IDEAS home Printed from https://ideas.repec.org/a/gam/jsusta/v14y2022i23p15666-d983377.html
   My bibliography  Save this article

Operating Range, Performance and Emissions of an HCCI Engine Fueled with Fusel Oil/Diethyl Ether: An Experimental Study

Author

Listed:
  • Seyfi Polat

    (Department of Mechanical Engineering, Faculty of Engineering, Hitit University, Çorum 19030, Turkey)

  • Alper Calam

    (Vocational School of Technical Sciences, Gazi University, Ankara 06374, Turkey)

  • Seyed Mohammad Safieddin Ardebili

    (Department of Biosystems Engineering, Shahid Chamran University of Ahvaz, Ahvaz 61369-84847, Iran)

  • Fatih Şahin

    (Automotive Engineering Department, Faculty of Technology, Gazi University, Ankara 06500, Turkey)

  • Alexandru Andrei Boroiu

    (Department of Automotive and Transport, University of Pitesti, 110040 Pitesti, Romania)

  • Hamit Solmaz

    (Automotive Engineering Department, Faculty of Technology, Gazi University, Ankara 06500, Turkey)

Abstract

The main disadvantages of HCCI engines are the knocking tendency at high engine loads, the challenge of the start of the combustion, control of the combustion phase, and the narrow operating range. In this study, we aimed to control the combustion processes in HCCI engines and to expand their working range by improving the fuel properties of fusel oil by the addition of diethyl ether. Thus, the variations in the in-cylinder pressure, rate of heat release, indicated mean effective pressure, start of combustion, combustion duration, CA50, indicated thermal efficiency, mean pressure rise rate, hydrocarbon and carbon monoxide emissions were investigated. It was observed that the in-cylinder pressure and rate of heat release were taken into advance and the test engine could be operated for a wider range by increasing the diethyl ether ratio in the blend. The indicated mean effective pressure increased by 67.5% with DEE40 fuel compared to the DEE80. Under the same operating conditions, HC and CO emissions decreased by 41.6% and 56.2%, in use of DEE40. Furthermore, the highest indicated thermal efficiency was obtained as 42.5% with DEE60 fuel. Maximum hydrocarbon and carbon monoxide emissions were observed with DEE80 fuel as 0.532% and 549 ppm, respectively.

Suggested Citation

  • Seyfi Polat & Alper Calam & Seyed Mohammad Safieddin Ardebili & Fatih Şahin & Alexandru Andrei Boroiu & Hamit Solmaz, 2022. "Operating Range, Performance and Emissions of an HCCI Engine Fueled with Fusel Oil/Diethyl Ether: An Experimental Study," Sustainability, MDPI, vol. 14(23), pages 1-19, November.
    • Handle: RePEc:gam:jsusta:v:14:y:2022:i:23:p:15666-:d:983377
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2071-1050/14/23/15666/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2071-1050/14/23/15666/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Awad, Omar I. & Ali, Obed M. & Mamat, Rizalman & Abdullah, A.A. & Najafi, G. & Kamarulzaman, M.K. & Yusri, I.M. & Noor, M.M., 2017. "Using fusel oil as a blend in gasoline to improve SI engine efficiencies: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 69(C), pages 1232-1242.
    2. Awad, Omar I. & Mamat, Rizalman & Ibrahim, Thamir K. & Kettner, Maurice & Kadirgama, K. & Leman, A.M. & Saiful, A.I.M., 2018. "Effects of fusel oil water content reduction on fuel properties, performance and emissions of SI engine fueled with gasoline -fusel oil blends," Renewable Energy, Elsevier, vol. 118(C), pages 858-869.
    3. Awad, Omar I. & Ali, Obed M. & Hammid, Ali Thaeer & Mamat, Rizalman, 2018. "Impact of fusel oil moisture reduction on the fuel properties and combustion characteristics of SI engine fueled with gasoline-fusel oil blends," Renewable Energy, Elsevier, vol. 123(C), pages 79-91.
    4. Sudheesh, K. & Mallikarjuna, J.M., 2010. "Diethyl ether as an ignition improver for biogas homogeneous charge compression ignition (HCCI) operation - An experimental investigation," Energy, Elsevier, vol. 35(9), pages 3614-3622.
    5. M. Mofijur & M.M. Hasan & T.M.I. Mahlia & S.M. Ashrafur Rahman & A.S. Silitonga & Hwai Chyuan Ong, 2019. "Performance and Emission Parameters of Homogeneous Charge Compression Ignition (HCCI) Engine: A Review," Energies, MDPI, vol. 12(18), pages 1-21, September.
    6. Rakopoulos, Dimitrios C. & Rakopoulos, Constantine D. & Giakoumis, Evangelos G. & Dimaratos, Athanasios M., 2012. "Characteristics of performance and emissions in high-speed direct injection diesel engine fueled with diethyl ether/diesel fuel blends," Energy, Elsevier, vol. 43(1), pages 214-224.
    7. Montoya, Alejandro & Guéret, Christelle & Mendoza, Jorge E. & Villegas, Juan G., 2017. "The electric vehicle routing problem with nonlinear charging function," Transportation Research Part B: Methodological, Elsevier, vol. 103(C), pages 87-110.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Süleyman Şimşek & Hasan Saygın & Bülent Özdalyan, 2020. "Improvement of Fusel Oil Features and Effect of Its Use in Different Compression Ratios for an SI Engine on Performance and Emission," Energies, MDPI, vol. 13(7), pages 1-14, April.
    2. Hagos, Ftwi Y. & Ali, Obed M. & Mamat, Rizalman & Abdullah, Abdul A., 2017. "Effect of emulsification and blending on the oxygenation and substitution of diesel fuel for compression ignition engine," Renewable and Sustainable Energy Reviews, Elsevier, vol. 75(C), pages 1281-1294.
    3. Mat Yasin, Mohd Hafizil & Mamat, Rizalman & Najafi, G. & Ali, Obed Majeed & Yusop, Ahmad Fitri & Ali, Mohd Hafiz, 2017. "Potentials of palm oil as new feedstock oil for a global alternative fuel: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 79(C), pages 1034-1049.
    4. Yusri, I.M. & Mamat, R. & Najafi, G. & Razman, A. & Awad, Omar I. & Azmi, W.H. & Ishak, W.F.W. & Shaiful, A.I.M., 2017. "Alcohol based automotive fuels from first four alcohol family in compression and spark ignition engine: A review on engine performance and exhaust emissions," Renewable and Sustainable Energy Reviews, Elsevier, vol. 77(C), pages 169-181.
    5. Awad, Omar I. & Mamat, R. & Ibrahim, Thamir K. & Hammid, Ali Thaeer & Yusri, I.M. & Hamidi, Mohd Adnin & Humada, Ali M. & Yusop, A.F., 2018. "Overview of the oxygenated fuels in spark ignition engine: Environmental and performance," Renewable and Sustainable Energy Reviews, Elsevier, vol. 91(C), pages 394-408.
    6. Ä°smet Sezer, 2020. "A review study on using diethyl ether in diesel engines: Effects on fuel properties, injection, and combustion characteristics," Energy & Environment, , vol. 31(2), pages 179-214, March.
    7. Zhou, Yu & Meng, Qiang & Ong, Ghim Ping, 2022. "Electric Bus Charging Scheduling for a Single Public Transport Route Considering Nonlinear Charging Profile and Battery Degradation Effect," Transportation Research Part B: Methodological, Elsevier, vol. 159(C), pages 49-75.
    8. Mostafa Esmaeili Shayan & Gholamhassan Najafi & Barat Ghobadian & Shiva Gorjian & Mohamed Mazlan & Mehdi Samami & Alireza Shabanzadeh, 2022. "Flexible Photovoltaic System on Non-Conventional Surfaces: A Techno-Economic Analysis," Sustainability, MDPI, vol. 14(6), pages 1-14, March.
    9. Yaman, Hayri & Yesilyurt, Murat Kadir & Uslu, Samet, 2022. "Simultaneous optimization of multiple engine parameters of a 1-heptanol / gasoline fuel blends operated a port-fuel injection spark-ignition engine using response surface methodology approach," Energy, Elsevier, vol. 238(PC).
    10. Tsuneyoshi, Koji & Yamamoto, Kazuhiro, 2013. "Experimental study of hexagonal and square diesel particulate filters under controlled and uncontrolled catalyzed regeneration," Energy, Elsevier, vol. 60(C), pages 325-332.
    11. Yuan, Ye & Li, GuoXiu & Sun, ZuoYu & Li, HongMeng & Zhou, ZiHang, 2016. "Experimental study on the dynamical features of a partially premixed methane jet flame in coflow," Energy, Elsevier, vol. 111(C), pages 593-598.
    12. Zhang, Wei & Chen, Zhaohui & Shen, Yinggang & Shu, Gequn & Chen, Guisheng & Xu, Biao & Zhao, Wei, 2013. "Influence of water emulsified diesel & oxygen-enriched air on diesel engine NO-smoke emissions and combustion characteristics," Energy, Elsevier, vol. 55(C), pages 369-377.
    13. Tse, H. & Leung, C.W. & Cheung, C.S., 2015. "Investigation on the combustion characteristics and particulate emissions from a diesel engine fueled with diesel-biodiesel-ethanol blends," Energy, Elsevier, vol. 83(C), pages 343-350.
    14. Ana Bricia Galindo-Muro & Riccardo Cespi & Stephany Isabel Vallarta-Serrano, 2023. "Applications of Electric Vehicles in Instant Deliveries," Energies, MDPI, vol. 16(4), pages 1-18, February.
    15. Şahin, Zehra & Aksu, Orhan N., 2015. "Experimental investigation of the effects of using low ratio n-butanol/diesel fuel blends on engine performance and exhaust emissions in a turbocharged DI diesel engine," Renewable Energy, Elsevier, vol. 77(C), pages 279-290.
    16. Obed M. Ali & Rizalman Mamat & Gholamhassan Najafi & Talal Yusaf & Seyed Mohammad Safieddin Ardebili, 2015. "Optimization of Biodiesel-Diesel Blended Fuel Properties and Engine Performance with Ether Additive Using Statistical Analysis and Response Surface Methods," Energies, MDPI, vol. 8(12), pages 1-15, December.
    17. Alberto Ponso & Angelo Bonfitto & Giovanni Belingardi, 2023. "Route Planning for Electric Vehicles Including Driving Style, HVAC, Payload and Battery Health," Energies, MDPI, vol. 16(12), pages 1-22, June.
    18. Raeesi, Ramin & Zografos, Konstantinos G., 2020. "The electric vehicle routing problem with time windows and synchronised mobile battery swapping," Transportation Research Part B: Methodological, Elsevier, vol. 140(C), pages 101-129.
    19. Cortés-Murcia, David L. & Prodhon, Caroline & Murat Afsar, H., 2019. "The electric vehicle routing problem with time windows, partial recharges and satellite customers," Transportation Research Part E: Logistics and Transportation Review, Elsevier, vol. 130(C), pages 184-206.
    20. Gillespie, Fiona & Metcalfe, Wayne K. & Dirrenberger, Patricia & Herbinet, Olivier & Glaude, Pierre-Alexandre & Battin-Leclerc, Frédérique & Curran, Henry J., 2012. "Measurements of flat-flame velocities of diethyl ether in air," Energy, Elsevier, vol. 43(1), pages 140-145.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jsusta:v:14:y:2022:i:23:p:15666-:d:983377. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.