IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v326y2025ics0360544225018006.html

Critical discussion on the challenges of integrating heat pumps in hydronic systems in existing buildings

Author

Listed:
  • Cholewa, Tomasz
  • Bejan, Andrei-Stelian
  • Miara, Marek
  • Schauer, Christian
  • Kosonen, Risto
  • Borodiņecs, Anatolijs
  • Bogdanovičs, Raimonds
  • Amanowicz, Łukasz
  • Vering, Christian
  • Siuta-Olcha, Alicja
  • Skwarczyński, Mariusz A.
  • Kropp, Michael
  • Kurnitski, Jarek
  • Lungu, Catalin
  • Croitoru, Cristiana
  • Afshari, Alireza
  • Alfano, Francesca Romana d'Ambrosio
  • Müller, Dirk
  • Nastase, Ilinca
  • Todorovic, Marija
  • Sekret, Robert

Abstract

The integration of heat pumps into existing buildings is one option to exploit carbon neutral heat and cool sources. Today, this is in line with planned electrification and paths to achieve nearly zero energy buildings by using renewable energy sources. However, the implementation process is more complex compared to new buildings. Moreover, there is no comprehensive study that depicts and critically discusses the main challenges associated with integrating heat pumps into existing buildings from a very practical point of view. This article presents the main technical and economic challenges related to the application of heat pumps in existing building stock based on critical literature review and discussion. Among others, especially, procedures involving the reduction of the supply temperature of the heating medium, the selection of the bivalent point, heat storage, and buffer tanks of heat pumps were discussed. Several best practices for the design and control of the heat pumps in existing buildings along with a discussion of benefits and limitations (technical, economic, operational) of the analyzed systems are provided. Key findings are: (i) it was indicated that the heat pumps in existing buildings can be applied as a heat source for the entire building, part or single room and for different purposes (space heating and/or DHW and/or cooling), (ii) minimisation of the supply temperature is always desirable, with the limit for DHW being 58 °C, and ultimately the control should be adapted to the building or replaced by forecast-based control, (iii) coverage of heat demand by heat pumps should reach 70–90 % of peak demand at nominal outdoor air conditions and be determined on the basis of the analysis of initial and running costs, (iv) from the point of view of reducing the demand for primary energy self-consumption of electricity from PV should be maximised. Finally, future research and development directions are suggested.

Suggested Citation

  • Cholewa, Tomasz & Bejan, Andrei-Stelian & Miara, Marek & Schauer, Christian & Kosonen, Risto & Borodiņecs, Anatolijs & Bogdanovičs, Raimonds & Amanowicz, Łukasz & Vering, Christian & Siuta-Olcha, Alic, 2025. "Critical discussion on the challenges of integrating heat pumps in hydronic systems in existing buildings," Energy, Elsevier, vol. 326(C).
    • Handle: RePEc:eee:energy:v:326:y:2025:i:c:s0360544225018006
    DOI: 10.1016/j.energy.2025.136158
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544225018006
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2025.136158?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to

    for a different version of it.

    References listed on IDEAS

    as
    1. Mi, Peiyuan & Zhang, Jili & Han, Youhua, 2024. "Operation study of the photovoltaic thermal heat pump integrated energy system under trigeneration condition and harsh conditions," Energy, Elsevier, vol. 312(C).
    2. Kaiser Ahmed & Jevgeni Fadejev & Jarek Kurnitski, 2019. "Modeling an Alternate Operational Ground Source Heat Pump for Combined Space Heating and Domestic Hot Water Power Sizing," Energies, MDPI, vol. 12(11), pages 1-26, June.
    3. Gao, Jinshuang & Li, Sheng & Adnouni, M. & Huang, Yan & Yu, Meng & Zhao, Yazhou & Zhang, Xuejun, 2024. "Simulation study on thermal performance of solar coupled air source heat pump system with phase change heat storage in cold regions," Energy, Elsevier, vol. 308(C).
    4. Li, Yunhai & Cui, Yu & Song, Zhiying & Zhao, Xudong & Li, Jing & Shen, Chao, 2023. "Eco-economic performance and application potential of a novel dual-source heat pump heating system," Energy, Elsevier, vol. 283(C).
    5. O'Hegarty, R. & Kinnane, O. & Lennon, D. & Colclough, S., 2022. "Air-to-water heat pumps: Review and analysis of the performance gap between in-use and product rated performance," Renewable and Sustainable Energy Reviews, Elsevier, vol. 155(C).
    6. Ma, Longxia & Sun, Yongjun & Wang, Fenghao & Wang, Ming & Zhang, Sheng & Wang, Zhihua, 2025. "Advancements in anti-frosting and defrosting techniques for air source heat pumps: A comprehensive review of recent progress," Applied Energy, Elsevier, vol. 377(PA).
    7. Wüllhorst, Fabian & Schwarz, Sebastian & Fuchs, Nico & Maier, Laura & Monti, Antonello & Müller, Dirk, 2025. "Impact of hybrid heat pump shares and building envelope retrofit rates on load penetration in German low-voltage grids," Applied Energy, Elsevier, vol. 388(C).
    8. Andersen, Martin Pihl & Zühlsdorf, Benjamin & Markussen, Wiebke Brix & Jensen, Jonas Kjær & Elmegaard, Brian, 2024. "Selection of working fluids and heat pump cycles at high temperatures: Creating a concise technology portfolio," Applied Energy, Elsevier, vol. 376(PB).
    9. Langerova, E. & Kralicek, J. & Kucera, M., 2025. "Air-to-water heat pump noise in residential settings: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 207(C).
    10. Luo, Zhenyu & Zhu, Na & Yu, Zhongyi & Zhang, Qin & Yan, Lei & Hu, Pingfang, 2024. "Performance study of dual-source heat pump integrated with radiation capillary terminal system," Energy, Elsevier, vol. 304(C).
    11. Olympios, Andreas V. & Song, Jian & Ziolkowski, Aleksander & Shanmugam, Vethalingam S. & Markides, Christos N., 2024. "Data-driven compressor performance maps and cost correlations for small-scale heat-pumping applications," Energy, Elsevier, vol. 291(C).
    12. Lämmle, Manuel & Bongs, Constanze & Wapler, Jeannette & Günther, Danny & Hess, Stefan & Kropp, Michael & Herkel, Sebastian, 2022. "Performance of air and ground source heat pumps retrofitted to radiator heating systems and measures to reduce space heating temperatures in existing buildings," Energy, Elsevier, vol. 242(C).
    13. Fraga, Carolina & Hollmuller, Pierre & Schneider, Stefan & Lachal, Bernard, 2018. "Heat pump systems for multifamily buildings: Potential and constraints of several heat sources for diverse building demands," Applied Energy, Elsevier, vol. 225(C), pages 1033-1053.
    14. Winskel, Mark & Heptonstall, Philip & Gross, Robert, 2024. "Reducing heat pump installed costs: Reviewing historic trends and assessing future prospects," Applied Energy, Elsevier, vol. 375(C).
    15. Davide Menegazzo & Giulia Lombardo & Sergio Bobbo & Michele De Carli & Laura Fedele, 2022. "State of the Art, Perspective and Obstacles of Ground-Source Heat Pump Technology in the European Building Sector: A Review," Energies, MDPI, vol. 15(7), pages 1-25, April.
    16. Pochwała, Sławomir & Anweiler, Stanisław & Tańczuk, Mariusz & Klementowski, Igor & Przysiężniuk, Dawid & Adrian, Łukasz & McNamara, Greg & Stevanović, Žana, 2023. "Energy source impact on the economic and environmental effects of retrofitting a heritage building with a heat pump system," Energy, Elsevier, vol. 278(PB).
    17. Kerme, Esa Dube & Alzahrani, Waleed Saeed & Fung, Alan S. & Leong, Wey H., 2024. "Experimental investigation of ground-source heat pump system coupled to vertical and horizontal ground loops: A case study," Renewable Energy, Elsevier, vol. 236(C).
    18. Wang, Yongjie & Zhan, Changhong & Li, Guanghao & Ren, Shaochen, 2024. "Comparison of algorithms for heat load prediction of buildings," Energy, Elsevier, vol. 297(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zheyuan Han & Kaiying Wang & Limin Dai & Kui Li & Xiaoshuai Wang, 2024. "Recent Application of Heat Pump Systems for Environmental Control in Livestock Facilities–A Review," Agriculture, MDPI, vol. 14(12), pages 1-21, December.
    2. Potthoff, Ugne & Brudermueller, Tobias & Hopf, Konstantin & Wortmann, Felix, 2025. "Optimization of heating curves for heat pumps in operation: Outdoor temperature ranges for energy-efficient heating curve shifts," Applied Energy, Elsevier, vol. 389(C).
    3. Omar Montero & Pauline Brischoux & Simon Callegari & Carolina Fraga & Matthias Rüetschi & Edouard Vionnet & Nicole Calame & Fabrice Rognon & Martin Patel & Pierre Hollmuller, 2022. "Large Air-to-Water Heat Pumps for Fuel-Boiler Substitution in Non-Retrofitted Multi-Family Buildings—Energy Performance, CO 2 Savings, and Lessons Learned in Actual Conditions of Use," Energies, MDPI, vol. 15(14), pages 1-29, July.
    4. Shan, Lianying & Martin, Andrew & Chiu, Justin NingWei, 2024. "Techno-economic analysis of latent heat thermal energy storage integrated heat pump for indoor heating," Energy, Elsevier, vol. 298(C).
    5. Suresh, C. & Awasthi, Abhishek & Kumar, Binit & Lee, Hyoungsoon & Jeon, Yongseok, 2026. "Comprehensive review on heat pump systems integrated with phase change material-based thermal energy storage for sustainable building heating," Renewable and Sustainable Energy Reviews, Elsevier, vol. 226(PA).
    6. Barnaś, Krzysztof & Jeleński, Tomasz & Nowak-Ocłoń, Marzena & Racoń-Leja, Kinga & Radziszewska-Zielina, Elżbieta & Szewczyk, Bartłomiej & Śladowski, Grzegorz & Toś, Cezary & Varbanov, Petar Sabev, 2023. "Algorithm for the comprehensive thermal retrofit of housing stock aided by renewable energy supply: A sustainable case for Krakow," Energy, Elsevier, vol. 263(PD).
    7. Naili, Nabiha & Nouicer, Omeima & Abbassi, Fakhreddine & Kooli, Sami, 2025. "Experimental study of ground source heat pump system coupled with a new auxiliary heat source for space heating: A case study of Tunisia," Renewable Energy, Elsevier, vol. 251(C).
    8. Vallati, Andrea & Di Matteo, Miriam & Lo Basso, Gianluigi & Ocłoń, Paweł & Fiorini, Costanza Vittoria, 2024. "Definition of a PVT coupled water source heat pump system through optimization of individual components," Energy, Elsevier, vol. 307(C).
    9. Rieck, Katharina & Dabrock, Kristina & Pflugradt, Noah & Weinand, Jann Michael & Stolten, Detlef, 2025. "Large-scale quantification of the future self-covered heat demand using a nationwide residential building database," Energy, Elsevier, vol. 317(C).
    10. Luo, Zhenyu & Zhu, Na & Yu, Zhongyi & Zhang, Qin & Yan, Lei & Hu, Pingfang, 2024. "Performance study of dual-source heat pump integrated with radiation capillary terminal system," Energy, Elsevier, vol. 304(C).
    11. Dong, Shengming & Liu, Tong & Hu, Xiaowei & Zhang, Chen & Hu, Pengli & Zhuang, Wenhui & Liu, Qiyou, 2025. "Investigation on the long short-term memory-based models for rural heating load prediction in Northeast China," Energy, Elsevier, vol. 318(C).
    12. Jiang, Jize & Wang, Chenglong & Bouazza, Abdelmalek & Ding, Xuanming & Kong, Gangqiang & Huang, Xu, 2026. "Exploring a new heat transfer model between circumferentially arranged pipes and tunnel lining in energy tunnels," Renewable Energy, Elsevier, vol. 256(PG).
    13. Yang, Jangho & Lee, Cheng-Yi & Muehlbauer, Jan & Hwang, Yunho, 2025. "Advanced defrosting techniques in air source heat pumps: A review of vapor injection, thermal energy storage, and experimental frost accumulation data," Energy, Elsevier, vol. 340(C).
    14. Xie, Yiwei & Hu, Pingfang & Li, Siyi, 2024. "Development of a doubly-fed compound control for hybrid ground source heat pump systems in hot summer and cold winter areas," Renewable Energy, Elsevier, vol. 237(PA).
    15. Sun, Chunhua & Ma, Weichi & Cao, Shanshan & Yuan, Lingyu & Qi, Chengying & Wu, Xiangdong, 2025. "Dynamic heat consumption benchmarking and carbon reduction potential mining of heating stations based on improved decision tree and association rule mining," Energy, Elsevier, vol. 332(C).
    16. Angeliki Kitsopoulou & Antonis Zacharis & Nikolaos Ziozas & Evangelos Bellos & Petros Iliadis & Ioannis Lampropoulos & Eleni Chatzigeorgiou & Komninos Angelakoglou & Nikolaos Nikolopoulos, 2023. "Dynamic Energy Analysis of Different Heat Pump Heating Systems Exploiting Renewable Energy Sources," Sustainability, MDPI, vol. 15(14), pages 1-36, July.
    17. Hermann, Julian & Kachirayil, Febin & Lohrmann, Alena & Scheller, Fabian & Roskosch, Dennis & McKenna, Russell, 2025. "A critical reflection on modelling approaches for heat pumps and building envelope retrofits in local energy system optimisations," Applied Energy, Elsevier, vol. 400(C).
    18. Klingebiel, Jonas & Höges, Christoph & Horst, Janik & Nießen, Oliver & Venzik, Valerius & Vering, Christian & Müller, Dirk, 2025. "A self-optimizing defrost initiation controller for air-source heat pumps: Experimental validation of deep reinforcement learning," Applied Energy, Elsevier, vol. 398(C).
    19. Inmaculada Gallego-Maya & Carlos Rubio-Bellido, 2024. "Use of International Adaptive Thermal Comfort Models as a Strategy for Adjusting the Museum Environments of the Mudejar Pavilion, Seville," Energies, MDPI, vol. 17(21), pages 1-22, November.
    20. Aunedi, Marko & Olympios, Andreas V. & Pantaleo, Antonio M. & Mersch, Matthias & Markides, Christos N., 2025. "System-level techno-economic comparison of residential low-carbon heating and cooling solutions," Energy, Elsevier, vol. 317(C).

    More about this item

    Keywords

    ;
    ;
    ;
    ;
    ;
    ;

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:326:y:2025:i:c:s0360544225018006. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.