IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v388y2025ics0306261925003629.html
   My bibliography  Save this article

Advanced thermal management for oxygen pump assisted solar thermochemical reactor for fuel production

Author

Listed:
  • Wang, Runsen
  • Chen, Yuzhu
  • Lin, Meng

Abstract

High-performance thermochemical cycles for fuel production require an energy-intensive reduction step due to the stringent conditions of high temperature and low oxygen partial pressure. An integrated high-temperature electrochemical oxygen pump (EOP) can enable effective in-situ oxygen removal, offering flexibility in tuning the oxygen environment with low energy consumption. However, thermal failure induced by extreme high reduction temperature, typically > 1500 °C, poses a challenge to the stability of the oxygen pump. This study proposes a thermal management strategy for oxygen pump integration by actively cooling the pump to prevent overheating. The performance of the reactor was evaluated using both numerical simulation and experimental methods. The thermochemical performance of ceria and the electrochemical performance of the EOP were assessed with and without active cooling. Results indicated that the ceria height (Hceria) was the key factor influencing reactor performance, more so than the gap distance (Dgap), temperature difference (Tdif), or mass flow rate of the cooling fluid (Mc). Increasing the Hceria from 3 mm to 7 mm improved the current density from 149.4 A·m-2 to 356.5 A·m-2 at 20 s and reduced the δ from 0.0357 to 0.0292 at 3000 s. Howevever, due to increased mass loading at increased Hceria, the overall oxygen producted increased resulting a in better reactor performance. Increasing the Dgap reduced the temperature gradient within the EOP, and hence enhancing the thermomechanical stability. An in-house oxygen pump sintered at 1373 K demonstrated an effective oxygen removal rate, operating at 162.1 A·m-2 with 0.3 V and 1373 K. However, the oxygen pump sintered at 1673 K showed a significant decrease in performance, resulting in inadequate oxygen pumping. Optimal reactor performance was achieved in the proposed CA scheme with a Tdif at 900 K, balancing the EOP oxygen removal capability in favorable operating temperature range and thermochemical reactor performance. This study provides comprehensive design guidelines and operational strategies for the integration of electrochemical oxygen pump with thermochemical reactors for practical applications.

Suggested Citation

  • Wang, Runsen & Chen, Yuzhu & Lin, Meng, 2025. "Advanced thermal management for oxygen pump assisted solar thermochemical reactor for fuel production," Applied Energy, Elsevier, vol. 388(C).
  • Handle: RePEc:eee:appene:v:388:y:2025:i:c:s0306261925003629
    DOI: 10.1016/j.apenergy.2025.125632
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261925003629
    Download Restriction: Full text for ScienceDirect subscribers only

    File URL: https://libkey.io/10.1016/j.apenergy.2025.125632?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Remo Schäppi & David Rutz & Fabian Dähler & Alexander Muroyama & Philipp Haueter & Johan Lilliestam & Anthony Patt & Philipp Furler & Aldo Steinfeld, 2022. "Drop-in fuels from sunlight and air," Nature, Nature, vol. 601(7891), pages 63-68, January.
    2. Justin T. Tran & Kent J. Warren & Steven A. Wilson & Christopher L. Muhich & Charles B. Musgrave & Alan W. Weimer, 2024. "An updated review and perspective on efficient hydrogen generation via solar thermal water splitting," Wiley Interdisciplinary Reviews: Energy and Environment, Wiley Blackwell, vol. 13(4), July.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Tang, Xin-Yuan & Yang, Wei-Wei & Li, Jia-Chen & Zhang, Jia-Rui & Lin, Yi-Wan, 2025. "Stable and efficient hybrid controller of solar thermal membrane reactor based on machine learning and multi-objective optimization," Energy, Elsevier, vol. 320(C).
    2. Xianjin Shi & Wei Peng & Yu Huang & Chao Gao & Yiman Fu & Zhenyu Wang & Leting Yang & Zixuan Zhu & Junji Cao & Fei Rao & Gangqiang Zhu & Shuncheng Lee & Yujie Xiong, 2024. "Integrable utilization of intermittent sunlight and residual heat for on-demand CO2 conversion with water," Nature Communications, Nature, vol. 15(1), pages 1-10, December.
    3. Lin, Zihan & Khan, Muhammad Sajid & Chen, Ji & Xia, Qi & Ma, Kewei & Ding, Weihua & Jiao, Long & Gao, Zengliang & Chen, Chen, 2024. "Solar methanol production from carbon dioxide and water using NaA zeolitic membrane reactor with pressurized solid oxide electrolysis cell," Energy, Elsevier, vol. 311(C).
    4. Wang, Hongsheng & Liu, Tong & Kong, Hui, 2024. "Solar CO2 splitting coupling with PV, photon-enhanced thermionic emission cell and SOEC for efficient full-spectrum utilization in a wide temperature range," Applied Energy, Elsevier, vol. 367(C).
    5. Guene Lougou, Bachirou & Wu, Lianxuan & Ma, Danni & Geng, Boxi & Jiang, Boshu & Han, Donmei & Zhang, Hao & Łapka, Piotr & Shuai, Yong, 2023. "Efficient conversion of solar energy through a macroporous ceramic receiver coupling heat transfer and thermochemical reactions," Energy, Elsevier, vol. 271(C).
    6. Zhang, Hao & Zhang, Xiaomi & Yang, Dazhi & Liu, Bai & Shuai, Yong & Lougou, Bachirou Guene & Zhou, Qian & Huang, Xing & Wang, Fuqiang, 2024. "Comparison of non-isothermal and isothermal cycles in a novel methane-assisted two-step thermochemical process," Renewable Energy, Elsevier, vol. 230(C).
    7. Pan, Ruming & Yang, Youwei & Lougou, Bachirou Guene & Wu, Lianxuan & Wang, Wei & Guo, Yanming & Shuai, Yong, 2024. "Thermal performance evaluation of a novel solar-driven pyrolysis reactor," Energy, Elsevier, vol. 313(C).
    8. Jiang, Boshu & Guene Lougou, Bachirou & Zhang, Hao & Geng, Boxi & Wu, Lianxuan & Shuai, Yong, 2022. "Preparation and solar thermochemical properties analysis of NiFe2O4@SiC/ @Si3N4 for high-performance CO2-splitting," Applied Energy, Elsevier, vol. 328(C).
    9. Liu, YongXiang & Yan, Jian & Xie, XinYi & Peng, YouDuo & Nie, DuZhong, 2023. "Improving the energy distribution uniformity of solar dish collector system under tracking error using a cavity receiver position adjustment method," Energy, Elsevier, vol. 278(PA).
    10. Shi, Xuhang & Li, Chunzhe & Yang, Zhenning & Xu, Jie & Song, Jintao & Wang, Fuqiang & Shuai, Yong & Zhang, Wenjing, 2024. "Egg-tray-inspired concave foam structure on pore-scale space radiation regulation for enhancing photo-thermal-chemical synergistic conversion," Energy, Elsevier, vol. 297(C).
    11. Zhao, Yi & Hagi, Hayato & Delahaye, Bruno & Maréchal, François, 2024. "A holistic approach to refinery decarbonization based on atomic, energy and exergy flow analysis," Energy, Elsevier, vol. 296(C).
    12. Pan, Heng & Zhao, Yuhao & He, Feiyu & Zhu, Liya & Wang, Zhaolu & Li, Yihang & Lu, Youjun, 2025. "Two-step electro-thermochemical cycle for CO2 splitting in a solid oxide electrochemical cell," Applied Energy, Elsevier, vol. 380(C).
    13. Shi, Xuhang & Song, Jintao & Cheng, Ziming & Liang, Huaxu & Dong, Yan & Wang, Fuqiang & Zhang, Wenjing, 2023. "Radiative intensity regulation to match energy conversion on demand in solar methane dry reforming to improve solar to fuel conversion efficiency," Renewable Energy, Elsevier, vol. 207(C), pages 436-446.
    14. Akba, Tufan & Baker, Derek & Mengüç, M. Pınar, 2023. "Gradient-based optimization of micro-scale pressurized volumetric receiver geometry and flow rate," Renewable Energy, Elsevier, vol. 203(C), pages 741-752.
    15. Guo, Yongpeng & Chen, Jing & Song, Hualong & Zheng, Ke & Wang, Jian & Wang, Hongsheng & Kong, Hui, 2024. "A review of solar thermochemical cycles for fuel production," Applied Energy, Elsevier, vol. 357(C).
    16. Ren, Ting & Li, Ran & Li, Xin, 2023. "Bi-level multi-objective robust optimization for performance improvements in integrated energy system with solar fuel production," Renewable Energy, Elsevier, vol. 219(P1).
    17. Chen, Xue & Lyu, Jinxin & Sun, Chuang & Xia, Xinlin & Wang, Fuqiang, 2023. "Pore-scale evaluation on a volumetric solar receiver with different optical property control strategies," Energy, Elsevier, vol. 278(PB).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:388:y:2025:i:c:s0306261925003629. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.