IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v12y2019i22p4369-d287656.html
   My bibliography  Save this article

Combustion Characteristics of Plant Chemical Polyol Waste Liquor in a Pilot Water-Cooled Incinerator

Author

Listed:
  • Dawei Wang

    (School of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, China
    WuHan Boiler Energy Engineering CO., LTD, No.1 Jiangxia Avenue, Miaoshan Development District, Wuhan 430200, China)

  • Guangbo Zhao

    (School of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, China)

  • Chuanming Du

    (School of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, China)

  • Dongdong Feng

    (School of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, China)

  • Lin Wang

    (WuHan Boiler Energy Engineering CO., LTD, No.1 Jiangxia Avenue, Miaoshan Development District, Wuhan 430200, China)

Abstract

In the production of plant chemical alcohol, a large amount of salty high-concentration organic waste liquid is by-produced, in which a large amount of high-value sodium tungstate and chemical heat energy are contained. Through the design of the pilot water-cooled incinerator, the operating parameters and the characteristics of alkali ash deposition of the waste incinerator were tested. The pilot incinerator is a natural-cycle steam boiler, has a full water-cooled II-type structure, with liquid slag discharge, and the furnace design has selected reasonable volumetric heat load and flue gas residence time. Combustion distribution is the core parameter affecting the combustion of waste liquid. Studies have shown that increasing the primary air rate and the excess air coefficient are beneficial to improve the combustion performance of waste liquid, increase steam production, and reduce CO and SO 2 emissions in flue gas, but also increase the concentration of NO. When the excess air ratio was 1.2, and the primary air ratio was 0.65, the NO concentration in the tail flue gas was less than 10 ppm, and the SO 2 concentration was zero. The TG-DTA method measured that when the alkali ash melting temperature was less than 587 °C, the alkali ash had strong adhesion in the high temperature zone of the incinerator and less deposition in the low temperature region of the tail. The alkali ash deposition rate and relative deposition rate were used to quantitatively study the characteristic of alkali ash deposition.

Suggested Citation

  • Dawei Wang & Guangbo Zhao & Chuanming Du & Dongdong Feng & Lin Wang, 2019. "Combustion Characteristics of Plant Chemical Polyol Waste Liquor in a Pilot Water-Cooled Incinerator," Energies, MDPI, vol. 12(22), pages 1-18, November.
    • Handle: RePEc:gam:jeners:v:12:y:2019:i:22:p:4369-:d:287656
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/12/22/4369/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/12/22/4369/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Feng, Dongdong & Zhang, Yu & Zhao, Yijun & Sun, Shaozeng, 2018. "Catalytic effects of ion-exchangeable K+ and Ca2+ on rice husk pyrolysis behavior and its gas–liquid–solid product properties," Energy, Elsevier, vol. 152(C), pages 166-177.
    2. Dawei Wang & Chuanming Du & Dongdong Feng & Yuting Li & Yu Zhang & Yijun Zhao & Guangbo Zhao, 2019. "The Thermal Swelling Properties of Plant Chemical Alcohol Waste Liquid," Energies, MDPI, vol. 12(21), pages 1-11, November.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. He-Ming Dong & Qian Du & Dun Li & Zhao-Yang Cui & Jian-Min Gao & Shao-Hua Wu, 2019. "Impacts of Organic Structures and Inherent Minerals of Coal on Soot Formation during Pyrolysis," Energies, MDPI, vol. 12(23), pages 1-16, November.
    2. Jiang, Yuan & Zong, Peijie & Bao, Yuan & Zhang, Xin & Wei, Haixin & Tian, Bin & Tian, Yuanyu & Qiao, Yingyun & Zhang, Juntao, 2022. "Catalytic conversion of gaseous tar using coal char catalyst in the two-stage downer reactor," Energy, Elsevier, vol. 242(C).
    3. Imtiaz Anando, Ahmed & Ehsan, M Monjurul & Karim, Md Rezwanul & Bhuiyan, Arafat A. & Ahiduzzaman, Md & Karim, Azharul, 2023. "Thermochemical pretreatments to improve the fuel properties of rice husk: A review," Renewable Energy, Elsevier, vol. 215(C).
    4. Bao Wang & Yujie Li & Jianan Zhou & Yi Wang & Xun Tao & Xiang Zhang & Weiming Song, 2021. "Thermogravimetric and Kinetic Analysis of High-Temperature Thermal Conversion of Pine Wood Sawdust under CO 2 /Ar," Energies, MDPI, vol. 14(17), pages 1-16, August.
    5. Dawei Wang & Chuanming Du & Dongdong Feng & Yuting Li & Yu Zhang & Yijun Zhao & Guangbo Zhao, 2019. "The Thermal Swelling Properties of Plant Chemical Alcohol Waste Liquid," Energies, MDPI, vol. 12(21), pages 1-11, November.
    6. Gao, Xiaoyan & Zhang, Yaning & Xu, Fei & Yin, Zhaoqin & Wang, Yingying & Bao, Fubing & Li, Bingxi, 2019. "Experimental and kinetic studies on the intrinsic reactivities of rice husk char," Renewable Energy, Elsevier, vol. 135(C), pages 608-616.
    7. Liu, Chao & Liu, Jingyong & Evrendilek, Fatih & Xie, Wuming & Kuo, Jiahong & Buyukada, Musa, 2020. "Bioenergy and emission characterizations of catalytic combustion and pyrolysis of litchi peels via TG-FTIR-MS and Py-GC/MS," Renewable Energy, Elsevier, vol. 148(C), pages 1074-1093.
    8. Yong Huang & Yiling Wan & Shasha Liu & Yimeng Zhang & Huanhuan Ma & Shu Zhang & Jianbin Zhou, 2019. "A Downdraft Fixed-Bed Biomass Gasification System with Integrated Products of Electricity, Heat, and Biochar: The Key Features and Initial Commercial Performance," Energies, MDPI, vol. 12(15), pages 1-9, August.
    9. Sun, Kai & Zhang, Lijun & Xu, Qing & Zhang, Zhanming & Shao, Yuewen & Dong, Dehua & Gao, Guanggang & Liu, Qing & Wang, Shuang & Hu, Xun, 2020. "Evidence for cross-polymerization between the biomass-derived furans and phenolics," Renewable Energy, Elsevier, vol. 154(C), pages 517-531.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:12:y:2019:i:22:p:4369-:d:287656. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.