IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v318y2025ics0360544225004451.html
   My bibliography  Save this article

Combustion performance and NOx emissions in a 330 MW tangentially fired boiler retrofitted with preheating combustion devices

Author

Listed:
  • Wang, Siyuan
  • Tang, Hong
  • Liu, Zuodong
  • Han, Xiaoju
  • Shen, Xueqiang
  • Xu, Zhiming

Abstract

A preheating combustion device was designed and implemented in a 330 MW tangentially fired boiler to enhance combustion efficiency and reduce emissions. The device was placed between the primary combustion and burnout zones of the furnace. It pre-treated the fuel (bituminous coal) to generate high-temperature combustible gas and char under the excess air ratio range of 0.35–0.7, effectively lowering the nitrogen oxide (NOx) emissions in the primary combustion zone. Experimental investigations were carried out to analyze the composition of the preheated combustion products under varying pulverized coal concentrations and coal feed rates. The main combustible gases produced were CO, CH4, and H2. Additionally, numerical simulations were performed to evaluate the combustion characteristics and NOx emissions of the boiler with and without the preheating combustion device. The composition, temperature, and mass flow rate of gas and char measured from the experimental tests were used as input for the numerical simulations in the reduction zone. The study focused on the impact of pulverized coal concentration and coal feed rates on boiler performance. The results showed that retrofitting the boiler with the preheating combustion device led to a significant reduction in NOx emissions and improved combustion efficiency. As the pulverized coal concentration increased, the retrofitted boiler efficiency improved with minimal variation in NOx emissions. Moreover, increasing the preheating coal feed rate from 10 t/h to 40 t/h resulted in a rise in combustion efficiency, while the NOx emissions decreased from 167.6 mg/Nm3 to 121.1 mg/Nm3 (at 6 % O2), promoting cleaner and more efficient boiler combustion.

Suggested Citation

  • Wang, Siyuan & Tang, Hong & Liu, Zuodong & Han, Xiaoju & Shen, Xueqiang & Xu, Zhiming, 2025. "Combustion performance and NOx emissions in a 330 MW tangentially fired boiler retrofitted with preheating combustion devices," Energy, Elsevier, vol. 318(C).
    • Handle: RePEc:eee:energy:v:318:y:2025:i:c:s0360544225004451
    DOI: 10.1016/j.energy.2025.134803
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544225004451
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2025.134803?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Yan, Rong & Chen, Zhichao & Zhang, Bo & Zheng, Yu & Li, Zhengqi, 2022. "Impact of radial air staging on gas-particle flow characteristics in an industrial pulverized coal boiler," Energy, Elsevier, vol. 243(C).
    2. Li, Zixiang & Miao, Zhengqing & Shen, Xusheng & Li, Jiangtao, 2018. "Prevention of boiler performance degradation under large primary air ratio scenario in a 660 MW brown coal boiler," Energy, Elsevier, vol. 155(C), pages 474-483.
    3. Hong, Tang & Zuodong, Liu & Xiaoju, Han & Xueqiang, Shen & Yuqiu, Liu & Siyuan, Wang & Zhiming, Xu, 2024. "Experimental study on combustion characteristics of a 40 MW pulverized coal boiler based on a new low NOx burner with preheating function," Energy, Elsevier, vol. 305(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zhang, Xin & Chen, Zhichao & Hou, Jian & Liu, Zheng & Zeng, Lingyan & Li, Zhengqi, 2022. "Evaluation of wide-range coal combustion performance of a novel down-fired combustion technology based on gas–solid two-phase flow characteristics," Energy, Elsevier, vol. 248(C).
    2. Yuan, Zhenhua & Chen, Zhichao & Bian, Liguo & Li, Zhengqi, 2023. "Influence of over-fired air location on gas-particle flow characteristics within a coal-fired industrial boiler under radial air staging," Energy, Elsevier, vol. 283(C).
    3. Liu, Jie & Feng, Lele & Wu, Yuxin & Feng, Renhai & Chen, Shukuan & Zhao, Dongqiang, 2024. "Numerical investigation on H2S formation in a pulverized coal-fired boiler using recycled flue gas as near-wall air," Energy, Elsevier, vol. 313(C).
    4. Li, Zixiang & Qiao, Xinqi & Miao, Zhengqing, 2021. "A novel burner arrangement scheme with annularly combined multiple airflows for wall-tangentially fired pulverized coal boiler," Energy, Elsevier, vol. 222(C).
    5. Wang, Yanhong & Yu, Jie & Liang, Hejun & Li, Qi & Hu, Pengfei & Wang, Di, 2024. "Modeling on rapid prediction and cause diagnosis of boiler combustion efficiency," Energy, Elsevier, vol. 302(C).
    6. Zeng, Guang & Xu, Mingchen & Tu, Yaojie & Li, Zhenwei & Cai, Yongtie & Zheng, Zhimin & Tay, Kunlin & Yang, Wenming, 2020. "Influences of initial coal concentration on ignition behaviors of low-NOx bias combustion technology," Applied Energy, Elsevier, vol. 278(C).
    7. Yuan, Zhenhua & Chen, Zhichao & Bian, Liguo & Wu, Xiaolan & Zhang, Bo & Li, Jiawei & Qiao, Yanyu & Li, Zhengqi, 2023. "Influence of blade angle in the outer secondary air for swirl burner on the flow, combustion, and slagging characteristics in the pre-combustion chamber under the air-staged condition," Energy, Elsevier, vol. 275(C).
    8. Zima, Wiesław & Taler, Jan & Grądziel, Sławomir & Trojan, Marcin & Cebula, Artur & Ocłoń, Paweł & Dzierwa, Piotr & Taler, Dawid & Rerak, Monika & Majdak, Marek & Korzeń, Anna & Skrzyniowska, Dorota, 2022. "Thermal calculations of a natural circulation power boiler operating under a wide range of loads," Energy, Elsevier, vol. 261(PB).
    9. Liu, Mingyu & Chen, Sheng & Zhu, Hongwei & Zhou, Zijian & Xu, Jingying, 2023. "Numerical investigation of ammonia/coal co-combustion in a low NOx swirl burner," Energy, Elsevier, vol. 282(C).
    10. Heydar Maddah & Milad Sadeghzadeh & Mohammad Hossein Ahmadi & Ravinder Kumar & Shahaboddin Shamshirband, 2019. "Modeling and Efficiency Optimization of Steam Boilers by Employing Neural Networks and Response-Surface Method (RSM)," Mathematics, MDPI, vol. 7(7), pages 1-17, July.
    11. Li, Zixiang & Miao, Zhengqing & Shen, Xusheng & Li, Jiangtao, 2018. "Effects of momentum ratio and velocity difference on combustion performance in lignite-fired pulverized boiler," Energy, Elsevier, vol. 165(PA), pages 825-839.
    12. Wang, Yanhong & Zou, Zhihong & Lu, Ke & Li, Qi & Hu, Pengfei & Wang, Di, 2024. "Modeling for on-line monitoring of carbon burnout coefficient in boiler under partial load," Energy, Elsevier, vol. 288(C).
    13. Wu, Chunlei & Wang, Chao & Hou, Zongyu & Wang, Zhe, 2025. "Flexible peak shaving in coal-fired power plants: A comprehensive review of current challenges, recent advances, and future perspectives," Energy, Elsevier, vol. 327(C).
    14. Ma, Dafu & Zhang, Shouyu & He, Xiang & Zhang, Jian & Ding, Xian, 2023. "Combustion stability and NOX emission characteristics of a 300 MWe tangentially fired boiler under ultra-low loads with deep-air staging," Energy, Elsevier, vol. 269(C).
    15. Huang, Chunchao & Li, Zhengqi & Lu, Yue & Liu, Huacai & Fang, Fan & Chen, Zhichao, 2025. "Study on gas–particle flow and combustion stability of an improved burner for different boiler loads," Energy, Elsevier, vol. 316(C).
    16. Nahian Ismail Chowdhury & Bhaskaran Gopalakrishnan & Nishan Adhikari & Hailin Li & Zhichao Liu, 2024. "Evaluating Electrification of Fossil-Fuel-Fired Boilers for Decarbonization Using Discrete-Event Simulation," Energies, MDPI, vol. 17(12), pages 1-23, June.
    17. Yuan, Zhenhua & Chen, Zhichao & Wu, Xiaolan & Zhang, Ning & Bian, Liguo & Qiao, Yanyu & Li, Jiawei & Li, Zhengqi, 2022. "An innovative low-NOx combustion technology for industrial pulverized coal boiler: Gas-particle flow characteristics with different radial-air-staged levels," Energy, Elsevier, vol. 260(C).

    More about this item

    Keywords

    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:318:y:2025:i:c:s0360544225004451. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.