IDEAS home Printed from https://ideas.repec.org/a/wly/greenh/v10y2020i2p421-435.html
   My bibliography  Save this article

Waste heat recovery from the stripped gas in carbon capture process by membrane technology: Hydrophobic and hydrophilic organic membrane cases

Author

Listed:
  • Liqiang Xu
  • Qiufang Cui
  • Te Tu
  • Shuo Liu
  • Long Ji
  • Shuiping Yan

Abstract

In this study, hydrophobic polytetrafluoroethylene (PTFE) and hydrophilic polyetheretherketone (PEEK) membranes were used as heat exchangers in rich‐split CO2 capture process to recover the waste heat from the stripped gas (i.e., mixture of water vapor and CO2). Technical feasibilities of these two membrane exchangers were assessed by heat recovery and energy intensity in the monoethanolamine (MEA)‐based carbon capture process. The heat recovery of these two membrane exchangers with different pore sizes were then systematically compared under various operating parameters. The underlying mass and heat transfer mechanisms of two membranes were also investigated and compared to figure out the suitable candidate for heat recovery. Additionally, the potential risks of using these membrane exchangers were identified and investigated. Results showed that the PTFE membrane displays a better heat recovery performance than the PEEK membrane with the same pore size. The heat recovery of both PTFE and PEEK membranes first increases to a plateau and then drops slightly with the increased CO2‐rich solvent flow rate. The heat recovery of PTFE and PEEK membranes decreases with the increased flow rate and water vapor fraction of the inlet stripped gas, MEA temperature, and MEA concentration. Furthermore, the larger pore size results in higher heat recovery for both PTFE and PEEK membranes. PTFE membranes displayed lower MEA transfer flux than PTFE membranes at any rich MEA flow rate as the enhanced MEA transfer from the cold solution to the other side via PEEK membrane pores filled with liquid water. © 2020 Society of Chemical Industry and John Wiley & Sons, Ltd.

Suggested Citation

  • Liqiang Xu & Qiufang Cui & Te Tu & Shuo Liu & Long Ji & Shuiping Yan, 2020. "Waste heat recovery from the stripped gas in carbon capture process by membrane technology: Hydrophobic and hydrophilic organic membrane cases," Greenhouse Gases: Science and Technology, Blackwell Publishing, vol. 10(2), pages 421-435, April.
    • Handle: RePEc:wly:greenh:v:10:y:2020:i:2:p:421-435
    DOI: 10.1002/ghg.1971
    as

    Download full text from publisher

    File URL: https://doi.org/10.1002/ghg.1971
    Download Restriction: no
    File URL: https://libkey.io/10.1002/ghg.1971?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    References listed on IDEAS

    as
    1. Wang, Dandan & Li, Sheng & Liu, Feng & Gao, Lin & Sui, Jun, 2018. "Post combustion CO2 capture in power plant using low temperature steam upgraded by double absorption heat transformer," Applied Energy, Elsevier, vol. 227(C), pages 603-612.
    2. Zhang, Xian & Fan, Jing-Li & Wei, Yi-Ming, 2013. "Technology roadmap study on carbon capture, utilization and storage in China," Energy Policy, Elsevier, vol. 59(C), pages 536-550.
    3. Wang, Dexin & Bao, Ainan & Kunc, Walter & Liss, William, 2012. "Coal power plant flue gas waste heat and water recovery," Applied Energy, Elsevier, vol. 91(1), pages 341-348.
    4. Zhang, Zhien & Li, Yifu & Zhang, Wenxiang & Wang, Junlei & Soltanian, Mohamad Reza & Olabi, Abdul Ghani, 2018. "Effectiveness of amino acid salt solutions in capturing CO2: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 98(C), pages 179-188.
    5. Ashleigh Cousins & Aaron Cottrell & Anthony Lawson & Sanger Huang & Paul H.M. Feron, 2012. "Model verification and evaluation of the rich‐split process modification at an Australian‐based post combustion CO 2 capture pilot plant," Greenhouse Gases: Science and Technology, Blackwell Publishing, vol. 2(5), pages 329-345, October.
    6. Duan, Liqiang & Zhao, Mingde & Yang, Yongping, 2012. "Integration and optimization study on the coal-fired power plant with CO2 capture using MEA," Energy, Elsevier, vol. 45(1), pages 107-116.
    7. Oh, Se-Young & Binns, Michael & Cho, Habin & Kim, Jin-Kuk, 2016. "Energy minimization of MEA-based CO2 capture process," Applied Energy, Elsevier, vol. 169(C), pages 353-362.
    8. Rashidi, Saman & Kashefi, Mohammad Hossein & Kim, Kyung Chun & Samimi-Abianeh, Omid, 2019. "Potentials of porous materials for energy management in heat exchangers – A comprehensive review," Applied Energy, Elsevier, vol. 243(C), pages 206-232.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Cui, Qiufang & Tu, Te & Ji, Long & Yan, Shuiping, 2021. "CO2 capture cost saving through waste heat recovery using transport membrane condenser in different solvent-based carbon capture processes," Energy, Elsevier, vol. 216(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Guo, Liheng & Ding, Yudong & Liao, Qiang & Zhu, Xun & Wang, Hong, 2022. "A new heat supply strategy for CO2 capture process based on the heat recovery from turbine exhaust steam in a coal-fired power plant," Energy, Elsevier, vol. 239(PA).
    2. Zheng, Yawen & Gao, Lin & He, Song, 2023. "Analysis of the mechanism of energy consumption for CO2 capture in a power system," Energy, Elsevier, vol. 262(PA).
    3. Cheng, Chin-hung & Li, Kangkang & Yu, Hai & Jiang, Kaiqi & Chen, Jian & Feron, Paul, 2018. "Amine-based post-combustion CO2 capture mediated by metal ions: Advancement of CO2 desorption using copper ions," Applied Energy, Elsevier, vol. 211(C), pages 1030-1038.
    4. Cui, Qiufang & Tu, Te & Ji, Long & Yan, Shuiping, 2021. "CO2 capture cost saving through waste heat recovery using transport membrane condenser in different solvent-based carbon capture processes," Energy, Elsevier, vol. 216(C).
    5. Ali Saleh Bairq, Zain & Gao, Hongxia & Huang, Yufei & Zhang, Haiyan & Liang, Zhiwu, 2019. "Enhancing CO2 desorption performance in rich MEA solution by addition of SO42−/ZrO2/SiO2 bifunctional catalyst," Applied Energy, Elsevier, vol. 252(C), pages 1-1.
    6. Rongrong Zhai & Hongtao Liu & Hao Wu & Hai Yu & Yongping Yang, 2018. "Analysis of Integration of MEA-Based CO 2 Capture and Solar Energy System for Coal-Based Power Plants Based on Thermo-Economic Structural Theory," Energies, MDPI, vol. 11(5), pages 1-30, May.
    7. Wang, Rujie & Liu, Shanshan & Wang, Lidong & Li, Qiangwei & Zhang, Shihan & Chen, Bo & Jiang, Lei & Zhang, Yifeng, 2019. "Superior energy-saving splitter in monoethanolamine-based biphasic solvents for CO2 capture from coal-fired flue gas," Applied Energy, Elsevier, vol. 242(C), pages 302-310.
    8. Zhao, Bin & Liu, Fangzheng & Cui, Zheng & Liu, Changjun & Yue, Hairong & Tang, Siyang & Liu, Yingying & Lu, Houfang & Liang, Bin, 2017. "Enhancing the energetic efficiency of MDEA/PZ-based CO2 capture technology for a 650MW power plant: Process improvement," Applied Energy, Elsevier, vol. 185(P1), pages 362-375.
    9. Fu, Kun & Zheng, Mingzhen & Fu, Dong, 2023. "Low partial pressure CO2 capture in packed tower by EHA+Diglyme water-lean absorbent," Energy, Elsevier, vol. 266(C).
    10. Yoro, Kelvin O. & Daramola, Michael O. & Sekoai, Patrick T. & Armah, Edward K. & Wilson, Uwemedimo N., 2021. "Advances and emerging techniques for energy recovery during absorptive CO2 capture: A review of process and non-process integration-based strategies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 147(C).
    11. Li, Kangkang & Jiang, Kaiqi & Jones, Timothy W. & Feron, Paul H.M. & Bennett, Robert D. & Hollenkamp, Anthony F., 2019. "CO2 regenerative battery for energy harvesting from ammonia-based post-combustion CO2 capture," Applied Energy, Elsevier, vol. 247(C), pages 417-425.
    12. Chuenphan, Thapanat & Yurata, Tarabordin & Sema, Teerawat & Chalermsinsuwan, Benjapon, 2022. "Techno-economic sensitivity analysis for optimization of carbon dioxide capture process by potassium carbonate solution," Energy, Elsevier, vol. 254(PA).
    13. Xie, Weiyi & Chen, Xiaoping & Ma, Jiliang & Liu, Daoyin & Cai, Tianyi & Wu, Ye, 2019. "Energy analyses and process integration of coal-fired power plant with CO2 capture using sodium-based dry sorbents," Applied Energy, Elsevier, vol. 252(C), pages 1-1.
    14. Yue Hu & Yachi Gao & Hui Lv & Gang Xu & Shijie Dong, 2018. "A New Integration System for Natural Gas Combined Cycle Power Plants with CO 2 Capture and Heat Supply," Energies, MDPI, vol. 11(11), pages 1-13, November.
    15. Wu, Xiaomei & Fan, Huifeng & Sharif, Maimoona & Yu, Yunsong & Wei, Keming & Zhang, Zaoxiao & Liu, Guangxin, 2021. "Electrochemically-mediated amine regeneration of CO2 capture: From electrochemical mechanism to bench-scale visualization study," Applied Energy, Elsevier, vol. 302(C).
    16. Jiang, Kaiqi & Li, Kangkang, 2023. "Harvesting CO2 reaction enthalpy from amine scrubbing," Energy, Elsevier, vol. 284(C).
    17. Zhang, Xiaowen & Zhang, Rui & Liu, Helei & Gao, Hongxia & Liang, Zhiwu, 2018. "Evaluating CO2 desorption performance in CO2-loaded aqueous tri-solvent blend amines with and without solid acid catalysts," Applied Energy, Elsevier, vol. 218(C), pages 417-429.
    18. Liang, Ying & Cai, Lei & Guan, Yanwen & Liu, Wenbin & Xiang, Yanlei & Li, Juan & He, Tianzhi, 2020. "Numerical study on an original oxy-fuel combustion power plant with efficient utilization of flue gas waste heat," Energy, Elsevier, vol. 193(C).
    19. Alivand, Masood S. & Mazaheri, Omid & Wu, Yue & Stevens, Geoffrey W. & Scholes, Colin A. & Mumford, Kathryn A., 2019. "Development of aqueous-based phase change amino acid solvents for energy-efficient CO2 capture: The role of antisolvent," Applied Energy, Elsevier, vol. 256(C).
    20. Oko, Eni & Ramshaw, Colin & Wang, Meihong, 2018. "Study of intercooling for rotating packed bed absorbers in intensified solvent-based CO2 capture process," Applied Energy, Elsevier, vol. 223(C), pages 302-316.

    More about this item

    Statistics

    Access and download statistics

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:wly:greenh:v:10:y:2020:i:2:p:421-435. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Wiley Content Delivery (email available below). General contact details of provider: https://doi.org/10.1002/(ISSN)2152-3878 .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.