IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v14y2021i1p238-d474849.html
   My bibliography  Save this article

Design and Performance Analysis of New Ultra-Supercritical Double Reheat Coal-Fired Power Generation Systems

Author

Listed:
  • Ming Yang

    (School of Energy, Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China)

  • Liqiang Duan

    (School of Energy, Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China)

  • Yongjing Tong

    (School of Energy, Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China)

Abstract

In order to solve the existing problems of large mean heat transfer temperature differences of regenerative air heaters and high superheat degrees of regenerative extraction steam in double reheat coal-fired power generation systems, two new design schemes of ultra-supercritical double reheat cycles are proposed, which can realize the deep boiler-turbine coupling among the heat transfer processes of air, feeding water and regeneration extraction steam on the base of the principle of energy level matching. A typical 1000 MW ultra-supercritical double reheat cycle system is selected as the reference system and the overall system model is built by using the Ebsilon simulation software. The performances of two new systems are analyzed by using both the exergy method and energy equilibrium method. The results show that net output powers of both new systems 1 and 2 increase by 6.38 MW and 6.93 MW, respectively, and the standard coal consumptions of power generation decrease by 1.65 g/kWh and 1.79 g/kWh, respectively. The off-design performances of new systems and the reference system are analyzed, and the results show that performances of two new systems are better than that of the reference system. The system flow of the new system 2 is more complex compared with that of the new system 1. Generally speaking, the performance of new system 1 is better than that of new system 2. On the basis of new system 1, new system 3 is further optimized and its full operating condition performance characteristics are analyzed. The standard coal consumption rate of new system 3 is reduced about 1 g/kWh at higher load, and around 0.2 g/kWh at low load.

Suggested Citation

  • Ming Yang & Liqiang Duan & Yongjing Tong, 2021. "Design and Performance Analysis of New Ultra-Supercritical Double Reheat Coal-Fired Power Generation Systems," Energies, MDPI, vol. 14(1), pages 1-22, January.
    • Handle: RePEc:gam:jeners:v:14:y:2021:i:1:p:238-:d:474849
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/14/1/238/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/14/1/238/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Wang, Jianxing & Duan, Liqiang & Yang, Yongping & Yang, Zhiping & Yang, Laishun, 2019. "Study on the general system integration optimization method of the solar aided coal-fired power generation system," Energy, Elsevier, vol. 169(C), pages 660-673.
    2. Yan, Min & Zhang, Liang & Shi, Yuetao & Zhang, Liqiang & Li, Yuzhong & Ma, Chunyuan, 2018. "A novel boiler cold-end optimisation system based on bypass flue in coal-fired power plants: Heat recovery from wet flue gas," Energy, Elsevier, vol. 152(C), pages 84-94.
    3. Jin, Hongguang & Ishida, Masaru, 1993. "Graphical exergy analysis of complex cycles," Energy, Elsevier, vol. 18(6), pages 615-625.
    4. Zheng, D. & Uchiyama, Y. & Ishida, M., 1986. "Energy-utilization diagrams for two types of LNG power-generation systems," Energy, Elsevier, vol. 11(6), pages 631-639.
    5. Xu, Gang & Huang, Shengwei & Yang, Yongping & Wu, Ying & Zhang, Kai & Xu, Cheng, 2013. "Techno-economic analysis and optimization of the heat recovery of utility boiler flue gas," Applied Energy, Elsevier, vol. 112(C), pages 907-917.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. B. Koti Reddy & Amit Kumar Singh, 2021. "Optimal Operation of a Photovoltaic Integrated Captive Cogeneration Plant with a Utility Grid Using Optimization and Machine Learning Prediction Methods," Energies, MDPI, vol. 14(16), pages 1-28, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Wang, Yanhong & Cao, Lihua & Li, Xingcan & Wang, Jiaxing & Hu, Pengfei & Li, Bo & Li, Yong, 2020. "A novel thermodynamic method and insight of heat transfer characteristics on economizer for supercritical thermal power plant," Energy, Elsevier, vol. 191(C).
    2. Linbin Huang & Guoqing Chen & Xiang Xu & Rui Tan & Xinglong Gao & Haifeng Zhang & Jie Yu, 2024. "Recovering Low-Grade Heat from Flue Gas in a Coal-Fired Thermal Power Unit," Energies, MDPI, vol. 17(20), pages 1-11, October.
    3. Jiayou Liu & Fengzhong Sun, 2019. "Experimental Study on Operation Regulation of a Coupled High–Low Energy Flue Gas Waste Heat Recovery System Based on Exhaust Gas Temperature Control," Energies, MDPI, vol. 12(4), pages 1-20, February.
    4. Wang, Xiang & Zhuo, Jiankun & Liu, Jianmin & Li, Shuiqing, 2020. "Synergetic process of condensing heat exchanger and absorption heat pump for waste heat and water recovery from flue gas," Applied Energy, Elsevier, vol. 261(C).
    5. Jiayou Liu & Xiaoyun Gong & Wenhua Zhang & Fengzhong Sun & Qingbiao Wang, 2020. "Experimental Study on a Flue Gas Waste Heat Cascade Recovery System under Variable Working Conditions," Energies, MDPI, vol. 13(2), pages 1-19, January.
    6. Lin, Xiaolong & Li, Qinlun & Wang, Lukai & Guo, Yifan & Liu, Yinhe, 2020. "Thermo-economic analysis of typical thermal systems and corresponding novel system for a 1000 MW single reheat ultra-supercritical thermal power plant," Energy, Elsevier, vol. 201(C).
    7. Zhang, Yi & Liu, Jinfeng & Yang, Tingting & Liu, Jianbang & Shen, Jiong & Fang, Fang, 2021. "Dynamic modeling and control of direct air-cooling condenser pressure considering couplings with adjacent systems," Energy, Elsevier, vol. 236(C).
    8. Ma, Youfu & Wang, Zirui & Lu, Junfu & Yang, Lijuan, 2018. "Techno-economic analysis of a novel hot air recirculation process for exhaust heat recovery from a 600 MW brown-coal-fired boiler," Energy, Elsevier, vol. 152(C), pages 348-357.
    9. Zhang, Na & Wang, Zefeng & Lior, Noam & Han, Wei, 2018. "Advancement of distributed energy methods by a novel high efficiency solar-assisted combined cooling, heating and power system," Applied Energy, Elsevier, vol. 219(C), pages 179-186.
    10. Yan, Min & Zhang, Liang & Shi, Yuetao & Zhang, Liqiang & Li, Yuzhong & Ma, Chunyuan, 2018. "A novel boiler cold-end optimisation system based on bypass flue in coal-fired power plants: Heat recovery from wet flue gas," Energy, Elsevier, vol. 152(C), pages 84-94.
    11. Feng, Yupeng & Li, Yuzhong & Cui, Lin & Yan, Lifan & Zhao, Cheng & Dong, Yong, 2019. "Cold condensing scrubbing method for fine particle reduction from saturated flue gas," Energy, Elsevier, vol. 171(C), pages 1193-1205.
    12. Peng, Shuo & Hong, Hui & Jin, Hongguang & Wang, Zhifeng, 2012. "An integrated solar thermal power system using intercooled gas turbine and Kalina cycle," Energy, Elsevier, vol. 44(1), pages 732-740.
    13. Yan, Hui & Liu, Ming & Wang, Zhu & Zhang, Kezhen & Chong, Daotong & Yan, Junjie, 2023. "Flexibility enhancement of solar-aided coal-fired power plant under different direct normal irradiance conditions," Energy, Elsevier, vol. 262(PA).
    14. Ramadan, Mohamad & Khaled, Mahmoud & Haddad, Ahmad & Abdulhay, Bakri & Durrant, Andy & El Hage, Hicham, 2018. "An inhouse code for simulating heat recovery from boilers to heat water," Energy, Elsevier, vol. 157(C), pages 200-210.
    15. Rongrong Zhai & Hongtao Liu & Hao Wu & Hai Yu & Yongping Yang, 2018. "Analysis of Integration of MEA-Based CO 2 Capture and Solar Energy System for Coal-Based Power Plants Based on Thermo-Economic Structural Theory," Energies, MDPI, vol. 11(5), pages 1-30, May.
    16. Zuxian Zhang & Liqiang Duan & Zhen Wang & Yujie Ren, 2023. "Integration Optimization of Integrated Solar Combined Cycle (ISCC) System Based on System/Solar Photoelectric Efficiency," Energies, MDPI, vol. 16(8), pages 1-22, April.
    17. Yan, Hui & Liu, Ming & Chong, Daotong & Wang, Chaoyang & Yan, Junjie, 2021. "Dynamic performance and control strategy comparison of a solar-aided coal-fired power plant based on energy and exergy analyses," Energy, Elsevier, vol. 236(C).
    18. Ma, Hongqiang & Liang, Nuo & Liu, Yemin & Luo, Xinmei & Hou, Caiqin & Wang, Gang, 2021. "Experimental study on novel waste heat recovery system for sulfide-containing flue gas," Energy, Elsevier, vol. 227(C).
    19. Dzierwa, Piotr & Trojan, Marcin & Peret, Patryk & Taler, Jan & Taler, Dawid & Kaczmarski, Karol & Wrobel, Wojciech & Bator, Jakub, 2024. "Technological and economical analysis of the heat recovery system from flue gas in a thermal waste treatment plant," Energy, Elsevier, vol. 307(C).
    20. Liu, Hongtao & Zhai, Rongrong & Patchigolla, Kumar & Turner, Peter & Yang, Yongping, 2020. "Performance analysis of a novel combined solar trough and tower aided coal-fired power generation system," Energy, Elsevier, vol. 201(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:14:y:2021:i:1:p:238-:d:474849. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.