IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v9y2015i1p15-d61353.html
   My bibliography  Save this article

Fumed Silica Nanoparticles Incorporated in Quaternized Poly(Vinyl Alcohol) Nanocomposite Membrane for Enhanced Power Densities in Direct Alcohol Alkaline Fuel Cells

Author

Listed:
  • Selvaraj Rajesh Kumar

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

  • Cheng-Hsin Juan

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

  • Guan-Ming Liao

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

  • Jia-Shiun Lin

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

  • Chun-Chen Yang

    (Department of Chemical Engineering, Mingchi University of Technology, Tai-shan, New Taipei City 243, Taiwan)

  • Wei-Ting Ma

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

  • Jiann-Hua You

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

  • Shingjiang Jessie Lue

    (Department of Chemical and Materials Engineering, Chang Gung University, Kwei-shan, Taoyuan 333, Taiwan)

Abstract

A nanocomposite polymer membrane based on quaternized poly(vinyl alcohol)/fumed silica (QPVA/FS) was prepared via a quaternization process and solution casting method. The physico-chemical properties of the QPVA/FS membrane were investigated. Its high ionic conductivity was found to depend greatly on the concentration of fumed silica in the QPVA matrix. A maximum conductivity of 3.50 × 10 −2 S/cm was obtained for QPVA/5%FS at 60 °C when it was doped with 6 M KOH. The permeabilities of methanol and ethanol were reduced with increasing fumed silica content. Cell voltage and peak power density were analyzed as functions of fumed silica concentration, temperature, methanol and ethanol concentrations. A maximum power density of 96.8 mW/cm 2 was achieved with QPVA/5%FS electrolyte using 2 M methanol + 6 M KOH as fuel at 80 °C. A peak power density of 79 mW/cm 2 was obtained using the QPVA/5%FS electrolyte with 3 M ethanol + 5 M KOH as fuel. The resulting peak power densities are higher than the majority of published reports. The results confirm that QPVA/FS exhibits promise as a future polymeric electrolyte for use in direct alkaline alcoholic fuel cells.

Suggested Citation

  • Selvaraj Rajesh Kumar & Cheng-Hsin Juan & Guan-Ming Liao & Jia-Shiun Lin & Chun-Chen Yang & Wei-Ting Ma & Jiann-Hua You & Shingjiang Jessie Lue, 2015. "Fumed Silica Nanoparticles Incorporated in Quaternized Poly(Vinyl Alcohol) Nanocomposite Membrane for Enhanced Power Densities in Direct Alcohol Alkaline Fuel Cells," Energies, MDPI, vol. 9(1), pages 1-19, December.
    • Handle: RePEc:gam:jeners:v:9:y:2015:i:1:p:15-:d:61353
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/9/1/15/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/9/1/15/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. An, L. & Zhao, T.S. & Li, Y.S., 2015. "Carbon-neutral sustainable energy technology: Direct ethanol fuel cells," Renewable and Sustainable Energy Reviews, Elsevier, vol. 50(C), pages 1462-1468.
    2. Eileen Hao Yu & Ulrike Krewer & Keith Scott, 2010. "Principles and Materials Aspects of Direct Alkaline Alcohol Fuel Cells," Energies, MDPI, vol. 3(8), pages 1-30, August.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Jia-Shuin Lin & Wei-Ting Ma & Chao-Ming Shih & Bor-Chern Yu & Li-Wei Teng & Yi-Chun Wang & Kong-Wei Cheng & Fang-Chyou Chiu & Shingjiang Jessie Lue, 2016. "Reorientation of Magnetic Graphene Oxide Nanosheets in Crosslinked Quaternized Polyvinyl Alcohol as Effective Solid Electrolyte," Energies, MDPI, vol. 9(12), pages 1-13, November.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Hosseini, Mir Ghasem & Mahmoodi, Raana & Daneshvari-Esfahlan, Vahid, 2018. "Ni@Pd core-shell nanostructure supported on multi-walled carbon nanotubes as efficient anode nanocatalysts for direct methanol fuel cells with membrane electrode assembly prepared by catalyst coated m," Energy, Elsevier, vol. 161(C), pages 1074-1084.
    2. Michaela Roschger & Sigrid Wolf & Boštjan Genorio & Viktor Hacker, 2022. "Effect of PdNiBi Metal Content: Cost Reduction in Alkaline Direct Ethanol Fuel Cells," Sustainability, MDPI, vol. 14(22), pages 1-15, November.
    3. Yu, Bor-Chern & Wang, Yi-Chun & Lu, Hsin-Chun & Lin, Hsiu-Li & Shih, Chao-Ming & Kumar, S. Rajesh & Lue, Shingjiang Jessie, 2017. "Hydroxide-ion selective electrolytes based on a polybenzimidazole/graphene oxide composite membrane," Energy, Elsevier, vol. 134(C), pages 802-812.
    4. Hegazy Rezk & A. G. Olabi & Tabbi Wilberforce & Enas Taha Sayed, 2023. "A Comprehensive Review and Application of Metaheuristics in Solving the Optimal Parameter Identification Problems," Sustainability, MDPI, vol. 15(7), pages 1-24, March.
    5. Ke, Yuzhi & Yuan, Wei & Zhou, Feikun & Guo, Wenwen & Li, Jinguang & Zhuang, Ziyi & Su, Xiaoqing & Lu, Biaowu & Zhao, Yonghao & Tang, Yong & Chen, Yu & Song, Jianli, 2021. "A critical review on surface-pattern engineering of nafion membrane for fuel cell applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 145(C).
    6. Osmieri, Luigi & Escudero-Cid, Ricardo & Monteverde Videla, Alessandro H.A. & Ocón, Pilar & Specchia, Stefania, 2018. "Application of a non-noble Fe-N-C catalyst for oxygen reduction reaction in an alkaline direct ethanol fuel cell," Renewable Energy, Elsevier, vol. 115(C), pages 226-237.
    7. Nandan, Ravi & Goswami, Gopal Krishna & Nanda, Karuna Kar, 2017. "Direct synthesis of Pt-free catalyst on gas diffusion layer of fuel cell and usage of high boiling point fuels for efficient utilization of waste heat," Applied Energy, Elsevier, vol. 205(C), pages 1050-1058.
    8. Kiyani, Roya & Rowshanzamir, Soosan & Parnian, Mohammad Javad, 2016. "Nitrogen doped graphene supported palladium-cobalt as a promising catalyst for methanol oxidation reaction: Synthesis, characterization and electrocatalytic performance," Energy, Elsevier, vol. 113(C), pages 1162-1173.
    9. D.M.F. Santos & J.R.B. Lourenço & D. Macciò & A. Saccone & C.A.C. Sequeira & J.L. Figueiredo, 2020. "Ethanol Electrooxidation at Platinum-Rare Earth (RE = Ce, Sm, Ho, Dy) Binary Alloys," Energies, MDPI, vol. 13(7), pages 1-21, April.
    10. Mendiburu, Andrés Z. & Lauermann, Carlos H. & Hayashi, Thamy C. & Mariños, Diego J. & Rodrigues da Costa, Roberto Berlini & Coronado, Christian J.R. & Roberts, Justo J. & de Carvalho, João A., 2022. "Ethanol as a renewable biofuel: Combustion characteristics and application in engines," Energy, Elsevier, vol. 257(C).
    11. Sánchez-Monreal, Juan & García-Salaberri, Pablo A. & Vera, Marcos, 2019. "A mathematical model for direct ethanol fuel cells based on detailed ethanol electro-oxidation kinetics," Applied Energy, Elsevier, vol. 251(C), pages 1-1.
    12. Pan, Zhefei & Bi, Yanding & An, Liang, 2019. "Performance characteristics of a passive direct ethylene glycol fuel cell with hydrogen peroxide as oxidant," Applied Energy, Elsevier, vol. 250(C), pages 846-854.
    13. Deva Harsha Perugupalli & Tao Xu & Kyu Taek Cho, 2019. "Activation of Carbon Porous Paper for Alkaline Alcoholic Fuel Cells," Energies, MDPI, vol. 12(17), pages 1-12, August.
    14. Radenahmad, Nikdalila & Afif, Ahmed & Petra, Pg Iskandar & Rahman, Seikh M.H. & Eriksson, Sten-G. & Azad, Abul K., 2016. "Proton-conducting electrolytes for direct methanol and direct urea fuel cells – A state-of-the-art review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 57(C), pages 1347-1358.
    15. Benipal, Neeva & Qi, Ji & Gentile, Jacob C. & Li, Wenzhen, 2017. "Direct glycerol fuel cell with polytetrafluoroethylene (PTFE) thin film separator," Renewable Energy, Elsevier, vol. 105(C), pages 647-655.
    16. An, L. & Jung, C.Y., 2017. "Transport phenomena in direct borohydride fuel cells," Applied Energy, Elsevier, vol. 205(C), pages 1270-1282.
    17. Wu, Q.X. & Pan, Z.F. & An, L., 2018. "Recent advances in alkali-doped polybenzimidazole membranes for fuel cell applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 89(C), pages 168-183.
    18. Luque-Centeno, J.M. & Martínez-Huerta, M.V. & Sebastián, D. & Lemes, G. & Pastor, E. & Lázaro, M.J., 2018. "Bifunctional N-doped graphene Ti and Co nanocomposites for the oxygen reduction and evolution reactions," Renewable Energy, Elsevier, vol. 125(C), pages 182-192.
    19. Johannes Kiefer, 2015. "Recent Advances in the Characterization of Gaseous and Liquid Fuels by Vibrational Spectroscopy," Energies, MDPI, vol. 8(4), pages 1-33, April.
    20. Gentil, Tuani C. & Pinheiro, Victor S. & Souza, Felipe M. & de Araújo, Marcos L. & Mandelli, Dalmo & Batista, Bruno L. & dos Santos, Mauro C., 2021. "Acetol as a high-performance molecule for oxidation in alkaline direct liquid fuel cell," Renewable Energy, Elsevier, vol. 165(P1), pages 37-42.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:9:y:2015:i:1:p:15-:d:61353. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.