IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v282y2023ics0360544223017528.html

Numerical investigation of ammonia/coal co-combustion in a low NOx swirl burner

Author

Listed:
  • Liu, Mingyu
  • Chen, Sheng
  • Zhu, Hongwei
  • Zhou, Zijian
  • Xu, Jingying

Abstract

Co-firing of ammonia (NH3) and coal in boilers is a promising technology to reduce CO2 emissions from power plants. However, NH3/coal co-firing in swirl burners can impact the original flame structures and may lead to serious NOx emission issues due to the high concentration of nitrogen in NH3. In this study, a numerical simulation of a low-NOx swirl burner was carried out to investigate the changes in flame structure, carbon emission, and characteristics of NOx generation. The results show that, when the NH3 co-firing ratio is 10 cal%, the flame retains its original swirl structure, and a significant increase in NO formation is observed in situations with different injection positions. When the co-firing ratio increases to 20 cal% and 30 cal% and NH3 is injected through the central air pipe, the flame changes from a swirl flame to an elongated flame. The injected NH3 is wrapped by the low-temperature primary air, separating the NH3 from the high-temperature zone, and pyrolysis becomes the primary reaction pathway for NH3 consumption rather than oxidation. The NO concentrations measured at the chamber outlet can be reduced to 11.2mg/Nm3, which is lower than that from coal combustion. As the co-firing ratio further increases to 50 cal%, NH3 and air are well mixed and burned, forming a “candle-type” flame. This results in a significant rise in NO emissions.

Suggested Citation

  • Liu, Mingyu & Chen, Sheng & Zhu, Hongwei & Zhou, Zijian & Xu, Jingying, 2023. "Numerical investigation of ammonia/coal co-combustion in a low NOx swirl burner," Energy, Elsevier, vol. 282(C).
    • Handle: RePEc:eee:energy:v:282:y:2023:i:c:s0360544223017528
    DOI: 10.1016/j.energy.2023.128358
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544223017528
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2023.128358?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Tamura, Masato & Gotou, Takahiro & Ishii, Hiroki & Riechelmann, Dirk, 2020. "Experimental investigation of ammonia combustion in a bench scale 1.2 MW-thermal pulverised coal firing furnace," Applied Energy, Elsevier, vol. 277(C).
    2. Zeng, Guang & Zhou, Anqi & Fu, Jinming & Ji, Yang, 2022. "Experimental and numerical investigations on NOx formation and reduction mechanisms of pulverized-coal stereo-staged combustion," Energy, Elsevier, vol. 261(PB).
    3. Choi, Minsung & Park, Yeseul & Li, Xinzhuo & Kim, Kibeom & Sung, Yonmo & Hwang, Taegam & Choi, Gyungmin, 2021. "Numerical evaluation of pulverized coal swirling flames and NOx emissions in a coal-fired boiler: Effects of co- and counter-swirling flames and coal injection modes," Energy, Elsevier, vol. 217(C).
    4. Li, Yu & Fan, Weidong, 2016. "Effect of char gasification on NOx formation process in the deep air-staged combustion in a 20kW down flame furnace," Applied Energy, Elsevier, vol. 164(C), pages 258-267.
    5. Chen, Danan & Li, Jun & Li, Xing & Deng, Lisheng & He, Zhaohong & Huang, Hongyu & Kobayashi, Noriyuki, 2023. "Study on combustion characteristics of hydrogen addition on ammonia flame at a porous burner," Energy, Elsevier, vol. 263(PA).
    6. Jiang, Yu & Lee, Byoung-Hwa & Oh, Dong-Hun & Jeon, Chung-Hwan, 2022. "Influence of various air-staging on combustion and NOX emission characteristics in a tangentially fired boiler under the 50% load condition," Energy, Elsevier, vol. 244(PB).
    7. Benim, Ali Cemal & Deniz Canal, Cansu & Boke, Yakup Erhan, 2022. "Computational investigation of oxy-combustion of pulverized coal and biomass in a swirl burner," Energy, Elsevier, vol. 238(PC).
    8. Yan, Rong & Chen, Zhichao & Zhang, Bo & Zheng, Yu & Li, Zhengqi, 2022. "Impact of radial air staging on gas-particle flow characteristics in an industrial pulverized coal boiler," Energy, Elsevier, vol. 243(C).
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Xi, Zhiyuan & Guo, Tingting & Cao, Fan & Duan, Yuanyuan & Yang, Zhen, 2025. "Techno-economic analysis of coal-fired with green ammonia co-firing power system devoted to lower carbon emission," Energy, Elsevier, vol. 334(C).
    2. Su, Kun & Ouyang, Ziqu & Li, Shuyun & Chen, Qisi & Wang, Hongshuai & Ding, Hongliang & Wang, Wenyu, 2024. "Exploration on deep pulverized coal activation and ultra-low NOx emission strategies with novel purifying-combustion technology," Energy, Elsevier, vol. 313(C).
    3. Xiang Lin & Xin Lei & Chen Wang & Xuehui Jing & Wei Liu & Lijiang Dong & Qiaozhen Wang & Hao Lu, 2024. "Numerical Simulation Study of Hydrogen Blending Combustion in Swirl Pulverized Coal Burner," Energies, MDPI, vol. 17(1), pages 1-17, January.
    4. Li, Kun & Cheng, Leming & Zhao, Xin & Wang, Bo & Zhang, Qingyu & Zhu, Leigang & Kang, Qixun & Ma, Zhangke, 2024. "Experimental study of NH3 and coal Co-firing in a CFB and its nitrogen conversion," Energy, Elsevier, vol. 304(C).
    5. Cui, Baochong & Wang, Xiaoxiao & Yu, Shilin & Zhang, Kejie & Zhang, Yingjie & Ruan, Renhui & Wang, Xuebin & Tan, Houzhang, 2024. "Assisting denitrification and strengthening combustion by using ammonia/coal binary fuel gasification-combustion: Effects of injecting position and air distribution," Energy, Elsevier, vol. 312(C).
    6. Zeng, Yijie & Jeon, Chung-Hwan, 2025. "Advancing energy system decarbonization through high-ammonia co-firing: Performance optimization and environmental benefits in representative thermal power generation in South Korea," Energy, Elsevier, vol. 334(C).
    7. Zeng, Yijie & Kweon, Joonwoo & Kim, Gyeong-Min & Jeon, Chung-Hwan, 2024. "Carbon-free power generation strategy in South Korea: CFD simulation for ammonia injection strategies through boiler burner configurations in tangentially fired boiler," Energy, Elsevier, vol. 309(C).
    8. Kim, Jinyoung & Kim, Donghyun & Park, Sungwoo, 2025. "Numerical investigation of the hydrogen addition effect on NO formation in ammonia/air premixed flames at elevated pressure using an improved reaction mechanism," Energy, Elsevier, vol. 327(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zeng, Yijie & Kweon, Joonwoo & Kim, Gyeong-Min & Jeon, Chung-Hwan, 2024. "Carbon-free power generation strategy in South Korea: CFD simulation for ammonia injection strategies through boiler burner configurations in tangentially fired boiler," Energy, Elsevier, vol. 309(C).
    2. Li, Xinzhuo & Choi, Minsung & Jung, Chanho & Park, Yeseul & Choi, Gyungmin, 2022. "Effects of the staging position and air−LPG mixing ratio on the combustion and emission characteristics of coal and gas co-firing," Energy, Elsevier, vol. 254(PB).
    3. Cui, Baochong & Wang, Xiaoxiao & Yu, Shilin & Zhang, Kejie & Zhang, Yingjie & Ruan, Renhui & Wang, Xuebin & Tan, Houzhang, 2024. "Assisting denitrification and strengthening combustion by using ammonia/coal binary fuel gasification-combustion: Effects of injecting position and air distribution," Energy, Elsevier, vol. 312(C).
    4. Wang, Xin & Fan, Weidong & Chen, Jun & Zhang, Hai, 2024. "Experimental study of effect of a novel ammonia/coal co-firing mode on NOx emission under high temperature conditions," Renewable Energy, Elsevier, vol. 235(C).
    5. Zeng, Yijie & Jeon, Chung-Hwan, 2025. "Advancing energy system decarbonization through high-ammonia co-firing: Performance optimization and environmental benefits in representative thermal power generation in South Korea," Energy, Elsevier, vol. 334(C).
    6. Li, Kun & Cheng, Leming & Zhao, Xin & Wang, Bo & Zhang, Qingyu & Zhu, Leigang & Kang, Qixun & Ma, Zhangke, 2024. "Experimental study of NH3 and coal Co-firing in a CFB and its nitrogen conversion," Energy, Elsevier, vol. 304(C).
    7. Mohammadpour, Mohammadreza & Ashjaee, Mehdi & Houshfar, Ehsan, 2022. "Thermal performance and heat transfer characteristics analyses of oxy-biogas combustion in a swirl stabilized boiler under various oxidizing environments," Energy, Elsevier, vol. 261(PA).
    8. Kim, Jinyoung & Kim, Donghyun & Park, Sungwoo, 2025. "Numerical investigation of the hydrogen addition effect on NO formation in ammonia/air premixed flames at elevated pressure using an improved reaction mechanism," Energy, Elsevier, vol. 327(C).
    9. Yuan, Zhenhua & Chen, Zhichao & Bian, Liguo & Wu, Xiaolan & Zhang, Bo & Li, Jiawei & Qiao, Yanyu & Li, Zhengqi, 2023. "Influence of blade angle in the outer secondary air for swirl burner on the flow, combustion, and slagging characteristics in the pre-combustion chamber under the air-staged condition," Energy, Elsevier, vol. 275(C).
    10. Choi, Minsung & Hwang, Taegam & Park, Yeseul & Li, Xinzhuo & Kim, Junsung & Kim, Kibeom & Sung, Yonmo & Choi, Gyungmin, 2023. "Numerical evaluation of the effect of swirl configuration and fuel-rich environment on combustion and emission characteristics in a coal-fired boiler," Energy, Elsevier, vol. 268(C).
    11. Lijun Sun & Miao Wang & Peian Chong & Yunhao Shao & Lei Deng, 2025. "Numerical Simulation of a 330 MW Tangentially Fired Boiler by a Model Coupling CFD and Hydrodynamic Calculation," Energies, MDPI, vol. 18(10), pages 1-19, May.
    12. Zhang, Xin & Chen, Zhichao & Hou, Jian & Liu, Zheng & Zeng, Lingyan & Li, Zhengqi, 2022. "Evaluation of wide-range coal combustion performance of a novel down-fired combustion technology based on gas–solid two-phase flow characteristics," Energy, Elsevier, vol. 248(C).
    13. Hongliang Ding & Shuyun Li & Ziqu Ouyang & Shujun Zhu & Xiongwei Zeng & Haoyang Zhou & Kun Su & Hongshuai Wang & Jicheng Hui, 2025. "Experimental Study on Peak Shaving with Self-Preheating Combustion Equipped with a Novel Compact Fluidized Modification Device," Energies, MDPI, vol. 18(10), pages 1-30, May.
    14. Li, Xiangdong & Lin, Hui & Wang, Guan & Dai, Gaofeng & Chen, Yong Qiang & Luo, Yong & Zhang, Yili & Zhang, Jiaye & Tan, Houzhang & Axelbaum, Richard L. & Wang, Xuebin, 2025. "A full-scale staged, pressurized oxy-biomass combustion towards BECCS: Performance assessment via CFD approach," Energy, Elsevier, vol. 326(C).
    15. Zhao, Fei & Li, Yalou & Zhou, Xiaoxin & Wang, Dandan & Wei, Yawei & Li, Fang, 2023. "Co-optimization of decarbonized operation of coal-fired power plants and seasonal storage based on green ammonia co-firing," Applied Energy, Elsevier, vol. 341(C).
    16. Yiwei Wang & Yuan Wang & Sunhua Deng & Qiang Li & Jingjing Gu & Haoche Shui & Wei Guo, 2022. "Numerical Simulation Analysis of Heating Effect of Downhole Methane Catalytic Combustion Heater under High Pressure," Energies, MDPI, vol. 15(3), pages 1-23, February.
    17. Ahmad, Azaria Haykal & Aziz, Muhammad, 2025. "Decarbonization path of natural gas combined cycle using chemical looping hydrogen generation: Thermodynamics, emissions, and economics studies," Energy, Elsevier, vol. 335(C).
    18. Wen, Du & Aziz, Muhammad, 2022. "Techno-economic analyses of power-to-ammonia-to-power and biomass-to-ammonia-to-power pathways for carbon neutrality scenario," Applied Energy, Elsevier, vol. 319(C).
    19. Chen, Danan & Zhang, Junqing & Li, Jun & Li, Xing & Huang, Hongyu & Kobayashi, Noriyuki & Valera-Medina, Agustin, 2025. "Experimental and numerical study on the laminar burning velocities of n-dodecane/ammonia/air mixtures," Energy, Elsevier, vol. 326(C).
    20. Mohammad Bagheri, Saeed & Targhi, Mohammad Zabetian & Heyhat, Mohammad Mahdi & Ashouri, Ali, 2025. "Thermal analysis with extracting performance map in structured porous ceramic burners: A study for domestic cooking applications," Energy, Elsevier, vol. 338(C).

    More about this item

    Keywords

    ;
    ;
    ;
    ;

    JEL classification:

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:282:y:2023:i:c:s0360544223017528. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.