IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v13y2020i10p2537-d359181.html
   My bibliography  Save this article

Interleaved High Step-Up DC–DC Converter with Voltage-Lift and Voltage-Stack Techniques for Photovoltaic Systems

Author

Listed:
  • Shin-Ju Chen

    (Department of Electrical Engineering, Kun Shan University, Tainan 710303, Taiwan)

  • Sung-Pei Yang

    (Department of Electrical Engineering, Kun Shan University, Tainan 710303, Taiwan
    Green Energy Technology Research Center, Kun Shan University, Tainan 710303, Taiwan)

  • Chao-Ming Huang

    (Department of Electrical Engineering, Kun Shan University, Tainan 710303, Taiwan)

  • Yu-Hua Chen

    (Department of Electrical Engineering, Kun Shan University, Tainan 710303, Taiwan)

Abstract

A novel interleaved high step-up DC–DC converter applied for applications in photovoltaic systems is proposed in this paper. The proposed configuration is composed of three-winding coupled inductors, voltage multiplier cells and a clamp circuit. The step-up voltage gain is effectively increased, owing to the voltage-stack and voltage-lift techniques using the voltage multiplier cells. The leakage inductor energy is recycled by the clamp circuit to avoid the voltage surge on a power switch. The low-voltage-rated power switches with low on-state resistances and costs can be used to decrease the conduction losses and increase the conversion efficiency when the voltage stresses of power switches for the converter are considerably lower than the high output voltage. The reverse-recovery problems of diodes are mitigated by the leakage inductances of the coupled inductors. Moreover, both the input current ripple and the current stress on each power switch are reduced, owing to the interleaved operation. The operating principle and steady-state analysis of the proposed converter are thoroughly presented herein. A controller network is designed to diminish the effect of the variations of input voltage and output load on the output voltage. Finally, the experimental results for a 1 kW prototype with 28–380 V voltage conversion are shown to demonstrate its effectiveness and performance.

Suggested Citation

  • Shin-Ju Chen & Sung-Pei Yang & Chao-Ming Huang & Yu-Hua Chen, 2020. "Interleaved High Step-Up DC–DC Converter with Voltage-Lift and Voltage-Stack Techniques for Photovoltaic Systems," Energies, MDPI, vol. 13(10), pages 1-20, May.
    • Handle: RePEc:gam:jeners:v:13:y:2020:i:10:p:2537-:d:359181
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/13/10/2537/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/13/10/2537/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Yanying Gao & Hongchen Liu & Jian Ai, 2018. "Novel High Step-Up DC–DC Converter with Three-Winding-Coupled-Inductors and Its Derivatives for a Distributed Generation System," Energies, MDPI, vol. 11(12), pages 1-12, December.
    2. Amir Farakhor & Mehdi Abapour & Mehran Sabahi & Saeid Gholami Farkoush & Seung-Ryle Oh & Sang-Bong Rhee, 2020. "A Study on an Improved Three-Winding Coupled Inductor Based DC/DC Boost Converter with Continuous Input Current," Energies, MDPI, vol. 13(7), pages 1-18, April.
    3. Yong-Seng Wong & Jiann-Fuh Chen & Kuo-Bin Liu & Yi-Ping Hsieh, 2017. "A Novel High Step-Up DC-DC Converter with Coupled Inductor and Switched Clamp Capacitor Techniques for Photovoltaic Systems," Energies, MDPI, vol. 10(3), pages 1-17, March.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Aline V. C. Pereira & Marcelo C. Cavalcanti & Gustavo M. Azevedo & Fabrício Bradaschia & Rafael C. Neto & Márcio Rodrigo Santos de Carvalho, 2021. "A Novel Single-Switch High Step-Up DC–DC Converter with Three-Winding Coupled Inductor," Energies, MDPI, vol. 14(19), pages 1-17, October.
    2. Eduardo Augusto Oliveira Barbosa & Márcio Rodrigo Santos de Carvalho & Leonardo Rodrigues Limongi & Marcelo Cabral Cavalcanti & Eduardo José Barbosa & Gustavo Medeiros de Souza Azevedo, 2021. "High-Gain High-Efficiency DC–DC Converter with Single-Core Parallel Operation Switched Inductors and Rectifier Voltage Multiplier Cell," Energies, MDPI, vol. 14(15), pages 1-18, July.
    3. Salvatore Musumeci, 2022. "Special Issue “Advanced DC-DC Power Converters and Switching Converters”," Energies, MDPI, vol. 15(4), pages 1-5, February.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Aline V. C. Pereira & Marcelo C. Cavalcanti & Gustavo M. Azevedo & Fabrício Bradaschia & Rafael C. Neto & Márcio Rodrigo Santos de Carvalho, 2021. "A Novel Single-Switch High Step-Up DC–DC Converter with Three-Winding Coupled Inductor," Energies, MDPI, vol. 14(19), pages 1-17, October.
    2. Mauricio Dalla Vecchia & Giel Van den Broeck & Simon Ravyts & Johan Driesen, 2019. "Novel Step-Down DC–DC Converters Based on the Inductor–Diode and Inductor–Capacitor–Diode Structures in a Two-Stage Buck Converter," Energies, MDPI, vol. 12(6), pages 1-22, March.
    3. Ahmad Alzahrani & Pourya Shamsi & Mehdi Ferdowsi, 2020. "Interleaved Multistage Step-Up Topologies with Voltage Multiplier Cells," Energies, MDPI, vol. 13(22), pages 1-18, November.
    4. Héctor Hidalgo & Rodolfo Orosco & Héctor Huerta & Nimrod Vázquez & Claudia Hernández & Sergio Pinto, 2023. "A High-Voltage-Gain DC–DC Boost Converter with Zero-Ripple Input Current for Renewable Applications," Energies, MDPI, vol. 16(13), pages 1-23, June.
    5. Miran Rodič & Miro Milanovič & Mitja Truntič & Benjamin Ošlaj, 2018. "Switched-Capacitor Boost Converter for Low Power Energy Harvesting Applications," Energies, MDPI, vol. 11(11), pages 1-29, November.
    6. Krzysztof Górecki & Kalina Detka, 2019. "Influence of Power Losses in the Inductor Core on Characteristics of Selected DC–DC Converters," Energies, MDPI, vol. 12(10), pages 1-15, May.
    7. Yicheng Liu & Jieping Wang & Haiyan Tu, 2019. "Design and Implementation of Finite Time Nonsingular Fast Terminal Sliding Mode Control for a Novel High Step-Up DC-DC Converter," Energies, MDPI, vol. 12(9), pages 1-16, May.
    8. Salvatore Musumeci, 2023. "Energy Conversion Using Electronic Power Converters: Technologies and Applications," Energies, MDPI, vol. 16(8), pages 1-9, April.
    9. Yiwang Wang & Chun Gan & Kai Ni & Xinhua Li & Houjun Tang & Yong Yang, 2017. "A Multifunctional Isolated and Non-Isolated Dual Mode Converter for Renewable Energy Conversion Applications," Energies, MDPI, vol. 10(12), pages 1-17, November.
    10. Eduardo Augusto Oliveira Barbosa & Márcio Rodrigo Santos de Carvalho & Leonardo Rodrigues Limongi & Marcelo Cabral Cavalcanti & Eduardo José Barbosa & Gustavo Medeiros de Souza Azevedo, 2021. "High-Gain High-Efficiency DC–DC Converter with Single-Core Parallel Operation Switched Inductors and Rectifier Voltage Multiplier Cell," Energies, MDPI, vol. 14(15), pages 1-18, July.
    11. Shin-Ju Chen & Sung-Pei Yang & Chao-Ming Huang & Huann-Ming Chou & Meng-Jie Shen, 2018. "Interleaved High Step-Up DC-DC Converter Based on Voltage Multiplier Cell and Voltage-Stacking Techniques for Renewable Energy Applications," Energies, MDPI, vol. 11(7), pages 1-17, June.
    12. Flavio Balsamo & Davide Lauria & Fabio Mottola, 2019. "Design and Control of Coupled Inductor DC–DC Converters for MVDC Ship Power Systems," Energies, MDPI, vol. 12(4), pages 1-20, February.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:13:y:2020:i:10:p:2537-:d:359181. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.