IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v183y2019icp1266-1277.html
   My bibliography  Save this article

Recovery of waste-derived and low-grade components within fuel slurries

Author

Listed:
  • Vershinina, K.Yu.
  • Shlegel, N.E.
  • Strizhak, P.A.

Abstract

The article considers the involvement of combustible waste in the energy sector as the main and additional components of slurry fuels for burning in boilers. Five compositions of waste-derived slurries have been developed based on the analysis of ignition and combustion characteristics of nine components. For these compositions, the values of ignition delay, minimum ignition temperature, maximum burning temperature, SOx and NOx concentrations have been determined. The efficiency indicators of the slurries have been calculated in comparison with coal and fuel oil. The relative values take into account combustion heat, cost, ash content, ignition delay, minimum ignition temperature, maximum combustion temperature, and emissions. The most attractive fuel has been identified: 20 wt% of coal slime, 30 wt% of coal flotation waste, 40 wt% of wastewater, and 10 wt% of peat. On the aggregate indicator, this fuel surpasses coal 2.11 times and fuel oil – 11.9 times. All investigated water-containing fuels turned out to be less dangerous on environmental indicators than coal dust. In particular, SOx and NOx emissions were 1.2–3.8 times lower in comparison with coal. Using the example of a typical coal-fired boiler, an assessment was made of the potential reduction in fuel purchase costs, as well as savings in water treatment.

Suggested Citation

  • Vershinina, K.Yu. & Shlegel, N.E. & Strizhak, P.A., 2019. "Recovery of waste-derived and low-grade components within fuel slurries," Energy, Elsevier, vol. 183(C), pages 1266-1277.
    • Handle: RePEc:eee:energy:v:183:y:2019:i:c:p:1266-1277
    DOI: 10.1016/j.energy.2019.07.031
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S036054421931357X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2019.07.031?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Sami Alpanda & Adrian Peralta-Alva, 2010. "Oil Crisis, Energy-Saving Technological Change and the Stock Market Crash of 1973-74," Review of Economic Dynamics, Elsevier for the Society for Economic Dynamics, vol. 13(4), pages 824-842, October.
    2. Kumar, Abhishek & Sah, Bikash & Singh, Arvind R. & Deng, Yan & He, Xiangning & Kumar, Praveen & Bansal, R.C., 2017. "A review of multi criteria decision making (MCDM) towards sustainable renewable energy development," Renewable and Sustainable Energy Reviews, Elsevier, vol. 69(C), pages 596-609.
    3. Zhu, Mingming & Zhang, Zhezi & Zhang, Yang & Liu, Pengfei & Zhang, Dongke, 2017. "An experimental investigation into the ignition and combustion characteristics of single droplets of biochar water slurry fuels in air," Applied Energy, Elsevier, vol. 185(P2), pages 2160-2167.
    4. Setyawan, Hendrix Y. & Zhu, Mingming & Zhang, Zhezi & Zhang, Dongke, 2016. "Ignition and combustion characteristics of single droplets of a crude glycerol in comparison with pure glycerol, petroleum diesel, biodiesel and ethanol," Energy, Elsevier, vol. 113(C), pages 153-159.
    5. Tyagi, Vinay Kumar & Lo, Shang-Lien, 2013. "Sludge: A waste or renewable source for energy and resources recovery?," Renewable and Sustainable Energy Reviews, Elsevier, vol. 25(C), pages 708-728.
    6. Sever Akdağ, Ayşe & Atak, Onur & Atimtay, Aysel T. & Sanin, Faika Dilek, 2018. "Co-combustion of sewage sludge from different treatment processes and a lignite coal in a laboratory scale combustor," Energy, Elsevier, vol. 158(C), pages 417-426.
    7. Antonov, Dmitri V. & Valiullin, Timur R. & Iegorov, Roman I. & Strizhak, Pavel A., 2017. "Effect of macroscopic porosity onto the ignition of the waste-derived fuel droplets," Energy, Elsevier, vol. 119(C), pages 1152-1158.
    8. Sekar, Aiswarya Devi & Jayabalan, Tamilmani & Muthukumar, Harshiny & Chandrasekaran, Nivedhini Iswarya & Mohamed, Samsudeen Naina & Matheswaran, Manickam, 2019. "Enhancing power generation and treatment of dairy waste water in microbial fuel cell using Cu-doped iron oxide nanoparticles decorated anode," Energy, Elsevier, vol. 172(C), pages 173-180.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Kuznetsov, G.V. & Malyshev, D. Yu & Kostoreva, Zh.A. & Syrodoy, S.V. & Gutareva, N. Yu., 2020. "The ignition of the bio water-coal fuel particles based on coals of different degree metamorphism," Energy, Elsevier, vol. 201(C).
    2. Dorokhov, V.V. & Kuznetsov, G.V. & Vershinina, K.Yu. & Strizhak, P.A., 2021. "Relative energy efficiency indicators calculated for high-moisture waste-based fuel blends using multiple-criteria decision-making," Energy, Elsevier, vol. 234(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Dmitrii Antonov & Olga Gaidukova & Galina Nyashina & Dmitrii Razumov & Pavel Strizhak, 2022. "Prospects of Using Gas Hydrates in Power Plants," Energies, MDPI, vol. 15(12), pages 1-20, June.
    2. Zhang, Jianan & Wang, Yuesen & Muldoon, Valerie L. & Deng, Sili, 2022. "Crude glycerol and glycerol as fuels and fuel additives in combustion applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 159(C).
    3. Wang, Jigang & Qiao, Xinqi & Ju, Dehao & Wang, Lintao & Sun, Chunhua, 2019. "Experimental study on the evaporation and micro-explosion characteristics of nanofuel droplet at dilute concentrations," Energy, Elsevier, vol. 183(C), pages 149-159.
    4. Zhang, Yu & Huang, Ronghua & Huang, Yuhan & Huang, Sheng & Ma, Yinjie & Xu, Shijie & Zhou, Pei, 2018. "Effect of ambient temperature on the puffing characteristics of single butanol-hexadecane droplet," Energy, Elsevier, vol. 145(C), pages 430-441.
    5. Huang, Qian & Xu, Jiuping, 2020. "Bi-level multi-objective programming approach for carbon emission quota allocation towards co-combustion of coal and sewage sludge," Energy, Elsevier, vol. 211(C).
    6. Zhang, Yu & Huang, Ronghua & Chen, Xi & Qin, Tian & Huang, Sheng & Zhou, Pei & Lou, Chun, 2019. "Experimental study on auto-ignition characteristics of a butanol-hexadecane droplet under elevated pressures and temperatures," Energy, Elsevier, vol. 171(C), pages 654-665.
    7. Busola D. Akintayo & Oluwafemi E. Ige & Olubayo M. Babatunde & Oludolapo A. Olanrewaju, 2023. "Evaluation and Prioritization of Power-Generating Systems Using a Life Cycle Assessment and a Multicriteria Decision-Making Approach," Energies, MDPI, vol. 16(18), pages 1-18, September.
    8. Wu, Zhangsheng & Li, Yue & Wang, Rong & Xu, Xu & Ren, Dongyang & Huang, Quanzhong & Xiong, Yunwu & Huang, Guanhua, 2023. "Evaluation of irrigation water saving and salinity control practices of maize and sunflower in the upper Yellow River basin with an agro-hydrological model based method," Agricultural Water Management, Elsevier, vol. 278(C).
    9. Claire Villette & Loïc Maurer & Julie Zumsteg & Jérôme Mutterer & Adrien Wanko & Dimitri Heintz, 2023. "Mass spectrometry imaging for biosolids characterization to assess ecological or health risks before reuse," Nature Communications, Nature, vol. 14(1), pages 1-13, December.
    10. Vlachokostas, Ch. & Michailidou, A.V. & Achillas, Ch., 2021. "Multi-Criteria Decision Analysis towards promoting Waste-to-Energy Management Strategies: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 138(C).
    11. Zhang, Tianyu & Dong, Peiwu & Zeng, Yongchao & Ju, Yanbing, 2022. "Analyzing the diffusion of competitive smart wearable devices: An agent-based multi-dimensional relative agreement model," Journal of Business Research, Elsevier, vol. 139(C), pages 90-105.
    12. Tan, R.R. & Aviso, K.B. & Ng, D.K.S., 2019. "Optimization models for financing innovations in green energy technologies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 113(C), pages 1-1.
    13. Behroozeh, Samira & Hayati, Dariush & Karami, Ezatollah, 2022. "Determining and validating criteria to measure energy consumption sustainability in agricultural greenhouses," Technological Forecasting and Social Change, Elsevier, vol. 185(C).
    14. Misyura, S.Y., 2019. "Non-stationary combustion of natural and artificial methane hydrate at heterogeneous dissociation," Energy, Elsevier, vol. 181(C), pages 589-602.
    15. Takeshi Niizeki, 2012. "Energy-Saving Technological Change in Japan," Global COE Hi-Stat Discussion Paper Series gd11-218, Institute of Economic Research, Hitotsubashi University.
    16. Yazid Dissou & Lilia Karnizova & Qian Sun, 2015. "Industry-level Econometric Estimates of Energy-Capital-Labor Substitution with a Nested CES Production Function," Atlantic Economic Journal, Springer;International Atlantic Economic Society, vol. 43(1), pages 107-121, March.
    17. Meng, Xiangmei & de Jong, Wiebren & Kudra, Tadeusz, 2016. "A state-of-the-art review of pulse combustion: Principles, modeling, applications and R&D issues," Renewable and Sustainable Energy Reviews, Elsevier, vol. 55(C), pages 73-114.
    18. Muhammad Riaz & Wojciech Sałabun & Hafiz Muhammad Athar Farid & Nawazish Ali & Jarosław Wątróbski, 2020. "A Robust q-Rung Orthopair Fuzzy Information Aggregation Using Einstein Operations with Application to Sustainable Energy Planning Decision Management," Energies, MDPI, vol. 13(9), pages 1-39, May.
    19. Shahbeig, Hossein & Nosrati, Mohsen, 2020. "Pyrolysis of municipal sewage sludge for bioenergy production: Thermo-kinetic studies, evolved gas analysis, and techno-socio-economic assessment," Renewable and Sustainable Energy Reviews, Elsevier, vol. 119(C).
    20. Arbulú, Italo & Lozano, Javier & Rey-Maquieira, Javier, 2017. "The challenges of tourism to waste-to-energy public-private partnerships," Renewable and Sustainable Energy Reviews, Elsevier, vol. 72(C), pages 916-921.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:183:y:2019:i:c:p:1266-1277. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.