IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i17p6225-d1226421.html
   My bibliography  Save this article

Reduction in Fuel Consumption in Biomass-Fired Power Plant Using Hybrid Drying System

Author

Listed:
  • Somchart Chantasiriwan

    (Faculty of Engineering, Thammasat School of Engineering, Thammasat University, Pathum Thani 12120, Thailand)

Abstract

Fuels used in biomass power plants usually have high moisture contents. Two methods of fuel drying that have been proposed are steam drying and flue gas drying. Steam drying requires extracted steam as its energy source, whereas flue gas drying requires flue gas leaving the boiler as its energy source. Previous works have mostly been concerned with the integration of either dryer in a power plant. There have been a few investigations on the integration of both dryers. This paper proposes a novel hybrid drying system that uses a steam dryer to dry a portion of the fuel. Exhaust vapor from the steam dryer is then used for the heating of combustion air, which increases the flue gas temperature. The higher flue gas temperature increases the potential of the flue gas dryer, which is used to dry another portion of the fuel. It is shown that the hybrid drying system is capable of reducing fuel consumption to 7.76% in a 50 MW power plant. Furthermore, the integration of hybrid drying is shown to be economically justified because the simple payback period is 4.28 years.

Suggested Citation

  • Somchart Chantasiriwan, 2023. "Reduction in Fuel Consumption in Biomass-Fired Power Plant Using Hybrid Drying System," Energies, MDPI, vol. 16(17), pages 1-14, August.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:17:p:6225-:d:1226421
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/17/6225/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/17/6225/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Han, Xiaoqu & Liu, Ming & Wang, Jinshi & Yan, Junjie & Liu, Jiping & Xiao, Feng, 2014. "Simulation study on lignite-fired power system integrated with flue gas drying and waste heat recovery – Performances under variable power loads coupled with off-design parameters," Energy, Elsevier, vol. 76(C), pages 406-418.
    2. Xu, Cheng & Xu, Gang & Zhao, Shifei & Zhou, Luyao & Yang, Yongping & Zhang, Dongke, 2015. "An improved configuration of lignite pre-drying using a supplementary steam cycle in a lignite fired supercritical power plant," Applied Energy, Elsevier, vol. 160(C), pages 882-891.
    3. Andersson, Eva & Harvey, Simon & Berntsson, Thore, 2006. "Energy efficient upgrading of biofuel integrated with a pulp mill," Energy, Elsevier, vol. 31(10), pages 1384-1394.
    4. Chantasiriwan, Somchart, 2021. "Optimum installation of flue gas dryer and additional air heater to increase the efficiency of coal-fired utility boiler," Energy, Elsevier, vol. 221(C).
    5. Moein Shamoushaki & Pouriya H. Niknam & Lorenzo Talluri & Giampaolo Manfrida & Daniele Fiaschi, 2021. "Development of Cost Correlations for the Economic Assessment of Power Plant Equipment," Energies, MDPI, vol. 14(9), pages 1-19, May.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Han, Xiaoqu & Liu, Ming & Zhai, Mengxu & Chong, Daotong & Yan, Junjie & Xiao, Feng, 2015. "Investigation on the off-design performances of flue gas pre-dried lignite-fired power system integrated with waste heat recovery at variable external working conditions," Energy, Elsevier, vol. 90(P2), pages 1743-1758.
    2. Atsonios, K. & Violidakis, I. & Sfetsioris, K. & Rakopoulos, D.C. & Grammelis, P. & Kakaras, E., 2016. "Pre-dried lignite technology implementation in partial load/low demand cases for flexibility enhancement," Energy, Elsevier, vol. 96(C), pages 427-436.
    3. Han, Xiaoqu & Liu, Ming & Wu, Kaili & Chen, Weixiong & Xiao, Feng & Yan, Junjie, 2016. "Exergy analysis of the flue gas pre-dried lignite-fired power system based on the boiler with open pulverizing system," Energy, Elsevier, vol. 106(C), pages 285-300.
    4. Gebreegziabher, Tesfaldet & Oyedun, Adetoyese Olajire & Hui, Chi Wai, 2013. "Optimum biomass drying for combustion – A modeling approach," Energy, Elsevier, vol. 53(C), pages 67-73.
    5. Khouya, Ahmed, 2021. "Modelling and analysis of a hybrid solar dryer for woody biomass," Energy, Elsevier, vol. 216(C).
    6. Pawlak-Kruczek, Halina & Niedźwiecki, Łukasz & Ostrycharczyk, Michał & Czerep, Michał & Plutecki, Zbigniew, 2019. "Potential and methods for increasing the flexibility and efficiency of the lignite fired power unit, using integrated lignite drying," Energy, Elsevier, vol. 181(C), pages 1142-1151.
    7. Zhao, Haitao & Jiang, Peng & Chen, Zhe & Ezeh, Collins I. & Hong, Yuanda & Guo, Yishan & Zheng, Chenghang & Džapo, Hrvoje & Gao, Xiang & Wu, Tao, 2019. "Improvement of fuel sources and energy products flexibility in coal power plants via energy-cyber-physical-systems approach," Applied Energy, Elsevier, vol. 254(C).
    8. Andrea Arbula Blecich & Paolo Blecich, 2023. "Thermoeconomic Analysis of Subcritical and Supercritical Isobutane Cycles for Geothermal Power Generation," Sustainability, MDPI, vol. 15(11), pages 1-25, May.
    9. Braimakis, Konstantinos & Magiri-Skouloudi, Despina & Grimekis, Dimitrios & Karellas, Sotirios, 2020. "Εnergy-exergy analysis of ultra-supercritical biomass-fuelled steam power plants for industrial CHP, district heating and cooling," Renewable Energy, Elsevier, vol. 154(C), pages 252-269.
    10. Schmidt, Johannes & Leduc, Sylvain & Dotzauer, Erik & Kindermann, Georg & Schmid, Erwin, 2010. "Cost-effective CO2 emission reduction through heat, power and biofuel production from woody biomass: A spatially explicit comparison of conversion technologies," Applied Energy, Elsevier, vol. 87(7), pages 2128-2141, July.
    11. Halina Pawlak–Kruczek & Michał Czerep & Lukasz Niedzwiecki & Emmanouil Karampinis & Ioannis Violidakis & Ioannis Avagianos & Panagiotis Grammelis, 2019. "Drying of Lignite of Various Origins in a Pilot Scale Toroidal Fluidized Bed Dryer using Low Quality Heat," Energies, MDPI, vol. 12(7), pages 1-22, March.
    12. Wang, Di & Xie, Xinyan & Wang, Chaonan & Zhou, Yunlong & Yang, Mei & Li, Xiaoli & Liu, Deying, 2021. "Thermo-economic analysis on an improved coal-fired power system integrated with S–CO2 brayton cycle," Energy, Elsevier, vol. 220(C).
    13. Walmsley, Timothy G. & Walmsley, Michael R.W. & Atkins, Martin J. & Neale, James R. & Tarighaleslami, Amir H., 2015. "Thermo-economic optimisation of industrial milk spray dryer exhaust to inlet air heat recovery," Energy, Elsevier, vol. 90(P1), pages 95-104.
    14. Zhang, Shunqi & Liu, Ming & Ma, Yuegeng & Liu, Jiping & Yan, Junjie, 2021. "Flexibility assessment of a modified double-reheat Rankine cycle integrating a regenerative turbine during recuperative heater shutdown processes," Energy, Elsevier, vol. 233(C).
    15. Joelsson, Jonas & Gustavsson, Leif, 2012. "Swedish biomass strategies to reduce CO2 emission and oil use in an EU context," Energy, Elsevier, vol. 43(1), pages 448-468.
    16. Joelsson, Jonas M. & Gustavsson, Leif, 2012. "Reductions in greenhouse gas emissions and oil use by DME (di-methyl ether) and FT (Fischer-Tropsch) diesel production in chemical pulp mills," Energy, Elsevier, vol. 39(1), pages 363-374.
    17. Forman, Clemens & Gootz, Matthias & Wolfersdorf, Christian & Meyer, Bernd, 2017. "Coupling power generation with syngas-based chemical synthesis," Applied Energy, Elsevier, vol. 198(C), pages 180-191.
    18. Moein Shamoushaki & Giampaolo Manfrida & Lorenzo Talluri & Pouriya H. Niknam & Daniele Fiaschi, 2021. "Different Geothermal Power Cycle Configurations Cost Estimation Models," Sustainability, MDPI, vol. 13(20), pages 1-19, October.
    19. Wei, Maolin & Zhao, Xiling & Fu, Lin & Zhang, Shigang, 2017. "Performance study and application of new coal-fired boiler flue gas heat recovery system," Applied Energy, Elsevier, vol. 188(C), pages 121-129.
    20. Sena, Kenton & Ochuodho, Thomas O. & Agyeman, Domena A. & Contreras, Marco & Niman, Chad & Eaton, Dan & Yang, Jian, 2022. "Wood bioenergy for rural energy resilience: Suitable site selection and potential economic impacts in Appalachian Kentucky," Forest Policy and Economics, Elsevier, vol. 145(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:17:p:6225-:d:1226421. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.