IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v12y2019i12p2314-d240524.html
   My bibliography  Save this article

Experimental Investigation of Methane Hydrate Induction Time in the Presence of Cassava Peel as a Hydrate Inhibitor

Author

Listed:
  • Mazlin Idress

    (Department of Petroleum Engineering, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Malaysia)

  • Muhammad Afiq Shahril

    (Department of Petroleum Engineering, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Malaysia)

  • Ahmad Syahir Zuraidin

    (Department of Petroleum Engineering, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Malaysia)

  • Mazuin Jasamai

    (Department of Petroleum Engineering, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Malaysia)

Abstract

The oil and gas industry faces numerous problems, from the exploration to the production phase. One of the most common problems faced by the industry is the formation of gas hydrates in the pipeline during the deep-water operation. The advancement of kinetic hydrate inhibitors (KHIs) has been rapid. However, as the natural degradation of conventional KHIs, such as polyvinylpyrrolidone (PVP) and polyvinylcaprolactam (PVCap), is challenging, there is a need to develop environmental-friendly KHIs with enhanced biodegradability to improve possible environmental risks. Thus, green inhibitors have been developed as a new class of KHIs. Research for enhancement of green hydrate inhibitors, as an alternative for existing low dosage hydrate inhibitors (LDHIs), has increased. In this paper, the effect of induction time with presence of cassava peels on the formation of methane hydrate was studied and compared with commercialized inhibitor, PVP. The performance of cassava peels as a kinetic hydrate inhibitor was investigated using high pressure micro differential scanning calorimetry (µ-DSC). For the induction time measurement, linear cooling ramps at a constant cooling rate of 0.5 K/min were used under isobaric conditions. Aqueous solutions of 0.5 wt % and 1.0 wt % of cassava peels were prepared and the induction time of methane hydrate formation in these solutions was measured at pressure ranges from 4.0 to 10.0 MPa. One of the characteristics to be a good kinetic inhibitor is the presence of hydroxyl functional group in inhibitors, which assist to form hydrogen bonds with water molecules, thus preventing hydrates formation. Fourier transform infrared (FTIR) analysis confirms the presence of hydroxyl groups in cassava peels with wavenumber value of 3370.68 cm −1 . Cassava peel solution is observed to delay the induction times at all pressure settings and it is better at 1.0 wt % concentration. However, at lower pressures of 4 and 6 MPa, the performance is less effective when compared to a commercial inhibitor, PVP. At high pressures of 8 and 10 MPa, it can be seen that the performance is as effective as PVP. This research paper shows that cassava peels have high potential to be developed as a gas hydrate green kinetic inhibitor that can be applied for industry usage in the future.

Suggested Citation

  • Mazlin Idress & Muhammad Afiq Shahril & Ahmad Syahir Zuraidin & Mazuin Jasamai, 2019. "Experimental Investigation of Methane Hydrate Induction Time in the Presence of Cassava Peel as a Hydrate Inhibitor," Energies, MDPI, vol. 12(12), pages 1-11, June.
    • Handle: RePEc:gam:jeners:v:12:y:2019:i:12:p:2314-:d:240524
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/12/12/2314/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/12/12/2314/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Kamal, Muhammad Shahzad & Hussein, Ibnelwaleed A. & Sultan, Abdullah S. & von Solms, Nicolas, 2016. "Application of various water soluble polymers in gas hydrate inhibition," Renewable and Sustainable Energy Reviews, Elsevier, vol. 60(C), pages 206-225.
    2. Adekunle, Ademola & Orsat, Valerie & Raghavan, Vijaya, 2016. "Lignocellulosic bioethanol: A review and design conceptualization study of production from cassava peels," Renewable and Sustainable Energy Reviews, Elsevier, vol. 64(C), pages 518-530.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Yue Zhang & Zhi Li & Xiaodeng Yang & Tianduo Li, 2022. "Synthesis of Chitosan Derivatives and Their Inhibition Effects on Methane Hydrates," Energies, MDPI, vol. 15(7), pages 1-14, April.
    2. Yulia F. Zaripova & Sherzod Razhabov & Roman S. Pavelyev & Svetlana S. Vinogradova & Renat R. Nazmutdinov & Iskander R. Vakhitov & Mikhail A. Varfolomeev, 2022. "Effective Inhibition of Carbon Steel Corrosion by Waterborne Polyurethane Based on N- tert -Butyl Diethanolamine in 2M HCl: Experimental and Computational Findings," Energies, MDPI, vol. 15(5), pages 1-21, March.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Adekunle, Ademola & Osazuwa, Peter & Raghavan, Vijaya, 2016. "Socio-economic determinants of agricultural mechanisation in Africa: A research note based on cassava cultivation mechanisation," Technological Forecasting and Social Change, Elsevier, vol. 112(C), pages 313-319.
    2. Liao, Bo & Wang, Jintang & Li, Mei-Chun & Lv, Kaihe & Wang, Qi & Li, Jian & Huang, Xianbing & Wang, Ren & Lv, Xindi & Chen, Zhangxin & Sun, Jinsheng, 2023. "Microscopic molecular and experimental insights into multi-stage inhibition mechanisms of alkylated hydrate inhibitor," Energy, Elsevier, vol. 279(C).
    3. Farhadian, Abdolreza & Varfolomeev, Mikhail A. & Rezaeisadat, Morteza & Semenov, Anton P. & Stoporev, Andrey S., 2020. "Toward a bio-based hybrid inhibition of gas hydrate and corrosion for flow assurance," Energy, Elsevier, vol. 210(C).
    4. Sánchez, Antonio Santos & Silva, Yuri Lopes & Kalid, Ricardo Araújo & Cohim, Eduardo & Torres, Ednildo Andrade, 2017. "Waste bio-refineries for the cassava starch industry: New trends and review of alternatives," Renewable and Sustainable Energy Reviews, Elsevier, vol. 73(C), pages 1265-1275.
    5. Jeong, Hanseob & Lee, Jaejung & Ju, Young Min & Lee, Soo Min, 2019. "Using electro-coagulation treatment to remove phenolic compounds and furan derivatives in hydrolysates resulting from pilot-scale supercritical water hydrolysis of Mongolian oak," Renewable Energy, Elsevier, vol. 138(C), pages 971-979.
    6. Donald Ukpanyang & Julio Terrados-Cepeda, 2022. "Decarbonizing Vehicle Transportation with Hydrogen from Biomass Gasification: An Assessment in the Nigerian Urban Environment," Energies, MDPI, vol. 15(9), pages 1-23, April.
    7. Derman, Eryati & Abdulla, Rahmath & Marbawi, Hartinie & Sabullah, Mohd Khalizan, 2018. "Oil palm empty fruit bunches as a promising feedstock for bioethanol production in Malaysia," Renewable Energy, Elsevier, vol. 129(PA), pages 285-298.
    8. Mohapatra, Sonali & Mishra, Chinmaya & Behera, Sudhansu S. & Thatoi, Hrudayanath, 2017. "Application of pretreatment, fermentation and molecular techniques for enhancing bioethanol production from grass biomass – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 78(C), pages 1007-1032.
    9. Lourdes Orejuela-Escobar & Arleth Gualle & Valeria Ochoa-Herrera & George P. Philippidis, 2021. "Prospects of Microalgae for Biomaterial Production and Environmental Applications at Biorefineries," Sustainability, MDPI, vol. 13(6), pages 1-19, March.
    10. Thakre, Niraj & Jana, Amiya K., 2021. "Physical and molecular insights to Clathrate hydrate thermodynamics," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    11. Panchal, Tirth M. & Patel, Ankit & Chauhan, D.D. & Thomas, Merlin & Patel, Jigar V., 2017. "A methodological review on bio-lubricants from vegetable oil based resources," Renewable and Sustainable Energy Reviews, Elsevier, vol. 70(C), pages 65-70.
    12. Abdulkhani, Ali & Alizadeh, Peyman & Hedjazi, Sahab & Hamzeh, Yahya, 2017. "Potential of Soya as a raw material for a whole crop biorefinery," Renewable and Sustainable Energy Reviews, Elsevier, vol. 75(C), pages 1269-1280.
    13. Long, Zhen & Zhou, Xuebing & Lu, Zhilin & Liang, Deqing, 2022. "Kinetic inhibition performance of N-vinyl caprolactam/isopropylacrylamide copolymers on methane hydrate formation," Energy, Elsevier, vol. 242(C).
    14. Yang, Mingjun & Zhao, Jie & Zheng, Jia-nan & Song, Yongchen, 2019. "Hydrate reformation characteristics in natural gas hydrate dissociation process: A review," Applied Energy, Elsevier, vol. 256(C).
    15. Salma Elhenawy & Majeda Khraisheh & Fares Almomani & Mohammad A. Al-Ghouti & Mohammad K. Hassan & Ala’a Al-Muhtaseb, 2022. "Towards Gas Hydrate-Free Pipelines: A Comprehensive Review of Gas Hydrate Inhibition Techniques," Energies, MDPI, vol. 15(22), pages 1-44, November.
    16. Chen, Xuyue & Yang, Jin & Gao, Deli & Hong, Yuqun & Zou, Yiqi & Du, Xu, 2020. "Unlocking the deepwater natural gas hydrate's commercial potential with extended reach wells from shallow water: Review and an innovative method," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:12:y:2019:i:12:p:2314-:d:240524. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.