IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i17p6145-d1223770.html
   My bibliography  Save this article

Experimental Study on the Feasibility of Quick Startup of Instant Heat Pump Water Heaters Based on Active Control of Heat Sink Flow Step

Author

Listed:
  • Fujun Ju

    (State Key Laboratory of Building Safety and Environment, Beijing 100013, China
    School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China
    National Engineering Research Center of Building Technology, Beijing 100013, China)

  • Zhenzhen Mu

    (School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China)

  • Guozhu Li

    (State Key Laboratory of Building Safety and Environment, Beijing 100013, China
    National Engineering Research Center of Building Technology, Beijing 100013, China)

  • Lihao Hou

    (School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China)

  • Xiaowei Fan

    (School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China)

  • Hongtao Liu

    (School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China)

  • Qinglei Liu

    (School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China)

  • Wenbo Liu

    (School of Energy and Environment, Zhongyuan University of Technology, Zhengzhou 450007, China)

Abstract

The influence of flow step ratio (FSR) on the startup characteristics of instant heat pump water heaters (IHPWHs) with natural mixture M (R744/R290 (12/88)) under nominal conditions was studied experimentally to verify the feasibility of a new quick startup method. The results show that the FSR had a marked effect on the startup time of system performance parameters. Under the optimal FSR of 0.6, the shortest system startup time and available hot water supply time were 700 s and 250 s, respectively, which were markedly shorter than those in the conventional startup. Therefore, rapid startup of the system and rapid production of usable domestic hot water can be realized by controlling the flow step. The influence of flow step on the variation trend of system performance parameters was obviously different, and there was no slow warming section for the heat sink outlet temperature (HSOT) under three FSRs. The HSOT, heating capacity, and high pressure side pressures had the maximum values in the quick startup, and the maximum values were obviously affected by the FSR. The FSR had no marked effect on the minimum suction pressure. The refrigerant pressures and refrigerant temperatures fluctuated markedly in both rapid and conventional starts.

Suggested Citation

  • Fujun Ju & Zhenzhen Mu & Guozhu Li & Lihao Hou & Xiaowei Fan & Hongtao Liu & Qinglei Liu & Wenbo Liu, 2023. "Experimental Study on the Feasibility of Quick Startup of Instant Heat Pump Water Heaters Based on Active Control of Heat Sink Flow Step," Energies, MDPI, vol. 16(17), pages 1-15, August.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:17:p:6145-:d:1223770
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/17/6145/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/17/6145/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Atasoy, Erkan & Çetin, Barbaros & Bayer, Özgür, 2022. "Experiment-based optimization of an energy-efficient heat pump integrated water heater for household appliances," Energy, Elsevier, vol. 245(C).
    2. Zhongchao Zhao & Yanrui Zhang & Haojun Mi & Yimeng Zhou & Yong Zhang, 2018. "Experimental Research of a Water-Source Heat Pump Water Heater System," Energies, MDPI, vol. 11(5), pages 1-13, May.
    3. Qu, Minglu & Yan, Xufeng & Wang, Haiyang & Hei, Yingxiao & Liu, Hongzhi & Li, Zhao, 2022. "Energy, exergy, economic and environmental analysis of photovoltaic/thermal integrated water source heat pump water heater," Renewable Energy, Elsevier, vol. 194(C), pages 1084-1097.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Chandan Swaroop Meena & Binju P Raj & Lohit Saini & Nehul Agarwal & Aritra Ghosh, 2021. "Performance Optimization of Solar-Assisted Heat Pump System for Water Heating Applications," Energies, MDPI, vol. 14(12), pages 1-17, June.
    2. Ignacio López Paniagua & Ángel Jiménez Álvaro & Javier Rodríguez Martín & Celina González Fernández & Rafael Nieto Carlier, 2019. "Comparison of Transcritical CO 2 and Conventional Refrigerant Heat Pump Water Heaters for Domestic Applications," Energies, MDPI, vol. 12(3), pages 1-17, February.
    3. Natanael Bolson & Maxim Yutkin & Tadeusz Patzek, 2023. "Primary Power Analysis of a Global Electrification Scenario," Sustainability, MDPI, vol. 15(19), pages 1-20, October.
    4. Xiang Gou & Shian Liu & Yang Fu & Qiyan Zhang & Saima Iram & Yingfan Liu, 2018. "Experimental Study on the Performance of a Household Dual-Source Heat Pump Water Heater," Energies, MDPI, vol. 11(10), pages 1-18, October.
    5. Wenting Ma & Moon Keun Kim & Jianli Hao, 2019. "Numerical Simulation Modeling of a GSHP and WSHP System for an Office Building in the Hot Summer and Cold Winter Region of China: A Case Study in Suzhou," Sustainability, MDPI, vol. 11(12), pages 1-17, June.
    6. Shucai Bai & Fangyi Li & Wu Xie, 2022. "Green but Unpopular? Analysis on Purchase Intention of Heat Pump Water Heaters in China," Energies, MDPI, vol. 15(7), pages 1-19, March.
    7. Zhe Wang & Fenghui Han & Yulong Ji & Wenhua Li, 2020. "Performance and Exergy Transfer Analysis of Heat Exchangers with Graphene Nanofluids in Seawater Source Marine Heat Pump System," Energies, MDPI, vol. 13(7), pages 1-17, April.
    8. Chao Huan & Shengteng Li & Fenghao Wang & Lang Liu & Yujiao Zhao & Zhihua Wang & Pengfei Tao, 2019. "Performance Analysis of a Combined Solar-Assisted Heat Pump Heating System in Xi’an, China," Energies, MDPI, vol. 12(13), pages 1-20, June.
    9. Josué F. Rosales-Pérez & Andrés Villarruel-Jaramillo & José A. Romero-Ramos & Manuel Pérez-García & José M. Cardemil & Rodrigo Escobar, 2023. "Hybrid System of Photovoltaic and Solar Thermal Technologies for Industrial Process Heat," Energies, MDPI, vol. 16(5), pages 1-45, February.
    10. Arpad Nyers & Jozsef Nyers, 2023. "Enhancing the Energy Efficiency—COP of the Heat Pump Heating System by Energy Optimization and a Case Study," Energies, MDPI, vol. 16(7), pages 1-20, March.
    11. Adria Banks & Colin Grist & Jonathan Heller & Hyunwoo Lim, 2022. "Field Measurement of Central CO 2 Heat Pump Water Heater for Multifamily Retrofit," Sustainability, MDPI, vol. 14(13), pages 1-18, July.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:17:p:6145-:d:1223770. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.