IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v267y2023ics0360544222034545.html
   My bibliography  Save this article

Influences of diffusion and advection on dynamic oil-CO2 mixing during CO2 EOR and storage process: Experimental study and numerical modeling at pore-scales

Author

Listed:
  • Li, Zongfa
  • Liu, Jiahui
  • Su, Yuliang
  • Fan, Liyao
  • Hao, Yongmao
  • kanjibayi, Bahedawulieti
  • Huang, Lijuan
  • Ren, Shaoran
  • Sun, Yongquan
  • Liu, Ran

Abstract

The dynamic oil-CO2 mixing and miscible flow in porous media are complex and important phenomena that occurs during CO2 injection for enhanced oil recovery (EOR) and geological storage. In this study, microfluidic experiments at pore-scale were conducted to simulate and investigate the mixing and flow behavior of oil and CO2 in porous media with dead-end pores. The non-uniform oil-CO2 mixing and bi-directional diffusion (CO2 into oil and oil components into CO2) in dead-end pores were observed. Based on the experimental observation, a novel oil-CO2 miscible flow model was established. The model can describe the effects of diffusion, flow velocity distribution, fluid properties change, and pore structures on oil-CO2 mixing and oil displacement. The diffusion coefficient between CO2 and oil in porous media was figured out by matching the experimental results using the new model. The modeling results indicate that diffusion plays an important role in oil-CO2 mixing, especially in deep dead-end pores. Without diffusion, over 70% of oil components would remain in their original place during CO2 flooding. In complex porous media, advection induced by CO2 flow dominates oil displacement in the early stage of CO2 flooding, which can reduce the average oil mole fraction by 24%. Then diffusion increasingly influences the oil-CO2 mixing and oil displacement, reducing the average oil mole fraction by over 35%. Without diffusion, much of the dead-end, column, and corner oil would remain in place in the oil reservoir. During CO2 flow in complex porous media, reducing oil viscosity due to mixing with CO2 can decrease the flow resistance in the main flow channels, which in turn can decrease the fluid flowing through the surrounding pores and is not conducive to oil displacement. In practice, even though a high CO2 injection rate can produce oil quickly, it might affect the overall oil recovery factor and lower the CO2 utilization efficiency.

Suggested Citation

  • Li, Zongfa & Liu, Jiahui & Su, Yuliang & Fan, Liyao & Hao, Yongmao & kanjibayi, Bahedawulieti & Huang, Lijuan & Ren, Shaoran & Sun, Yongquan & Liu, Ran, 2023. "Influences of diffusion and advection on dynamic oil-CO2 mixing during CO2 EOR and storage process: Experimental study and numerical modeling at pore-scales," Energy, Elsevier, vol. 267(C).
    • Handle: RePEc:eee:energy:v:267:y:2023:i:c:s0360544222034545
    DOI: 10.1016/j.energy.2022.126567
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544222034545
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2022.126567?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Nguyen, Phong & Carey, J. William & Viswanathan, Hari S. & Porter, Mark, 2018. "Effectiveness of supercritical-CO2 and N2 huff-and-puff methods of enhanced oil recovery in shale fracture networks using microfluidic experiments," Applied Energy, Elsevier, vol. 230(C), pages 160-174.
    2. Khaled Enab & Hamid Emami-Meybodi, 2021. "Effects of Diffusion, Adsorption, and Hysteresis on Huff-n-Puff Performance in Ultratight Reservoirs with Different Fluid Types and Injection Gases," Energies, MDPI, vol. 14(21), pages 1-17, November.
    3. Chen, Bailian & Pawar, Rajesh J., 2019. "Characterization of CO2 storage and enhanced oil recovery in residual oil zones," Energy, Elsevier, vol. 183(C), pages 291-304.
    4. Hao, Yongmao & Li, Zongfa & Su, Yuliang & Kong, Chuixian & Chen, Hong & Meng, Yang, 2022. "Experimental investigation of CO2 storage and oil production of different CO2 injection methods at pore-scale and core-scale," Energy, Elsevier, vol. 254(PB).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Huang, Xianfu & Zhao, Ya-Pu, 2023. "Evolution of pore structure and adsorption-desorption in oil shale formation rocks after compression," Energy, Elsevier, vol. 278(PA).
    2. Hao, Yongmao & Li, Zongfa & Su, Yuliang & Kong, Chuixian & Chen, Hong & Meng, Yang, 2022. "Experimental investigation of CO2 storage and oil production of different CO2 injection methods at pore-scale and core-scale," Energy, Elsevier, vol. 254(PB).
    3. Zhang, Xue & Su, Yuliang & Li, Lei & Da, Qi'an & Hao, Yongmao & Wang, Wendong & Liu, Jiahui & Gao, Xiaogang & Zhao, An & Wang, Kaiyu, 2022. "Microscopic remaining oil initiation mechanism and formation damage of CO2 injection after waterflooding in deep reservoirs," Energy, Elsevier, vol. 248(C).
    4. Desmond Batsa Dorhjie & Elena Mukhina & Anton Kasyanenko & Alexey Cheremisin, 2023. "Tight and Shale Oil Exploration: A Review of the Global Experience and a Case of West Siberia," Energies, MDPI, vol. 16(18), pages 1-28, September.
    5. Cai, Mingyu & Su, Yuliang & Elsworth, Derek & Li, Lei & Fan, Liyao, 2021. "Hydro-mechanical-chemical modeling of sub-nanopore capillary-confinement on CO2-CCUS-EOR," Energy, Elsevier, vol. 225(C).
    6. Chao Chen & Xiang Tang & Ming Qin & Rui Zhou & Zhenhua Ding & Guihui Lian & Huan Qi & Xin Chen & Zheyu Liu & Yiqiang Li, 2022. "Experimental Evaluation of Shale Oil Development Effectiveness by Air Injection," Energies, MDPI, vol. 15(24), pages 1-13, December.
    7. Zhengdong Lei & Yishan Liu & Rui Wang & Lei Li & Yuqi Liu & Yuanqing Zhang, 2022. "A Microfluidic Experiment on CO 2 Injection for Enhanced Oil Recovery in a Shale Oil Reservoir with High Temperature and Pressure," Energies, MDPI, vol. 15(24), pages 1-15, December.
    8. Chen, Binbin & Xuan, Jin & Offer, Gregory James & Wang, Huizhi, 2020. "Multiplex measurement of diffusion in zinc battery electrolytes from microfluidics using Raman microspectroscopy," Applied Energy, Elsevier, vol. 279(C).
    9. Song, Hongqing & Lao, Junming & Zhang, Liyuan & Xie, Chiyu & Wang, Yuhe, 2023. "Underground hydrogen storage in reservoirs: pore-scale mechanisms and optimization of storage capacity and efficiency," Applied Energy, Elsevier, vol. 337(C).
    10. Zhou, Xiang & Li, Xiuluan & Shen, Dehuang & Shi, Lanxiang & Zhang, Zhien & Sun, Xinge & Jiang, Qi, 2022. "CO2 huff-n-puff process to enhance heavy oil recovery and CO2 storage: An integration study," Energy, Elsevier, vol. 239(PB).
    11. Jin, Xu & Wang, Xiaoqi & Yan, Weipeng & Meng, Siwei & Liu, Xiaodan & Jiao, Hang & Su, Ling & Zhu, Rukai & Liu, He & Li, Jianming, 2019. "Exploration and casting of large scale microscopic pathways for shale using electrodeposition," Applied Energy, Elsevier, vol. 247(C), pages 32-39.
    12. Jian, Guoqing & Gizzatov, Ayrat & Kawelah, Mohammed & AlYousef, Zuhair & Abdel-Fattah, Amr I., 2021. "Simply built microfluidics for fast screening of CO2 foam surfactants and foam model parameters estimation," Applied Energy, Elsevier, vol. 292(C).
    13. Ganggang Hou & Xiaoli Ma & Wenyue Zhao & Pengxiang Diwu & Tongjing Liu & Jirui Hou, 2021. "Synergistic Modes and Enhanced Oil Recovery Mechanism of CO 2 Synergistic Huff and Puff," Energies, MDPI, vol. 14(12), pages 1-30, June.
    14. Qiang Liu & Jialong Li & Bing Liang & Weiji Sun & Jianjun Liu & Yun Lei, 2023. "Microscopic Flow of CO 2 in Complex Pore Structures: A Recent 10-Year Review," Sustainability, MDPI, vol. 15(17), pages 1-21, August.
    15. Wu, Pengzhi & Liu, Changchun & Wen, Hu & Luo, Zhenmin & Fan, Shixing & Mi, Wansheng, 2023. "Experimental investigation of jet impingement during accidental release of liquid CO2," Energy, Elsevier, vol. 279(C).
    16. Steele, Amanda Harker & Sharma, Smriti & Pena Cabra, Ivonne & Clahane, Luke & Iyengar, Arun, 2023. "A tool for measuring the system cost of replacement energy," Energy, Elsevier, vol. 275(C).
    17. Yunqi Jiang & Huaqing Zhang & Kai Zhang & Jian Wang & Shiti Cui & Jianfa Han & Liming Zhang & Jun Yao, 2022. "Reservoir Characterization and Productivity Forecast Based on Knowledge Interaction Neural Network," Mathematics, MDPI, vol. 10(9), pages 1-22, May.
    18. Ren, Bo & Duncan, Ian J., 2021. "Maximizing oil production from water alternating gas (CO2) injection into residual oil zones: The impact of oil saturation and heterogeneity," Energy, Elsevier, vol. 222(C).
    19. Vo Thanh, Hung & Sheini Dashtgoli, Danial & Zhang, Hemeng & Min, Baehyun, 2023. "Machine-learning-based prediction of oil recovery factor for experimental CO2-Foam chemical EOR: Implications for carbon utilization projects," Energy, Elsevier, vol. 278(PA).
    20. Vo Thanh, Hung & Yasin, Qamar & Al-Mudhafar, Watheq J. & Lee, Kang-Kun, 2022. "Knowledge-based machine learning techniques for accurate prediction of CO2 storage performance in underground saline aquifers," Applied Energy, Elsevier, vol. 314(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:267:y:2023:i:c:s0360544222034545. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.