IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v15y2022i10p3555-d814159.html
   My bibliography  Save this article

System Performance Analyses of Supercritical CO 2 Brayton Cycle for Sodium-Cooled Fast Reactor

Author

Listed:
  • Min Xie

    (HE National Engineering Research Center of Power Generation Equipment, Harbin 150028, China)

  • Jian Cheng

    (Harbin Electric International Company Limited, Harbin 150028, China)

  • Xiaohan Ren

    (Institute of Thermal Science and Technology, Shandong University, Jinan 250061, China)

  • Shuo Wang

    (State Key Laboratory of Efficient and Clean Coal-Fired Utility Boilers, Harbin Boiler Company Limited, Harbin 150046, China)

  • Pengcheng Che

    (HE National Engineering Research Center of Power Generation Equipment, Harbin 150028, China)

  • Chunwei Zhang

    (HE National Engineering Research Center of Power Generation Equipment, Harbin 150028, China)

Abstract

The system performance of the supercritical CO 2 Brayton cycle for the Sodium Fast Reactor with a partial-cooling layout was studied, and an economic analysis was carried out. The energetic, exergetic, and exergoeconomic analyses are presented, and the optimized results were compared with the recompression cycle. The sensitivity analyses were conducted by considering the variations in the pressure ratios and inlet temperatures of the main compressor and the turbine. The exergy efficiency of the partial-cooling cycle reached 63.65% with a net power output of 34.39 MW via optimization. The partial-cooling cycle obtained a minimum total cost rate of 2230.36 USD/h and exergy efficiency of 63.65% when the pressure ratio was equal to 3.50. The inlet temperature of the main compressor was equal to 35 °C, and the inlet temperature of the turbine was equal to 480 °C. The total cost of recuperators decreased with the increase in the pressure ratio and the inlet temperatures of the main compressor. In addition, the total cost of recuperator could be reduced by increasing the outlet temperature of the turbine. The change in cost from exergy loss and destruction with the pressure ratio was substantially larger than with the inlet temperature of the turbine or the main compressor. Manipulating the pressure ratio is an essential method to guarantee good economy of the system. Moreover, capital investment, operation, and maintenance costs normally accounted for large proportions of the total cost rate, being almost double the cost from the exergy loss and destruction occurring in each condition.

Suggested Citation

  • Min Xie & Jian Cheng & Xiaohan Ren & Shuo Wang & Pengcheng Che & Chunwei Zhang, 2022. "System Performance Analyses of Supercritical CO 2 Brayton Cycle for Sodium-Cooled Fast Reactor," Energies, MDPI, vol. 15(10), pages 1-19, May.
    • Handle: RePEc:gam:jeners:v:15:y:2022:i:10:p:3555-:d:814159
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/15/10/3555/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/15/10/3555/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Muhammad Haroon & Nadeem Ahmed Sheikh & Abubakr Ayub & Rasikh Tariq & Farooq Sher & Aklilu Tesfamichael Baheta & Muhammad Imran, 2020. "Exergetic, Economic and Exergo-Environmental Analysis of Bottoming Power Cycles Operating with CO 2 -Based Binary Mixture," Energies, MDPI, vol. 13(19), pages 1-19, September.
    2. Mohammadkhani, F. & Shokati, N. & Mahmoudi, S.M.S. & Yari, M. & Rosen, M.A., 2014. "Exergoeconomic assessment and parametric study of a Gas Turbine-Modular Helium Reactor combined with two Organic Rankine Cycles," Energy, Elsevier, vol. 65(C), pages 533-543.
    3. Wang, Xurong & Yang, Yi & Zheng, Ya & Dai, Yiping, 2017. "Exergy and exergoeconomic analyses of a supercritical CO2 cycle for a cogeneration application," Energy, Elsevier, vol. 119(C), pages 971-982.
    4. Zare, V. & Mahmoudi, S.M.S. & Yari, M., 2013. "An exergoeconomic investigation of waste heat recovery from the Gas Turbine-Modular Helium Reactor (GT-MHR) employing an ammonia–water power/cooling cycle," Energy, Elsevier, vol. 61(C), pages 397-409.
    5. Noaman, Mohamed & Saade, George & Morosuk, Tatiana & Tsatsaronis, George, 2019. "Exergoeconomic analysis applied to supercritical CO2 power systems," Energy, Elsevier, vol. 183(C), pages 756-765.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Tozlu, Alperen & Abuşoğlu, Ayşegül & Özahi, Emrah, 2018. "Thermoeconomic analysis and optimization of a Re-compression supercritical CO2 cycle using waste heat of Gaziantep Municipal Solid Waste Power Plant," Energy, Elsevier, vol. 143(C), pages 168-180.
    2. Xinyu Miao & Haochun Zhang & Qi Wang & Wenbo Sun & Yan Xia, 2022. "Thermodynamic, Exergoeconomic and Multi-Objective Analyses of Supercritical N 2 O-He Recompression Brayton Cycle for a Nuclear Spacecraft Application," Energies, MDPI, vol. 15(21), pages 1-31, November.
    3. Özahi, Emrah & Tozlu, Alperen, 2020. "Optimization of an adapted Kalina cycle to an actual municipal solid waste power plant by using NSGA-II method," Renewable Energy, Elsevier, vol. 149(C), pages 1146-1156.
    4. Esra Özdemir Küçük & Muhsin Kılıç, 2023. "Exergoeconomic and Exergetic Sustainability Analysis of a Combined Dual-Pressure Organic Rankine Cycle and Vapor Compression Refrigeration Cycle," Sustainability, MDPI, vol. 15(8), pages 1-28, April.
    5. Wang, Xurong & Yang, Yi & Zheng, Ya & Dai, Yiping, 2017. "Exergy and exergoeconomic analyses of a supercritical CO2 cycle for a cogeneration application," Energy, Elsevier, vol. 119(C), pages 971-982.
    6. Liu, Yaping & Wang, Ying & Huang, Diangui, 2019. "Supercritical CO2 Brayton cycle: A state-of-the-art review," Energy, Elsevier, vol. 189(C).
    7. Mahdavi, Navid & Khalilarya, Shahram, 2019. "Comprehensive thermodynamic investigation of three cogeneration systems including GT-HRSG/RORC as the base system, intermediate system and solar hybridized system," Energy, Elsevier, vol. 181(C), pages 1252-1272.
    8. Li, Jiaojiao & Zoghi, Mohammad & Zhao, Linfeng, 2022. "Thermo-economic assessment and optimization of a geothermal-driven tri-generation system for power, cooling, and hydrogen production," Energy, Elsevier, vol. 244(PB).
    9. Lee, Young Duk & Ahn, Kook Young & Morosuk, Tatiana & Tsatsaronis, George, 2018. "Exergetic and exergoeconomic evaluation of an SOFC-Engine hybrid power generation system," Energy, Elsevier, vol. 145(C), pages 810-822.
    10. Teymouri, Matin & Sadeghi, Shayan & Moghimi, Mahdi & Ghandehariun, Samane, 2021. "3E analysis and optimization of an innovative cogeneration system based on biomass gasification and solar photovoltaic thermal plant," Energy, Elsevier, vol. 230(C).
    11. Gao, Lei & Cao, Tao & Hwang, Yunho & Radermacher, Reinhard, 2022. "Robustness analysis in supercritical CO2 power generation system configuration optimization," Energy, Elsevier, vol. 242(C).
    12. Bahlouli, Keyvan & Khoshbakhti Saray, Rahim, 2016. "Energetic and exergetic analyses of a new energy system for heating and power production purposes," Energy, Elsevier, vol. 106(C), pages 390-399.
    13. Bahlouli, K. & Khoshbakhti Saray, R. & Sarabchi, N., 2015. "Parametric investigation and thermo-economic multi-objective optimization of an ammonia–water power/cooling cycle coupled with an HCCI (homogeneous charge compression ignition) engine," Energy, Elsevier, vol. 86(C), pages 672-684.
    14. Feng, Yong-qiang & Zhang, Fei-yang & Xu, Jing-wei & He, Zhi-xia & Zhang, Qiang & Xu, Kang-jing, 2023. "Parametric analysis and multi-objective optimization of biomass-fired organic Rankine cycle system combined heat and power under three operation strategies," Renewable Energy, Elsevier, vol. 208(C), pages 431-449.
    15. Fan, Gang & Lu, Xiaochen & Chen, Kang & Zhang, Yicen & Han, Zihao & Yu, Haibin & Dai, Yiping, 2022. "Comparative analysis on design and off-design performance of novel cascade CO2 combined cycles for gas turbine waste heat utilization," Energy, Elsevier, vol. 254(PA).
    16. Kim, Sunjin & Cho, Yeonjoo & Kim, Min Soo & Kim, Minsung, 2018. "Characteristics and optimization of supercritical CO2 recompression power cycle and the influence of pinch point temperature difference of recuperators," Energy, Elsevier, vol. 147(C), pages 1216-1226.
    17. Fan, Gang & Du, Yang & Li, Hang & Dai, Yiping, 2021. "Off-design behavior investigation of the combined supercritical CO2 and organic Rankine cycle," Energy, Elsevier, vol. 237(C).
    18. S. M. Seyed Mahmoudi & Niloufar Sarabchi & Mortaza Yari & Marc A. Rosen, 2019. "Exergy and Exergoeconomic Analyses of a Combined Power Producing System including a Proton Exchange Membrane Fuel Cell and an Organic Rankine Cycle," Sustainability, MDPI, vol. 11(12), pages 1-25, June.
    19. Sadeghi, Mohsen & Seyed Mahmoudi, Seyed Mohammad & Rosen, Marc A., 2022. "Thermoeconomic analysis of two solid oxide fuel cell based cogeneration plants integrated with simple or modified supercritical CO2 Brayton cycles: A comparative study," Energy, Elsevier, vol. 259(C).
    20. Cao, Yue & Rattner, Alexander S. & Dai, Yiping, 2018. "Thermoeconomic analysis of a gas turbine and cascaded CO2 combined cycle using thermal oil as an intermediate heat-transfer fluid," Energy, Elsevier, vol. 162(C), pages 1253-1268.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:15:y:2022:i:10:p:3555-:d:814159. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.