IDEAS home Printed from https://ideas.repec.org/a/eee/rensus/v135y2021ics1364032120304597.html
   My bibliography  Save this article

“Drop-in” fuel production from biomass: Critical review on techno-economic feasibility and sustainability

Author

Listed:
  • Kargbo, Hannah
  • Harris, Jonathan Stuart
  • Phan, Anh N.

Abstract

This paper reviews the technological and economical feasibilities as well as sustainable assessment of approaches (thermochemical and biochemical) applied for sustainable “drop-in” fuel production from lignocellulosic sources. The challenges for each pathway to produce “drop-in” fuels are covered. Currently “drop-in” fuel production cost is approximately 2 times (~5–6$/gallon) higher than fossil fuels (3$/gallon), especially with the use of 2nd generation feedstocks. The primary sources of cost with “drop-in” fuel production are feedstock cost (40–60% of the total production cost), syngas cleaning and conditioning to meet Fischer-Tropsch synthesis requirement (12–15% of the total production cost) and bio oil upgrading (14–18% of the total production cost) in the case of pyrolysis and hydrothermal liquefaction (HTL). The most influential factors on the life cycle analysis (LCA) were biomass cultivation, harvesting, biomass pre-treatment, and transportation. Therefore, robust processes that can use local waste biomass are far more environmental and economically viable, especially as biofuel from second generation have a greater potential to reduce greenhouse gas emissions (50–100%) than first generation biofuels (50–90%) when land use changes are omitted in the LCA. The sustainability of biofuels is pre-dominantly dependant on the sustainability of the initial biomass, with 2nd generation feedstocks being more sustainable than 1st generation. Gasification-FTS is considered as the most promising technique for “drop-in” fuel production over pyrolysis and HTL due to its flexibility towards feedstock acceptance and the ability to produced high yields of liquid fuel together with other economically viable biofuels such as electricity and heat. Biochemical routes (i.e.fermentation) to “drop-in” fuels are still in their early development stages, and therefore require more studies and pilot-scale experiments in order to discover an economic and sustainable means of using these methods.

Suggested Citation

  • Kargbo, Hannah & Harris, Jonathan Stuart & Phan, Anh N., 2021. "“Drop-in” fuel production from biomass: Critical review on techno-economic feasibility and sustainability," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    • Handle: RePEc:eee:rensus:v:135:y:2021:i:c:s1364032120304597
    DOI: 10.1016/j.rser.2020.110168
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S1364032120304597
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.rser.2020.110168?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Mafakheri, Fereshteh & Nasiri, Fuzhan, 2014. "Modeling of biomass-to-energy supply chain operations: Applications, challenges and research directions," Energy Policy, Elsevier, vol. 67(C), pages 116-126.
    2. Fortier, Marie-Odile P. & Roberts, Griffin W. & Stagg-Williams, Susan M. & Sturm, Belinda S.M., 2014. "Life cycle assessment of bio-jet fuel from hydrothermal liquefaction of microalgae," Applied Energy, Elsevier, vol. 122(C), pages 73-82.
    3. Iribarren, Diego & Susmozas, Ana & Dufour, Javier, 2013. "Life-cycle assessment of Fischer–Tropsch products from biosyngas," Renewable Energy, Elsevier, vol. 59(C), pages 229-236.
    4. Yi Yang & David Tilman & Clarence Lehman & Jared J. Trost, 2018. "Sustainable intensification of high-diversity biomass production for optimal biofuel benefits," Nature Sustainability, Nature, vol. 1(11), pages 686-692, November.
    5. Carolan Joseph E. & Joshi Satish V. & Dale Bruce E., 2007. "Technical and Financial Feasibility Analysis of Distributed Bioprocessing Using Regional Biomass Pre-Processing Centers," Journal of Agricultural & Food Industrial Organization, De Gruyter, vol. 5(2), pages 1-29, December.
    6. Maung, Thein A. & Gustafson, Cole R. & Saxowsky, David M. & Nowatzki, John & Miljkovic, Tatjana & Ripplinger, David, 2013. "The logistics of supplying single vs. multi-crop cellulosic feedstocks to a biorefinery in southeast North Dakota," Applied Energy, Elsevier, vol. 109(C), pages 229-238.
    7. Sorda, Giovanni & Banse, Martin & Kemfert, Claudia, 2010. "An overview of biofuel policies across the world," Energy Policy, Elsevier, vol. 38(11), pages 6977-6988, November.
    8. Gambelli, Danilo & Alberti, Francesca & Solfanelli, Francesco & Vairo, Daniela & Zanoli, Raffaele, 2017. "Third generation algae biofuels in Italy by 2030: A scenario analysis using Bayesian networks," Energy Policy, Elsevier, vol. 103(C), pages 165-178.
    9. Väisänen, S. & Havukainen, J. & Uusitalo, V. & Havukainen, M. & Soukka, R. & Luoranen, M., 2016. "Carbon footprint of biobutanol by ABE fermentation from corn and sugarcane," Renewable Energy, Elsevier, vol. 89(C), pages 401-410.
    10. Akhtar, Javaid & Amin, Nor Aishah Saidina, 2011. "A review on process conditions for optimum bio-oil yield in hydrothermal liquefaction of biomass," Renewable and Sustainable Energy Reviews, Elsevier, vol. 15(3), pages 1615-1624, April.
    11. de Jong, Sierk & Hoefnagels, Ric & Wetterlund, Elisabeth & Pettersson, Karin & Faaij, André & Junginger, Martin, 2017. "Cost optimization of biofuel production – The impact of scale, integration, transport and supply chain configurations," Applied Energy, Elsevier, vol. 195(C), pages 1055-1070.
    12. Havlík, Petr & Schneider, Uwe A. & Schmid, Erwin & Böttcher, Hannes & Fritz, Steffen & Skalský, Rastislav & Aoki, Kentaro & Cara, Stéphane De & Kindermann, Georg & Kraxner, Florian & Leduc, Sylvain & , 2011. "Global land-use implications of first and second generation biofuel targets," Energy Policy, Elsevier, vol. 39(10), pages 5690-5702, October.
    13. Naik, S.N. & Goud, Vaibhav V. & Rout, Prasant K. & Dalai, Ajay K., 2010. "Production of first and second generation biofuels: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 14(2), pages 578-597, February.
    14. Carriquiry, Miguel A. & Du, Xiaodong & Timilsina, Govinda R., 2011. "Second generation biofuels: Economics and policies," Energy Policy, Elsevier, vol. 39(7), pages 4222-4234, July.
    15. Anselm Eisentraut, 2010. "Sustainable Production of Second-Generation Biofuels: Potential and Perspectives in Major Economies and Developing Countries," IEA Energy Papers 2010/1, OECD Publishing.
    16. Xiaoxia Zou & Yu’e Li & Kuo Li & Roger Cremades & Qingzhu Gao & Yunfan Wan & Xiaobo Qin, 2015. "Greenhouse gas emissions from agricultural irrigation in China," Mitigation and Adaptation Strategies for Global Change, Springer, vol. 20(2), pages 295-315, February.
    17. Francisco F. C. Mello & Carlos E. P. Cerri & Christian A. Davies & N. Michele Holbrook & Keith Paustian & Stoécio M. F. Maia & Marcelo V. Galdos & Martial Bernoux & Carlos C. Cerri, 2014. "Payback time for soil carbon and sugar-cane ethanol," Nature Climate Change, Nature, vol. 4(7), pages 605-609, July.
    18. Wijayanta, Agung Tri & Aziz, Muhammad, 2019. "Ammonia production from algae via integrated hydrothermal gasification, chemical looping, N2 production, and NH3 synthesis," Energy, Elsevier, vol. 174(C), pages 331-338.
    19. Zhu, Yunhua & Biddy, Mary J. & Jones, Susanne B. & Elliott, Douglas C. & Schmidt, Andrew J., 2014. "Techno-economic analysis of liquid fuel production from woody biomass via hydrothermal liquefaction (HTL) and upgrading," Applied Energy, Elsevier, vol. 129(C), pages 384-394.
    20. Ribeiro, Lauro A. & da Silva, Patrícia Pereira & Mata, Teresa M. & Martins, António A., 2015. "Prospects of using microalgae for biofuels production: Results of a Delphi study," Renewable Energy, Elsevier, vol. 75(C), pages 799-804.
    21. Castello, Daniele & Haider, Muhammad Salman & Rosendahl, Lasse Aistrup, 2019. "Catalytic upgrading of hydrothermal liquefaction biocrudes: Different challenges for different feedstocks," Renewable Energy, Elsevier, vol. 141(C), pages 420-430.
    22. Perpiñá, C. & Alfonso, D. & Pérez-Navarro, A. & Peñalvo, E. & Vargas, C. & Cárdenas, R., 2009. "Methodology based on Geographic Information Systems for biomass logistics and transport optimisation," Renewable Energy, Elsevier, vol. 34(3), pages 555-565.
    23. Czekała, Wojciech & Bartnikowska, Sylwia & Dach, Jacek & Janczak, Damian & Smurzyńska, Anna & Kozłowski, Kamil & Bugała, Artur & Lewicki, Andrzej & Cieślik, Marta & Typańska, Dorota & Mazurkiewicz, Ja, 2018. "The energy value and economic efficiency of solid biofuels produced from digestate and sawdust," Energy, Elsevier, vol. 159(C), pages 1118-1122.
    24. Bhutto, Abdul Waheed & Qureshi, Khadija & Harijan, Khanji & Abro, Rashid & Abbas, Tauqeer & Bazmi, Aqeel Ahmed & Karim, Sadia & Yu, Guangren, 2017. "Insight into progress in pre-treatment of lignocellulosic biomass," Energy, Elsevier, vol. 122(C), pages 724-745.
    25. Luthra, Sunil & Kumar, Sanjay & Garg, Dixit & Haleem, Abid, 2015. "Barriers to renewable/sustainable energy technologies adoption: Indian perspective," Renewable and Sustainable Energy Reviews, Elsevier, vol. 41(C), pages 762-776.
    26. Menten, Fabio & Chèze, Benoît & Patouillard, Laure & Bouvart, Frédérique, 2013. "A review of LCA greenhouse gas emissions results for advanced biofuels: The use of meta-regression analysis," Renewable and Sustainable Energy Reviews, Elsevier, vol. 26(C), pages 108-134.
    27. Bajwa, Dilpreet S. & Peterson, Tyler & Sharma, Neeta & Shojaeiarani, Jamileh & Bajwa, Sreekala G., 2018. "A review of densified solid biomass for energy production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 96(C), pages 296-305.
    28. Taylor, Benjamin & Xiao, Ning & Sikorski, Janusz & Yong, Minloon & Harris, Tom & Helme, Tim & Smallbone, Andrew & Bhave, Amit & Kraft, Markus, 2013. "Techno-economic assessment of carbon-negative algal biodiesel for transport solutions," Applied Energy, Elsevier, vol. 106(C), pages 262-274.
    29. De Laporte, Aaron V. & Ripplinger, David G., 2019. "The effects of site selection, opportunity costs and transportation costs on bioethanol production," Renewable Energy, Elsevier, vol. 131(C), pages 73-82.
    30. Edward Frank & Amgad Elgowainy & Jeongwoo Han & Zhichao Wang, 2013. "Life cycle comparison of hydrothermal liquefaction and lipid extraction pathways to renewable diesel from algae," Mitigation and Adaptation Strategies for Global Change, Springer, vol. 18(1), pages 137-158, January.
    31. García-Velásquez, Carlos A. & Cardona, Carlos A., 2019. "Comparison of the biochemical and thermochemical routes for bioenergy production: A techno-economic (TEA), energetic and environmental assessment," Energy, Elsevier, vol. 172(C), pages 232-242.
    32. van Dyken, Silke & Bakken, Bjorn H. & Skjelbred, Hans I., 2010. "Linear mixed-integer models for biomass supply chains with transport, storage and processing," Energy, Elsevier, vol. 35(3), pages 1338-1350.
    33. Mohr, Alison & Raman, Sujatha, 2013. "Lessons from first generation biofuels and implications for the sustainability appraisal of second generation biofuels," Energy Policy, Elsevier, vol. 63(C), pages 114-122.
    34. Zhang, Yajing & Bi, Peiyan & Wang, Jicong & Jiang, Peiwen & Wu, Xiaoping & Xue, He & Liu, Junxu & Zhou, Xiaoguo & Li, Quanxin, 2015. "Production of jet and diesel biofuels from renewable lignocellulosic biomass," Applied Energy, Elsevier, vol. 150(C), pages 128-137.
    35. Arkadiusz Dyjakon, 2018. "Harvesting and Baling of Pruned Biomass in Apple Orchards for Energy Production," Energies, MDPI, vol. 11(7), pages 1-14, June.
    36. Santamaría, Marta & Azqueta, Diego, 2015. "Promoting biofuels use in Spain: A cost-benefit analysis," Renewable and Sustainable Energy Reviews, Elsevier, vol. 50(C), pages 1415-1424.
    37. Dupuis, Daniel P. & Grim, R. Gary & Nelson, Eric & Tan, Eric C.D. & Ruddy, Daniel A. & Hernandez, Sergio & Westover, Tyler & Hensley, Jesse E. & Carpenter, Daniel, 2019. "High-Octane Gasoline from Biomass: Experimental, Economic, and Environmental Assessment," Applied Energy, Elsevier, vol. 241(C), pages 25-33.
    38. Hassan, Shady S. & Williams, Gwilym A. & Jaiswal, Amit K., 2019. "Moving towards the second generation of lignocellulosic biorefineries in the EU: Drivers, challenges, and opportunities," Renewable and Sustainable Energy Reviews, Elsevier, vol. 101(C), pages 590-599.
    39. Uslu, Ayla & Faaij, André P.C. & Bergman, P.C.A., 2008. "Pre-treatment technologies, and their effect on international bioenergy supply chain logistics. Techno-economic evaluation of torrefaction, fast pyrolysis and pelletisation," Energy, Elsevier, vol. 33(8), pages 1206-1223.
    40. Yang, Zixu & Qian, Kezhen & Zhang, Xuesong & Lei, Hanwu & Xin, Chunhua & Zhang, Yayun & Qian, Moriko & Villota, Elmar, 2018. "Process design and economics for the conversion of lignocellulosic biomass into jet fuel range cycloalkanes," Energy, Elsevier, vol. 154(C), pages 289-297.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Lo, Shirleen Lee Yuen & How, Bing Shen & Teng, Sin Yong & Lam, Hon Loong & Lim, Chun Hsion & Rhamdhani, Muhammad Akbar & Sunarso, Jaka, 2021. "Stochastic techno-economic evaluation model for biomass supply chain: A biomass gasification case study with supply chain uncertainties," Renewable and Sustainable Energy Reviews, Elsevier, vol. 152(C).
    2. Yang, Zaoli & Ahmad, Salman & Bernardi, Andrea & Shang, Wen-long & Xuan, Jin & Xu, Bing, 2023. "Evaluating alternative low carbon fuel technologies using a stakeholder participation-based q-rung orthopair linguistic multi-criteria framework," Applied Energy, Elsevier, vol. 332(C).
    3. Do, Thai Ngan & Hur, Young Gul & Chung, Hegwon & Kim, Jiyong, 2023. "Potentials and benefit assessment of green fuels from residue gas via gas-to-liquid," Renewable and Sustainable Energy Reviews, Elsevier, vol. 182(C).
    4. Parrado-Hernando, Gonzalo & Pfeifer, Antun & Frechoso, Fernando & Miguel González, Luis Javier & Duić, Neven, 2022. "A novel approach to represent the energy system in integrated assessment models," Energy, Elsevier, vol. 258(C).
    5. Witcover, Julie, 2021. "What Happened and Will Happen with Biofuels? Review and Prospects for Non-Conventional Biofuels in California and the U.S.: Supply, Cost, and Potential GHG Reductions," Institute of Transportation Studies, Working Paper Series qt7624q040, Institute of Transportation Studies, UC Davis.
    6. Mariyam, Sabah & Shahbaz, Muhammad & Al-Ansari, Tareq & Mackey, Hamish. R & McKay, Gordon, 2022. "A critical review on co-gasification and co-pyrolysis for gas production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 161(C).
    7. Ebrahimi, Sajad & Haji Esmaeili, Seyed Ali & Sobhani, Ahmad & Szmerekovsky, Joseph, 2022. "Renewable jet fuel supply chain network design: Application of direct monetary incentives," Applied Energy, Elsevier, vol. 310(C).
    8. Kim, Kyeongsu & Suh, Young-Woong & Ha, Jeong-Myeong & An, Jinjoo & Lee, Ung, 2023. "A comprehensive analysis of biphasic reaction system for economical biodiesel production process," Renewable and Sustainable Energy Reviews, Elsevier, vol. 173(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Jambo, Siti Azmah & Abdulla, Rahmath & Mohd Azhar, Siti Hajar & Marbawi, Hartinie & Gansau, Jualang Azlan & Ravindra, Pogaku, 2016. "A review on third generation bioethanol feedstock," Renewable and Sustainable Energy Reviews, Elsevier, vol. 65(C), pages 756-769.
    2. Schillo, R. Sandra & Isabelle, Diane A. & Shakiba, Abtin, 2017. "Linking advanced biofuels policies with stakeholder interests: A method building on Quality Function Deployment," Energy Policy, Elsevier, vol. 100(C), pages 126-137.
    3. Mafakheri, Fereshteh & Nasiri, Fuzhan, 2014. "Modeling of biomass-to-energy supply chain operations: Applications, challenges and research directions," Energy Policy, Elsevier, vol. 67(C), pages 116-126.
    4. Lim, Chun Hsion & Lam, Hon Loong & Ng, Wendy Pei Qin, 2018. "A novel HAZOP approach for literature review on biomass supply chain optimisation model," Energy, Elsevier, vol. 146(C), pages 13-25.
    5. Cambero, Claudia & Sowlati, Taraneh, 2014. "Assessment and optimization of forest biomass supply chains from economic, social and environmental perspectives – A review of literature," Renewable and Sustainable Energy Reviews, Elsevier, vol. 36(C), pages 62-73.
    6. Lorenzo Di Lucia & Barbara Ribeiro, 2018. "Enacting Responsibilities in Landscape Design: The Case of Advanced Biofuels," Sustainability, MDPI, vol. 10(11), pages 1-15, November.
    7. Md Abu Helal & Nathaniel Anderson & Yu Wei & Matthew Thompson, 2023. "A Review of Biomass-to-Bioenergy Supply Chain Research Using Bibliometric Analysis and Visualization," Energies, MDPI, vol. 16(3), pages 1-32, January.
    8. Tzanetis, Konstantinos F. & Posada, John A. & Ramirez, Andrea, 2017. "Analysis of biomass hydrothermal liquefaction and biocrude-oil upgrading for renewable jet fuel production: The impact of reaction conditions on production costs and GHG emissions performance," Renewable Energy, Elsevier, vol. 113(C), pages 1388-1398.
    9. Bengtsson, Selma & Fridell, Erik & Andersson, Karin, 2012. "Environmental assessment of two pathways towards the use of biofuels in shipping," Energy Policy, Elsevier, vol. 44(C), pages 451-463.
    10. Robert S. Weber & Johnathan E. Holladay & Cynthia Jenks & Ellen A. Panisko & Lesley J. Snowden‐Swan & Magdalena Ramirez‐Corredores & Brian Baynes & Largus T. Angenent & Dane Boysen, 2018. "Modularized production of fuels and other value‐added products from distributed, wasted, or stranded feedstocks," Wiley Interdisciplinary Reviews: Energy and Environment, Wiley Blackwell, vol. 7(6), November.
    11. Jerome A. Ramirez & Richard J. Brown & Thomas J. Rainey, 2015. "A Review of Hydrothermal Liquefaction Bio-Crude Properties and Prospects for Upgrading to Transportation Fuels," Energies, MDPI, vol. 8(7), pages 1-30, July.
    12. Bi, Zheting & Zhang, Ji & Zhu, Zeying & Liang, Yanna & Wiltowski, Tomasz, 2018. "Generating biocrude from partially defatted Cryptococcus curvatus yeast residues through catalytic hydrothermal liquefaction," Applied Energy, Elsevier, vol. 209(C), pages 435-444.
    13. Liu, Tingting & McConkey, Brian & Huffman, Ted & Smith, Stephen & MacGregor, Bob & Yemshanov, Denys & Kulshreshtha, Suren, 2014. "Potential and impacts of renewable energy production from agricultural biomass in Canada," Applied Energy, Elsevier, vol. 130(C), pages 222-229.
    14. Alizadeh, Reza & Lund, Peter D. & Soltanisehat, Leili, 2020. "Outlook on biofuels in future studies: A systematic literature review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).
    15. Janda, Karel & Kristoufek, Ladislav & Zilberman, David, "undated". "Biofuels: review of policies and impacts," CUDARE Working Papers 120415, University of California, Berkeley, Department of Agricultural and Resource Economics.
    16. Maity, Sunil K., 2015. "Opportunities, recent trends and challenges of integrated biorefinery: Part I," Renewable and Sustainable Energy Reviews, Elsevier, vol. 43(C), pages 1427-1445.
    17. Cruce, Jesse R. & Quinn, Jason C., 2019. "Economic viability of multiple algal biorefining pathways and the impact of public policies," Applied Energy, Elsevier, vol. 233, pages 735-746.
    18. Tomasz Bochenski & Tanmay Chaturvedi & Mette Hedegaard Thomsen & Jens Ejbye Schmidt, 2019. "Evaluation of Marine Synechococcus for an Algal Biorefinery in Arid Regions," Energies, MDPI, vol. 12(12), pages 1-13, June.
    19. Oumer, A.N. & Hasan, M.M. & Baheta, Aklilu Tesfamichael & Mamat, Rizalman & Abdullah, A.A., 2018. "Bio-based liquid fuels as a source of renewable energy: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 88(C), pages 82-98.
    20. Correa, Diego F. & Beyer, Hawthorne L. & Fargione, Joseph E. & Hill, Jason D. & Possingham, Hugh P. & Thomas-Hall, Skye R. & Schenk, Peer M., 2019. "Towards the implementation of sustainable biofuel production systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 107(C), pages 250-263.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:rensus:v:135:y:2021:i:c:s1364032120304597. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/600126/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.