IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v312y2024ics0360544224033966.html
   My bibliography  Save this article

Evolution of structure and pyrolysis behavior of macerals and their interaction based on macro separation of a sub-bituminous coal

Author

Listed:
  • Peng, Zeyu
  • Zhang, Qian
  • Liang, Litong
  • Gao, Zhihua
  • Wang, Dong
  • Li, Le
  • Han, Chun
  • Jia, Yu
  • Huang, Wei

Abstract

High purity vitrinite (PV, 89.40 % vitrinite content), high purity inertinite (PI, 82.38 % inertinite content), and a series of fractions with varying macerals content were obtained from the macro separation of a sub-bituminous coal by the developed Kg-scale density gradient centrifugation separator. The structural characteristics and pyrolysis behaviors exhibited regular variation with the content of macerals. Compared with raw coal (RC), PV had the most abundant alkyl chains and a lower degree of condensation, resulting in the highest tar yield (14.11 %), which was 4.02 % higher than that of RC (10.09 %). The tar contained abundant aliphatics and phenolics. PI contained larger fused aromatics structure and shorter length alkyl side chains. Although tar yield from PI was relatively low (6.02 %), the tar contained the highest three- and four-ring aromatic hydrocarbons, which was more conducive to deriving value-added products. The tar yield from fractions with varying macerals content indicated that an increase in inertinite by approximately 10 % resulted in a 1 % decrease in tar yield. The interaction of the macerals was confirmed and it was affected by the content of vitrinite and inertinite. When the vitrinite and inertinite coexisted with proper proportion, the tar and aromatic hydrocarbons formation could be promoted.

Suggested Citation

  • Peng, Zeyu & Zhang, Qian & Liang, Litong & Gao, Zhihua & Wang, Dong & Li, Le & Han, Chun & Jia, Yu & Huang, Wei, 2024. "Evolution of structure and pyrolysis behavior of macerals and their interaction based on macro separation of a sub-bituminous coal," Energy, Elsevier, vol. 312(C).
    • Handle: RePEc:eee:energy:v:312:y:2024:i:c:s0360544224033966
    DOI: 10.1016/j.energy.2024.133618
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544224033966
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2024.133618?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Lin, Xiongchao & Luo, Meng & Li, Shouyi & Yang, Yuanping & Chen, Xujun & Tian, Bin & Wang, Yonggang, 2017. "The evolutionary route of coal matrix during integrated cascade pyrolysis of a typical low-rank coal," Applied Energy, Elsevier, vol. 199(C), pages 335-346.
    2. Yang, Wei & Wang, Yihan & Yan, Fazhi & Si, Guangyao & Lin, Baiquan, 2022. "Evolution characteristics of coal microstructure and its influence on methane adsorption capacity under high temperature pyrolysis," Energy, Elsevier, vol. 254(PA).
    3. Kuang, Yucen & Jiang, Tao & Wu, Longqi & Liu, Xiaoqian & Yang, Xuke & Sher, Farooq & Wei, Zhifang & Zhang, Shengfu, 2023. "High-temperature rheological behavior and non-isothermal pyrolysis mechanism of macerals separated from different coals," Energy, Elsevier, vol. 277(C).
    4. Li, Chunshan & Suzuki, Kenzi, 2010. "Resources, properties and utilization of tar," Resources, Conservation & Recycling, Elsevier, vol. 54(11), pages 905-915.
    5. Xu, Shipei & Zeng, Xi & Han, Zhennan & Cheng, Jiguang & Wu, Rongcheng & Chen, Zhaohui & Masĕk, Ondřej & Fan, Xianfeng & Xu, Guangwen, 2019. "Quick pyrolysis of a massive coal sample via rapid infrared heating," Applied Energy, Elsevier, vol. 242(C), pages 732-740.
    6. Liu, Yang & Fu, Peifang & Yu, Bo & Yan, Weijie & Chen, Yumin & Zhou, Huaichun, 2023. "Intrinsic combustion kinetics of rapid-pyrolysis Zhundong coal char," Energy, Elsevier, vol. 262(PB).
    7. Sonibare, Oluwadayo O. & Haeger, Tobias & Foley, Stephen F., 2010. "Structural characterization of Nigerian coals by X-ray diffraction, Raman and FTIR spectroscopy," Energy, Elsevier, vol. 35(12), pages 5347-5353.
    8. Lu, Yang & Wang, Ying & Zhang, Jing & Wang, Qi & Zhao, Yuqiong & Zhang, Yongfa, 2020. "Investigation on the characteristics of pyrolysates during co-pyrolysis of Zhundong coal and Changji oil shale and its kinetics," Energy, Elsevier, vol. 200(C).
    9. Tian, Bin & Zhao, Wanyi & Guo, Qingjie & Tian, Yuanyu, 2022. "A comprehensive understanding of synergetic effect and volatile interaction mechanisms during co-pyrolysis of rice husk and different rank coals," Energy, Elsevier, vol. 254(PB).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Duan, Zhonghui & Zhang, Yongmin & Yang, Fu & Liu, Meijuan & Wang, Zhendong & Zhao, Youzhi & Ma, Li, 2024. "Research on controllable shock wave technology for in-situ development of tar-rich coal," Energy, Elsevier, vol. 288(C).
    2. Liu, Xiangchun & Song, Huan & Han, Kangshun & Hu, Jun & Zhao, Zhigang & Cui, Ping, 2023. "Insight into low-temperature co-pyrolysis of Qinglongshan lean coal with organic matter in Huadian oil shale," Energy, Elsevier, vol. 285(C).
    3. Fan, Yuqiang & Guan, Jun & He, Demin & Hong, Yu & Zhang, Qiumin, 2023. "The influence of inherent minerals on the constant-current electrolysis process of coal-water slurry," Energy, Elsevier, vol. 285(C).
    4. Zhang, Chao & Zhao, Yangsheng & Feng, Zijun & Wang, Lei & Meng, Qiaorong & Lu, Yang & Gao, Qiang, 2023. "Comparative study on the chemical structure characteristics of lump coal during superheated water vapor pyrolysis and conventional pyrolysis," Energy, Elsevier, vol. 276(C).
    5. Zhang, He, 2024. "Study on microscale stress sensitivity of CO2 foam fracturing in tight reservoirs," Energy, Elsevier, vol. 294(C).
    6. Gu, Suqian & Xu, Zhiqiang & Ren, Yangguang & Tu, Yanan & Sun, Meijie & Liu, Xiangyang, 2021. "An approach for upgrading lignite to improve slurryability: Blending with direct coal liquefaction residue under microwave-assisted pyrolysis," Energy, Elsevier, vol. 222(C).
    7. Wendi Sun & Li Bai & Mingshu Chi & Xiuling Xu & Zhao Chen & Kecheng Yu, 2023. "Study on the Evolution Pattern of the Aromatics of Lignin during Hydrothermal Carbonization," Energies, MDPI, vol. 16(3), pages 1-14, January.
    8. Zhang, Wenda & Sun, Shaozeng & Zhao, Yijun & Zhao, Zujie & Wang, Pengxiang & Feng, Dongdong & Li, Pengfei, 2020. "Effects of total pressure and CO2 partial pressure on the physicochemical properties and reactivity of pressurized coal char produced at rapid heating rate," Energy, Elsevier, vol. 208(C).
    9. Abunowara, Mustafa & Sufian, Suriati & Bustam, Mohamad Azmi & Eldemerdash, Usama & Suleman, Humbul & Bencini, Roberto & Assiri, Mohammed Ali & Ullah, Sami & Al-Sehemi, Abdullah G., 2020. "Experimental measurements of carbon dioxide, methane and nitrogen high-pressure adsorption properties onto Malaysian coals under various conditions," Energy, Elsevier, vol. 210(C).
    10. Zhou, Xiaofeng & Wei, Jianguang & Zhao, Junfeng & Zhang, Xiangyu & Fu, Xiaofei & Shamil, Sultanov & Abdumalik, Gayubov & Chen, Yinghe & Wang, Jian, 2024. "Study on pore structure and permeability sensitivity of tight oil reservoirs," Energy, Elsevier, vol. 288(C).
    11. Ahsanullah Soomro & Shiyi Chen & Shiwei Ma & Wenguo Xiang, 2018. "Catalytic activities of nickel, dolomite, and olivine for tar removal and H2-enriched gas production in biomass gasification process," Energy & Environment, , vol. 29(6), pages 839-867, September.
    12. Li, Liangwei & Liu, Xianfeng & Nie, Baisheng & Sun, Haitao & Jia, Xueqi & Zhang, Chengpeng, 2024. "Microstructural alterations of coal induced by interaction with sequestered supercritical carbon dioxide," Energy, Elsevier, vol. 304(C).
    13. Zhu, Wenkun & Li, Xiaohui & Sun, Rui & Cao, Zhen & Yuan, Mengfan & Sun, Liutao & Yu, Xin & Wu, Jiangquan, 2022. "Investigation of the CN and C2 emission characteristics and microstructural evolution of coal to char using laser-induced breakdown spectroscopy and Raman spectroscopy," Energy, Elsevier, vol. 240(C).
    14. Zhao, Jingyu & Hang, Gai & Song, Jiajia & Lu, Shiping & Ming, Hanqi & Chang, Jiaming & Deng, Jun & Zhang, Yanni & Shu, Chi-Min, 2023. "Spontaneous oxidation kinetics of weathered coal based upon thermogravimetric characteristics," Energy, Elsevier, vol. 275(C).
    15. Yang, Dingding & Peng, Kai & Zheng, Yu & Chen, Yujia & Zheng, Juan & Wang, Man & Chen, Si, 2023. "Study on the characteristics of coal and gas outburst hazard under the influence of high formation temperature in deep mines," Energy, Elsevier, vol. 268(C).
    16. Li, Jiuqing & Qin, Yong & Shen, Jian & Chen, Yilin, 2024. "Evolution of carbon nanostructures during coal graphitization: Insights from X-ray diffraction and high-resolution transmission electron microscopy," Energy, Elsevier, vol. 290(C).
    17. Kang, Shijie & Sun, Youhong & Qiao, Mingyang & Li, Shengli & Deng, Sunhua & Guo, Wei & Li, Jiasheng & He, Wentong, 2022. "The enhancement on oil shale extraction of FeCl3 catalyst in subcritical water," Energy, Elsevier, vol. 238(PA).
    18. Zhao, Jingyu & Deng, Jun & Chen, Long & Wang, Tao & Song, Jiajia & Zhang, Yanni & Shu, Chi-Min & Zeng, Qiang, 2019. "Correlation analysis of the functional groups and exothermic characteristics of bituminous coal molecules during high-temperature oxidation," Energy, Elsevier, vol. 181(C), pages 136-147.
    19. Ren, Yangguang & Xu, Zhiqiang & Gu, Suqian, 2022. "Physicochemical properties and slurry ability changes of lignite after microwave upgrade with the assist of lignite semi-coke," Energy, Elsevier, vol. 252(C).
    20. Wang, Hao & Wang, Liang & Zheng, Siwen & Sun, Yiwei & Shen, Shangkun & Zhang, Xiaolei, 2024. "Research on coal matrix pore structure evolution and adsorption behavior characteristics under different thermal stimulation," Energy, Elsevier, vol. 287(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:312:y:2024:i:c:s0360544224033966. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.