IDEAS home Printed from https://ideas.repec.org/a/gam/jsusta/v14y2022i16p10438-d894674.html
   My bibliography  Save this article

Permeability-Enhancing Technology through Liquid CO 2 Fracturing and Its Application

Author

Listed:
  • Zebiao Jiang

    (Key Laboratory of Comprehensive Utilization of Nonmetallic Mineral Resources in Guizhou, School of Mining, Guizhou University, Guiyang 550025, China)

  • Xiping Quan

    (Key Laboratory of Comprehensive Utilization of Nonmetallic Mineral Resources in Guizhou, School of Mining, Guizhou University, Guiyang 550025, China)

  • Shixiang Tian

    (Key Laboratory of Comprehensive Utilization of Nonmetallic Mineral Resources in Guizhou, School of Mining, Guizhou University, Guiyang 550025, China)

  • Hao Liu

    (College of Aerospace Engineering, Chongqing University, Chongqing 400044, China)

  • Yaling Guo

    (Key Laboratory of Comprehensive Utilization of Nonmetallic Mineral Resources in Guizhou, School of Mining, Guizhou University, Guiyang 550025, China)

  • Xiangxiang Fu

    (College of Aerospace Engineering, Chongqing University, Chongqing 400044, China)

  • Xifa Yang

    (Key Laboratory of Comprehensive Utilization of Nonmetallic Mineral Resources in Guizhou, School of Mining, Guizhou University, Guiyang 550025, China)

Abstract

Liquid carbon dioxide (CO 2 ) phase change fracturing (LCPCF) is an innovative technique to improve the efficiency of gas drainage from low-permeability coal seams of high gas content. However, fracture sprouting, extension and displacement changes of coal under LCPCF need further study, and corresponding field tests are also lacking. Therefore, a mechanical model based on the thermodynamic theory of CO 2 phase change is developed in this paper. Then, the pressure change characteristics, crack propagation and displacement change of coal subjected to LCPCF were analyzed through numerical simulation. In addition, the permeability-enhancing effect of the field LCPCF test was analyzed. The results obtained from the numerical simulation show that during the LCPCF process, the crack-generation process changes with pressure as follows: microfracture–numerous microfractures–major macrofracture–macrofractures. During the development of fractures, the stress is incompletely symmetrically distributed in coal centered on the fracturing borehole. The failure occurs stochastically in the coal in the vicinity of the fracturing borehole at first, and then it gradually propagates to the inner seam of coal as the gas pressure increases. The following result can be obtained from field experiments: the permeability coefficient of coal seams after increasing the permeability through LCPCF is 2.60~3.97 times that of coal seams without presplitting. The average concentration of gas extracted in coal seams within the zone having undergone an increase in permeability through liquid CO 2 fracturing is 2.14 times greater than that within the zone without presplitting. The average pure amount of gas extracted within the zone having undergone an increase in permeability through LCPCF is 3.78 times greater than that within the zone without presplitting. By comparing coal seams before and after fracturing in the field test, it can be seen that the LCPCF presents a favorable effect in increasing the permeability of low-permeability coal seams. This provides an effective approach for increasing the permeability of coal seams in coal mines with similar geological conditions.

Suggested Citation

  • Zebiao Jiang & Xiping Quan & Shixiang Tian & Hao Liu & Yaling Guo & Xiangxiang Fu & Xifa Yang, 2022. "Permeability-Enhancing Technology through Liquid CO 2 Fracturing and Its Application," Sustainability, MDPI, vol. 14(16), pages 1-23, August.
    • Handle: RePEc:gam:jsusta:v:14:y:2022:i:16:p:10438-:d:894674
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2071-1050/14/16/10438/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2071-1050/14/16/10438/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Zhengyi Ti & Feng Zhang & Jin Pan & Xiaofei Ma & Zheng Shang, 2018. "Permeability enhancement of deep hole pre-splitting blasting in the low permeability coal seam of the Nanting coal mine," PLOS ONE, Public Library of Science, vol. 13(6), pages 1-16, June.
    2. Zou, Quanle & Zhang, Tiancheng & Ma, Tengfei & Tian, Shixiang & Jia, Xueqi & Jiang, Zebiao, 2022. "Effect of water-based SiO2 nanofluid on surface wettability of raw coal," Energy, Elsevier, vol. 254(PA).
    3. Jiang, Yongdong & Luo, Yahuang & Lu, Yiyu & Qin, Chao & Liu, Hui, 2016. "Effects of supercritical CO2 treatment time, pressure, and temperature on microstructure of shale," Energy, Elsevier, vol. 97(C), pages 173-181.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Yin, Hong & Zhou, Junping & Xian, Xuefu & Jiang, Yongdong & Lu, Zhaohui & Tan, Jingqiang & Liu, Guojun, 2017. "Experimental study of the effects of sub- and super-critical CO2 saturation on the mechanical characteristics of organic-rich shales," Energy, Elsevier, vol. 132(C), pages 84-95.
    2. Wang, Chongyang & Zhang, Dongming & Liu, Chenxi & Pan, Yisha & Jiang, Zhigang & Yu, Beichen & Lin, Yun, 2023. "Deformation and seepage characteristics of water-saturated shale under true triaxial stress," Energy, Elsevier, vol. 284(C).
    3. Wang, Gang & Xie, Shuliang & Huang, Qiming & Wang, Enmao & Wang, Shuxin, 2023. "Study on the performances of fluorescent tracers for the wetting area detection of coal seam water injection," Energy, Elsevier, vol. 263(PE).
    4. Zhou, Gang & Wang, Qi & Zhang, Yizhen & Zhang, Qi & Li, Lin & Wang, Yongmei & Sun, Biao & Liu, Rulin, 2024. "Effects of dual Gemini-based fracturing fluid on the physicochemical properties of coking coal: Material preparation and wetting mechanism," Energy, Elsevier, vol. 289(C).
    5. Jin, Lu & Hawthorne, Steven & Sorensen, James & Pekot, Lawrence & Kurz, Bethany & Smith, Steven & Heebink, Loreal & Herdegen, Volker & Bosshart, Nicholas & Torres, José & Dalkhaa, Chantsalmaa & Peters, 2017. "Advancing CO2 enhanced oil recovery and storage in unconventional oil play—Experimental studies on Bakken shales," Applied Energy, Elsevier, vol. 208(C), pages 171-183.
    6. Qin, Chao & Jiang, Yongdong & Zhou, Junping & Zuo, Shuangying & Chen, Shiwan & Liu, Zhengjie & Yin, Hong & Li, Ye, 2022. "Influence of supercritical CO2 exposure on water wettability of shale: Implications for CO2 sequestration and shale gas recovery," Energy, Elsevier, vol. 242(C).
    7. Zhou, Junping & Tian, Shifeng & Zhou, Lei & Xian, Xuefu & Yang, Kang & Jiang, Yongdong & Zhang, Chengpeng & Guo, Yaowen, 2020. "Experimental investigation on the influence of sub- and super-critical CO2 saturation time on the permeability of fractured shale," Energy, Elsevier, vol. 191(C).
    8. Chengkai Fan & Qi Li & Jianli Ma & Duoxing Yang, 2019. "Fiber Bragg grating‐based experimental and numerical investigations of CO2 migration front in saturated sandstone under subcritical and supercritical conditions," Greenhouse Gases: Science and Technology, Blackwell Publishing, vol. 9(1), pages 106-124, February.
    9. Qin, Chao & Jiang, Yongdong & Cao, Mengyao & Zhou, Junping & Song, Xiao & Zuo, Shuangying & Chen, Shiwan & Luo, Yahuang & Xiao, Siyou & Yin, Hong & Du, Xidong, 2023. "Experimental study on the methane desorption-diffusion behavior of Longmaxi shale exposure to supercritical CO2," Energy, Elsevier, vol. 262(PA).
    10. Liu, Bo & Mohammadi, Mohammad-Reza & Ma, Zhongliang & Bai, Longhui & Wang, Liu & Xu, Yaohui & Hemmati-Sarapardeh, Abdolhossein & Ostadhassan, Mehdi, 2023. "Pore structure evolution of Qingshankou shale (kerogen type I) during artificial maturation via hydrous and anhydrous pyrolysis: Experimental study and intelligent modeling," Energy, Elsevier, vol. 282(C).
    11. Sean P. Rigby & Ali Alsayah & Richard Seely, 2022. "Impact of Exposure to Supercritical Carbon Dioxide on Reservoir Caprocks and Inter-Layers during Sequestration," Energies, MDPI, vol. 15(20), pages 1-34, October.
    12. Haojun Wu & Min Gong & Xiaodong Wu & Yang Guo, 2022. "Effect and Response of Coal and Rock Media Conditions on Deep-Hole Pre-Splitting Blasting Techniques for Gas Drainage," Energies, MDPI, vol. 15(22), pages 1-17, November.
    13. Yang, Xin & Wang, Gongda & Du, Feng & Jin, Longzhe & Gong, Haoran, 2022. "N2 injection to enhance coal seam gas drainage (N2-ECGD): Insights from underground field trial investigation," Energy, Elsevier, vol. 239(PC).
    14. Zhang, Rongda & Wei, Jing & Zhao, Xiaoli & Liu, Yang, 2022. "Economic and environmental benefits of the integration between carbon sequestration and underground gas storage," Energy, Elsevier, vol. 260(C).
    15. Chen, Kang & Liu, Xianfeng & Nie, Baisheng & Zhang, Chengpeng & Song, Dazhao & Wang, Longkang & Yang, Tao, 2022. "Mineral dissolution and pore alteration of coal induced by interactions with supercritical CO2," Energy, Elsevier, vol. 248(C).
    16. Mavhengere, P. & Wagner, N. & Malumbazo, N., 2021. "The effects of long-term supercritical CO2 exposure on Zululand Basin core samples," Energy, Elsevier, vol. 220(C).
    17. Bai, Bing & Ni, Hong-jian & Shi, Xian & Guo, Xing & Ding, Lu, 2021. "The experimental investigation of effect of supercritical CO2 immersion on mechanical properties and pore structure of shale," Energy, Elsevier, vol. 228(C).
    18. Lu, Yiyu & Chen, Xiayu & Tang, Jiren & Li, Honglian & Zhou, Lei & Han, Shuaibin & Ge, Zhaolong & Xia, Binwei & Shen, Huajian & Zhang, Jing, 2019. "Relationship between pore structure and mechanical properties of shale on supercritical carbon dioxide saturation," Energy, Elsevier, vol. 172(C), pages 270-285.
    19. Qin, Chao & Jiang, Yongdong & Luo, Yahuang & Zhou, Junping & Liu, Hao & Song, Xiao & Li, Dong & Zhou, Feng & Xie, Yingliang, 2020. "Effect of supercritical CO2 saturation pressures and temperatures on the methane adsorption behaviours of Longmaxi shale," Energy, Elsevier, vol. 206(C).
    20. Hongyan Qin & Jingui Zhang & Zhiheng Cheng & Zhenhua Ouyang & Liang Chen & Haiyang Yi & Xidong Zhao & Yang Li & Hao Liu, 2022. "Research on Overburden Failure Characteristics Based on the Theory of Plates and Shells," Sustainability, MDPI, vol. 14(18), pages 1-16, September.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jsusta:v:14:y:2022:i:16:p:10438-:d:894674. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.