun & Zhong, Zheng, 2024. "Maximizing thermal integration performance in SOFC CHP systems: A top-down approach to configuration-parameter cooptimization," Energy, Elsevier, vol. 311(C).
    2. Cai, Weiqiang & Zhou, Ruidong & Wang, Chenxia & Xie, Chao & Xiao, Liusheng & Zhang, Zhonggang & Yang, Chao & Yuan, Jinliang, 2025. "On characteristics and research development of coupled fuel cell stack performance and stress," Applied Energy, Elsevier, vol. 388(C).
    3. Lee, Wooseok & Lang, Michael & Costa, Remi & Lee, In-Sung & Lee, Young-Sang & Hong, Jongsup, 2025. "Enhancing uniformity and performance in Solid Oxide Fuel Cells with double symmetry interconnect design," Applied Energy, Elsevier, vol. 381(C).
    4. Carballo, R. & Fouz, D.M. & López, I. & Iglesias, G., 2024. "Hydrokinetic energy site selection under high seasonality: The i-IHE index," Renewable Energy, Elsevier, vol. 237(PC).
    5. Liang, Zhaojian & Chen, Shanlin & Ni, Meng & Wang, Jingyi & Li, Mengying, 2024. "A novel control strategy to neutralize internal heat source within solid oxide electrolysis cell (SOEC) under variable solar power conditions," Applied Energy, Elsevier, vol. 371(C).
    6. Xia, Lei & Khosravi, Ali & Han, Minfang & Sun, Li, 2025. "Modelica based hybrid-dimensional dynamic modeling, multi-objective optimization and thermodynamic analysis of cross-flow SOFC system," Renewable Energy, Elsevier, vol. 241(C).
    7. Iliya Krastev Iliev & Antonina Andreevna Filimonova & Andrey Alexandrovich Chichirov & Natalia Dmitrievna Chichirova & Alexander Vadimovich Pechenkin & Artem Sergeevich Vinogradov, 2023. "Theoretical and Experimental Studies of Combined Heat and Power Systems with SOFCs," Energies, MDPI, vol. 16(4), pages 1-17, February.
    8. Wang, Yang & Wu, Chengru & Zhao, Siyuan & Wang, Jian & Zu, Bingfeng & Han, Minfang & Du, Qing & Ni, Meng & Jiao, Kui, 2022. "Coupling deep learning and multi-objective genetic algorithms to achieve high performance and durability of direct internal reforming solid oxide fuel cell," Applied Energy, Elsevier, vol. 315(C).
    9. Jiamiao Xie & Jingyang Li & Wenqian Hao & Fenghui Wang, 2023. "Influence of Interface Morphology on the Thermal Stress Distribution of SOFC under Inhomogeneous Temperature Field," Energies, MDPI, vol. 16(21), pages 1-13, October.
    10. Mohamad Fairus Rabuni & Tao Li & Mohd Hafiz Dzarfan Othman & Faidzul Hakim Adnan & Kang Li, 2023. "Progress in Solid Oxide Fuel Cells with Hydrocarbon Fuels," Energies, MDPI, vol. 16(17), pages 1-36, September.
    11. Ba, Zhichao & Meng, Kai & Ma, Yaxue & Xia, Yikun, 2024. "Discovering technological opportunities by identifying dynamic structure-coupling patterns and lead-lag distance between science and technology," Technological Forecasting and Social Change, Elsevier, vol. 200(C).
    12. Chuang Sheng & Yi Zheng & Rui Tian & Qian Xiang & Zhonghua Deng & Xiaowei Fu & Xi Li, 2023. "A Comparative Study of the Kalman Filter and the LSTM Network for the Remaining Useful Life Prediction of SOFC," Energies, MDPI, vol. 16(9), pages 1-16, April.
    13. Gulagi, Ashish & Keiner, Dominik & Canessa, Rafaella & Satymov, Rasul & ElSayed, Mai & Peer, Rebecca & Haas, Jannik & Breyer, Christian, 2025. "Analysing techno-economic impacts of integrating wave power to achieve carbon neutrality and electricity based fuel exports: A case for New Zealand," Energy, Elsevier, vol. 319(C).
    14. Gong, Chengyuan & Tu, Zhengkai & Hwa Chan, Siew, 2023. "A novel flow field design with flow re-distribution for advanced thermal management in Solid oxide fuel cell," Applied Energy, Elsevier, vol. 331(C).
    15. Xia, Zhiping & Zhao, Dongqi & Li, Yuanzheng & Deng, Zhonghua & Kupecki, Jakub & Fu, Xiaowei & Li, Xi, 2023. "Control-oriented dynamic process optimization of solid oxide electrolysis cell system with the gas characteristic regarding oxygen electrode delamination," Applied Energy, Elsevier, vol. 332(C).
    16. Liu, Yechang & Ning, Zhi & Sun, Chunhua & Zheng, Xuan & Wang, Lintao & Wei, Yongqi & Lv, Ming, 2025. "Experimental study on the operational characteristics and coupling relationships of burners, heat exchangers, and reformers in a kerosene solid oxide fuel cell," Applied Energy, Elsevier, vol. 382(C).
    17. Promsen, Mungmuang & Komatsu, Yosuke & Sciazko, Anna & Kaneko, Shozo & Shikazono, Naoki, 2023. "Power maximization and load range extension of solid oxide fuel cell operation by water cooling," Energy, Elsevier, vol. 276(C).
    18. Jie, Hao & Liao, Jiawei & Zhu, Guozhu & Hong, Weirong, 2024. "Nonlinear model predictive control of direct internal reforming solid oxide fuel cells via PDAE-constrained dynamic optimization," Applied Energy, Elsevier, vol. 360(C).
    19. Yin, Linfei & Liu, Dongduan, 2023. "Adaptive multistep model predictive control for tubular grid-connected solid oxide fuel cells," Renewable Energy, Elsevier, vol. 216(C).
    20. Li, Jiawen & Yu, Tao & Yang, Bo, 2021. "A data-driven output voltage control of solid oxide fuel cell using multi-agent deep reinforcement learning," Applied Energy, Elsevier, vol. 304(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:386:y:2025:i:c:s0306261925002958. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.