IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v321y2025ics0360544225010084.html
   My bibliography  Save this article

Modeling and analysis of methane-fueled turboexpander engine under the consideration of chemical non-equilibrium

Author

Listed:
  • Gao, Jin
  • Wang, Youyin
  • Yu, Yuejie
  • Sun, Weiheng
  • Zhang, Junlong
  • Bao, Wen

Abstract

The turboexpander engines are regarded as a possible solution of low Mach numbers propulsion system of single-stage-to-orbit (SSTO) vehicles and spacecraft. Although the turboexpander engine was proposed for decades, previous work has focused on hydrogen-fueled turboexpander engines. Although some researchers have analyzed the cycle performance of different fuels, the thermal decomposition of the fuel caused by the high turbine inlet temperature was neglected. However, the thermal decomposition of hydrocarbon fuel can significantly affect the performance of the engine. Thermodynamic models of the methane-fueled turboexpander engine considering the chemical non-equilibrium were built, and the engine performance was analyzed to reveal the necessity of considering the chemical non-equilibrium in the methane-fueled turboexpander engine. The major results showed that the methane conversion rate in the heat exchanger is the key factor affecting the performance of methane-fueled turboexpander engine, and on this basis, the methods of improving the engine performance was suggested.

Suggested Citation

  • Gao, Jin & Wang, Youyin & Yu, Yuejie & Sun, Weiheng & Zhang, Junlong & Bao, Wen, 2025. "Modeling and analysis of methane-fueled turboexpander engine under the consideration of chemical non-equilibrium," Energy, Elsevier, vol. 321(C).
    • Handle: RePEc:eee:energy:v:321:y:2025:i:c:s0360544225010084
    DOI: 10.1016/j.energy.2025.135366
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544225010084
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2025.135366?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Patlolla, Shashank Reddy & Katsu, Kyle & Sharafian, Amir & Wei, Kevin & Herrera, Omar E. & Mérida, Walter, 2023. "A review of methane pyrolysis technologies for hydrogen production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 181(C).
    2. Zhao, Wei & Huang, Chen & Zhao, Qingjun & Ma, Yingqun & Xu, Jianzhong, 2018. "Performance analysis of a pre-cooled and fuel-rich pre-burned mixed-flow turbofan cycle for high speed vehicles," Energy, Elsevier, vol. 154(C), pages 96-109.
    3. Kwon, Hyun Min & Moon, Seong Won & Kim, Tong Seop & Kang, Do Won, 2020. "Performance enhancement of the gas turbine combined cycle by simultaneous reheating, recuperation, and coolant inter-cooling," Energy, Elsevier, vol. 207(C).
    4. Yin, Juan & Su, Shi & Yu, Xin Xiang & Weng, Yiwu, 2010. "Thermodynamic characteristics of a low concentration methane catalytic combustion gas turbine," Applied Energy, Elsevier, vol. 87(6), pages 2102-2108, June.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Lv, Chengkun & Xu, Haiqi & Chang, Juntao & Wang, Youyin & Chen, Ruoyu & Yu, Daren, 2022. "Mode transition analysis of a turbine-based combined-cycle considering ammonia injection pre-compressor cooling and variable-geometry ram-combustor," Energy, Elsevier, vol. 261(PB).
    2. Seck, Gondia Sokhna & Hache, Emmanuel & D'Herbemont, Vincent & Guyot, Mathis & Malbec, Louis-Marie, 2023. "Hydrogen development in Europe: Estimating material consumption in net zero emissions scenarios," International Economics, Elsevier, vol. 176(C).
    3. Deng, Li & Chen, Min & Tang, Hailong & Zhang, Jiyuan, 2024. "Performance evaluation of multicombustor engine for Mach3+-Level propulsion system," Energy, Elsevier, vol. 295(C).
    4. Zakaria, Z. & Kamarudin, S.K., 2016. "Direct conversion technologies of methane to methanol: An overview," Renewable and Sustainable Energy Reviews, Elsevier, vol. 65(C), pages 250-261.
    5. Jiang, Guohe & Chen, Min & Tang, Hailong & Zhang, Jiyuan, 2025. "Matching mechanism of a novel variable cycle propulsion concept with hydrogen intercooling," Energy, Elsevier, vol. 317(C).
    6. Pan, Xin & Xiong, Yuefei & Wang, Cong & Qin, Jiang & Zhang, Silong & Bao, Wen, 2022. "Performance analysis of precooled turbojet engine with a low-temperature endothermic fuel," Energy, Elsevier, vol. 248(C).
    7. Yu, Xuanfei & Wang, Cong & Yu, Daren, 2019. "Precooler-design & engine-performance conjugated optimization for fuel direct precooled airbreathing propulsion," Energy, Elsevier, vol. 170(C), pages 546-556.
    8. Wang, Jia & Wen, Mengyuan & La, Xinru & Ren, Jurong & Jiang, Jianchun & Tsang, Daniel C.W., 2024. "Resonance-driven microwave heating for improved methane conversion to hydrogen," Applied Energy, Elsevier, vol. 375(C).
    9. Marín, Pablo & Díez, Fernando V. & Ordóñez, Salvador, 2014. "A new method for controlling the ignition state of a regenerative combustor using a heat storage device," Applied Energy, Elsevier, vol. 116(C), pages 322-332.
    10. Yu, Xuanfei & Wang, Cong & Yu, Daren, 2020. "Series view method based thermodynamic modeling and analysis for innovative precooled aeroengines with different turbine-compressor coupling schemes," Energy, Elsevier, vol. 205(C).
    11. Wang, Cong & Yu, Xuanfei & Pan, Xin & Qin, Jiang & Huang, Hongyan, 2022. "Thermodynamic optimization of the indirect precooled engine cycle using the method of cascade utilization of cold sources," Energy, Elsevier, vol. 238(PB).
    12. Palmieri, A. & Lanzarotto, D. & Cacciacarne, S. & Torre, I. & Bonfiglio, A., 2021. "An innovative sliding mode load controller for gas turbine power generators: Design and experimental validation via real-time simulation," Energy, Elsevier, vol. 217(C).
    13. Wang, Cong & Yu, Xuanfei & Ha, Chan & Liu, Zekuan & Fang, Jiwei & Qin, Jiang & Shao, Jiahui & Huang, Hongyan, 2023. "Thermodynamic analysis for a novel chemical precooling turbojet engine based on a multi-stage precooling-compression cycle," Energy, Elsevier, vol. 262(PA).
    14. Khidr, Kareem I. & Eldrainy, Yehia A. & EL-Kassaby, Mohamed M., 2017. "Towards lower gas turbine emissions: Flameless distributed combustion," Renewable and Sustainable Energy Reviews, Elsevier, vol. 67(C), pages 1237-1266.
    15. Li, Longfei & Luo, Zhongyang & Du, Liwen & Miao, Feiting & Liu, Longyi, 2025. "Prediction of product yields and heating value of bio-oil from biomass fast pyrolysis: Explainable predictive modeling and evaluation," Energy, Elsevier, vol. 324(C).
    16. Tsiklios, Christos & Hermesmann, Matthias & Stumm, Paul & Müller, Thomas E., 2025. "Comparative analysis of hydrogen vs. methane pipeline transport systems with integrated methane pyrolysis for low-carbon hydrogen supply," Applied Energy, Elsevier, vol. 383(C).
    17. Wang, Cong & Cheng, Kunlin & Qin, Jiang & Shao, Jiahui & Huang, Hongyan, 2022. "Performance comparison of three chemical precooled turbine engine cycles using methanol and n-decane as the precooling fuels," Energy, Elsevier, vol. 249(C).
    18. Ma, Xiaofeng & Jiang, Peixue & Zhu, Yinhai, 2023. "Modeling and performance analysis of a pre-cooling and power generation system based on the supercritical CO2 Brayton cycle on turbine-based combined cycle engines," Energy, Elsevier, vol. 284(C).
    19. Gunarayu, Mathesh Rao & Abdul Patah, Muhamad Fazly & Ashri Wan Daud, Wan Mohd, 2025. "Advancements in methane pyrolysis: A comprehensive review of parameters and molten catalysts in bubble column reactors," Renewable and Sustainable Energy Reviews, Elsevier, vol. 210(C).
    20. Wang, Jia & Wen, Mengyuan & Ren, Jurong & La, Xinru & Meng, Xianzhi & Yuan, Xiangzhou & Ragauskas, Arthur J. & Jiang, Jianchun, 2024. "Tailoring microwave frequencies for high-efficiency hydrogen production from biomass," Energy, Elsevier, vol. 297(C).

    More about this item

    Keywords

    ;
    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:321:y:2025:i:c:s0360544225010084. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.