IDEAS home Printed from https://ideas.repec.org/a/gam/jsusta/v14y2022i21p13853-d952752.html
   My bibliography  Save this article

A Torque-Compensated Fault-Tolerant Control Method for Electric Vehicle Traction Motor with Short-Circuit Fault

Author

Listed:
  • Feiyu Hou

    (College of Information Science and Technology, Donghua University, Shanghai 201620, China)

  • Fei Yao

    (College of Information Science and Technology, Donghua University, Shanghai 201620, China)

  • Zheng Li

    (College of Information Science and Technology, Donghua University, Shanghai 201620, China)

Abstract

The development of traditional vehicles which consume fossil carbon-based fuels is constrained by environmental pollution and the energy crisis, and it has become a social consensus to develop electric vehicles with new energy resources and low emissions. The drive system of electric vehicles should be able to reliably operate over a long period. When a short-circuit fault occurs in the driving motor, the current in the winding will increase sharply and threaten driving safety. This paper proposed a short-circuit fault-tolerant control strategy for a dual three-phase permanent magnet synchronous traction motor (DT-PMSTM) which can resolve the problem of short-circuit faults. The current in non-short-circuit fault windings has been reconstructed to offset the interference of the short-circuit current and output a stable torque. Based on the principle of constant composited magnetic motive force (MMF), the dimension-reduced orthogonal transformation matrix was derived. The compensation currents were designed according to the interference effect of the short-circuit current to the normal MMF of the motor. Consequently, the lost torque component caused by the lack of the short-circuit winding was compensated, and the torque pulsation was also reduced. The performance of the topologies with neutral point-isolated mode and neutral point-connected mode were both investigated and compared. The validity of the proposed short-circuit fault-tolerant control strategy was proved by the simulation results.

Suggested Citation

  • Feiyu Hou & Fei Yao & Zheng Li, 2022. "A Torque-Compensated Fault-Tolerant Control Method for Electric Vehicle Traction Motor with Short-Circuit Fault," Sustainability, MDPI, vol. 14(21), pages 1-17, October.
    • Handle: RePEc:gam:jsusta:v:14:y:2022:i:21:p:13853-:d:952752
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2071-1050/14/21/13853/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2071-1050/14/21/13853/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Li, Zhenhe & Khajepour, Amir & Song, Jinchun, 2019. "A comprehensive review of the key technologies for pure electric vehicles," Energy, Elsevier, vol. 182(C), pages 824-839.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Xie, Yunkun & Li, Yangyang & Zhao, Zhichao & Dong, Hao & Wang, Shuqian & Liu, Jingping & Guan, Jinhuan & Duan, Xiongbo, 2020. "Microsimulation of electric vehicle energy consumption and driving range," Applied Energy, Elsevier, vol. 267(C).
    2. Jie Hu & Wentong Cao & Feng Jiang & Lingling Hu & Qian Chen & Weiguang Zheng & Junming Zhou, 2023. "Study on Multi-Objective Optimization of Power System Parameters of Battery Electric Vehicles," Sustainability, MDPI, vol. 15(10), pages 1-23, May.
    3. Yossi Hadad & Baruch Keren & Dima Alberg, 2023. "An Expert System for Ranking and Matching Electric Vehicles to Customer Specifications and Requirements," Energies, MDPI, vol. 16(11), pages 1-18, May.
    4. Hicham El Hadraoui & Mourad Zegrari & Fatima-Ezzahra Hammouch & Nasr Guennouni & Oussama Laayati & Ahmed Chebak, 2022. "Design of a Customizable Test Bench of an Electric Vehicle Powertrain for Learning Purposes Using Model-Based System Engineering," Sustainability, MDPI, vol. 14(17), pages 1-22, September.
    5. Wen, Shuang & Lin, Ni & Huang, Shengxu & Wang, Zhenpo & Zhang, Zhaosheng, 2023. "Lithium battery health state assessment based on vehicle-to-grid (V2G) real-world data and natural gradient boosting model," Energy, Elsevier, vol. 284(C).
    6. Wu, Yingwen & Ji, Yangjian, 2023. "Identifying firm-specific technology opportunities from the perspective of competitors by using association rule mining," Journal of Informetrics, Elsevier, vol. 17(2).
    7. Tingting Wang & Xin Liu & Dongchen Qin & Yuechen Duan, 2022. "Thermal Modeling and Prediction of The Lithium-ion Battery Based on Driving Behavior," Energies, MDPI, vol. 15(23), pages 1-22, November.
    8. Ataur Rahman & Kyaw Myo Aung & Sany Ihsan & Raja Mazuir Raja Ahsan Shah & Mansour Al Qubeissi & Mohannad T. Aljarrah, 2023. "Solar Energy Dependent Supercapacitor System with ANFIS Controller for Auxiliary Load of Electric Vehicles," Energies, MDPI, vol. 16(6), pages 1-23, March.
    9. Foda, Ahmed & Abdelaty, Hatem & Mohamed, Moataz & El-Saadany, Ehab, 2023. "A generic cost-utility-emission optimization for electric bus transit infrastructure planning and charging scheduling," Energy, Elsevier, vol. 277(C).
    10. He, Hongwen & Han, Mo & Liu, Wei & Cao, Jianfei & Shi, Man & Zhou, Nana, 2022. "MPC-based longitudinal control strategy considering energy consumption for a dual-motor electric vehicle," Energy, Elsevier, vol. 253(C).
    11. Piotr Bielaczyc & Rafal Sala & Tomasz Meinicke, 2021. "Analysis of Technical Capabilities, Methodology and Test Results of a Light-Commercial Vehicle Conversion to Battery Electric Powertrain," Energies, MDPI, vol. 14(4), pages 1-18, February.
    12. Weiqi Zhou & Nanchi Wu & Qingchao Liu & Chaofeng Pan & Long Chen, 2023. "Research on Ecological Driving Following Strategy Based on Deep Reinforcement Learning," Sustainability, MDPI, vol. 15(18), pages 1-14, September.
    13. Abdulgader Alsharif & Chee Wei Tan & Razman Ayop & Ahmed Al Smin & Abdussalam Ali Ahmed & Farag Hamed Kuwil & Mohamed Mohamed Khaleel, 2023. "Impact of Electric Vehicle on Residential Power Distribution Considering Energy Management Strategy and Stochastic Monte Carlo Algorithm," Energies, MDPI, vol. 16(3), pages 1-22, January.
    14. Macias, A. & Kandidayeni, M. & Boulon, L. & Trovão, J.P., 2021. "Fuel cell-supercapacitor topologies benchmark for a three-wheel electric vehicle powertrain," Energy, Elsevier, vol. 224(C).
    15. Kandidayeni, M. & Macias, A. & Boulon, L. & Kelouwani, S., 2020. "Investigating the impact of ageing and thermal management of a fuel cell system on energy management strategies," Applied Energy, Elsevier, vol. 274(C).
    16. Mokesioluwa Fanoro & Mladen Božanić & Saurabh Sinha, 2022. "A Review of the Impact of Battery Degradation on Energy Management Systems with a Special Emphasis on Electric Vehicles," Energies, MDPI, vol. 15(16), pages 1-29, August.
    17. Deng, Huifan & Zhao, Youqun & Feng, Shilin & Wang, Qiuwei & Zhang, Chenxi & Lin, Fen, 2021. "Torque vectoring algorithm based on mechanical elastic electric wheels with consideration of the stability and economy," Energy, Elsevier, vol. 219(C).
    18. Al-Bahrani, Loau Tawfak & Horan, Ben & Seyedmahmoudian, Mehdi & Stojcevski, Alex, 2020. "Dynamic economic emission dispatch with load dema nd management for the load demand of electric vehicles during crest shaving and valley filling in smart cities environment," Energy, Elsevier, vol. 195(C).
    19. Huang, Zhenhua & Fan, Hongqin, 2022. "Responsibility-sharing subsidy policy for reducing diesel emissions from in-use off-road construction equipment," Applied Energy, Elsevier, vol. 320(C).
    20. Lin, Xinyou & Li, Yalong & Zhang, Guangji, 2022. "Bi-objective optimization strategy of energy consumption and shift shock based driving cycle-aware bias coefficients for a novel dual-motor electric vehicle," Energy, Elsevier, vol. 249(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jsusta:v:14:y:2022:i:21:p:13853-:d:952752. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.