IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i16p5903-d1213989.html
   My bibliography  Save this article

Impact Assessment of Hydrate Cuttings Migration and Decomposition on Annular Temperature and Pressure in Deep Water Gas Hydrate Formation Riserless Drilling

Author

Listed:
  • Faling Yin

    (School of Petroleum Engineering, China University of Petroleum (East China), Qingdao 266580, China)

  • Xingyu Ni

    (CNPC Offshore Engineering Co., Ltd., Beijing 100028, China)

  • Jindong Han

    (CNPC Offshore Engineering Co., Ltd., Beijing 100028, China)

  • Jianwei Di

    (CNPC Offshore Engineering Co., Ltd., Beijing 100028, China)

  • Youwei Zhou

    (School of Petroleum Engineering, China University of Petroleum (East China), Qingdao 266580, China)

  • Xinxin Zhao

    (School of Petroleum Engineering, China University of Petroleum (East China), Qingdao 266580, China)

  • Yonghai Gao

    (School of Petroleum Engineering, China University of Petroleum (East China), Qingdao 266580, China
    Key Laboratory of Unconventional Oil & Gas Development, Ministry of Education, Qingdao 266580, China
    National Engineering Research Center for Oil & Gas Drilling and Completion Technology, Qingdao 266580, China)

Abstract

The accurate prediction of wellbore temperature and pressure is important for safe drilling. However, annulus temperature and pressure changes are more complicated due to phase transition. To study this problem, a prediction model of temperature and pressure in deep water riserless drilling is established by considering hydrate cuttings decomposition, interphase mass transfer, and phase transition heat. Based on this model, the effects of hydrate cuttings decomposition on the temperature and pressure of drilling in a hydrate reservoir are explored. The results show that the influence of hydrate cuttings decomposition increases significantly with an increase in the inlet temperature. The influence of hydrate cuttings decomposition on temperature and pressure decreases with an increase in displacement. A small range in the variation of density and penetration rates has little impact on the annulus pressure but mainly affects the temperature. The influence of hydrate cuttings decomposition increases with an increase in the penetration rate. In normal drilling conditions, hydrate cuttings decomposition has little impact on annulus temperature and pressure, but under the conditions of a high inlet temperature, high hydrate saturation, low displacement, and high penetration rate, it is necessary to consider the impact of hydrate cuttings decomposition. This study can provide reference for the prediction of temperature and pressure in deep water hydrate reservoir riserless drilling.

Suggested Citation

  • Faling Yin & Xingyu Ni & Jindong Han & Jianwei Di & Youwei Zhou & Xinxin Zhao & Yonghai Gao, 2023. "Impact Assessment of Hydrate Cuttings Migration and Decomposition on Annular Temperature and Pressure in Deep Water Gas Hydrate Formation Riserless Drilling," Energies, MDPI, vol. 16(16), pages 1-17, August.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:16:p:5903-:d:1213989
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/16/5903/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/16/5903/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Yuan, Qing & Sun, Chang-Yu & Yang, Xin & Ma, Ping-Chuan & Ma, Zheng-Wei & Liu, Bei & Ma, Qing-Lan & Yang, Lan-Ying & Chen, Guang-Jin, 2012. "Recovery of methane from hydrate reservoir with gaseous carbon dioxide using a three-dimensional middle-size reactor," Energy, Elsevier, vol. 40(1), pages 47-58.
    2. Boris V. Malozyomov & Nikita V. Martyushev & Vladislav V. Kukartsev & Vadim S. Tynchenko & Vladimir V. Bukhtoyarov & Xiaogang Wu & Yadviga A. Tyncheko & Viktor A. Kukartsev, 2023. "Overview of Methods for Enhanced Oil Recovery from Conventional and Unconventional Reservoirs," Energies, MDPI, vol. 16(13), pages 1-48, June.
    3. Wang, Bin & Fan, Zhen & Wang, Pengfei & Liu, Yu & Zhao, Jiafei & Song, Yongchen, 2018. "Analysis of depressurization mode on gas recovery from methane hydrate deposits and the concomitant ice generation," Applied Energy, Elsevier, vol. 227(C), pages 624-633.
    4. Yin, Faling & Gao, Yonghai & Zhang, Heen & Sun, Baojiang & Chen, Ye & Gao, Dongzhi & Zhao, Xinxin, 2022. "Comprehensive evaluation of gas production efficiency and reservoir stability of horizontal well with different depressurization methods in low permeability hydrate reservoir," Energy, Elsevier, vol. 239(PE).
    5. Yin, Faling & Gao, Yonghai & Chen, Ye & Sun, Baojiang & Li, Shaoqiang & Zhao, Danshi, 2022. "Numerical investigation on the long-term production behavior of horizontal well at the gas hydrate production site in South China Sea," Applied Energy, Elsevier, vol. 311(C).
    6. Zhao, Jiafei & Liu, Yulong & Guo, Xianwei & Wei, Rupeng & Yu, Tianbo & Xu, Lei & Sun, Lingjie & Yang, Lei, 2020. "Gas production behavior from hydrate-bearing fine natural sediments through optimized step-wise depressurization," Applied Energy, Elsevier, vol. 260(C).
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Vladimir Brigida & Vladimir Ivanovich Golik & Elena V. Voitovich & Vladislav V. Kukartsev & Valeriy E. Gozbenko & Vladimir Yu. Konyukhov & Tatiana A. Oparina, 2024. "Technogenic Reservoirs Resources of Mine Methane When Implementing the Circular Waste Management Concept," Resources, MDPI, vol. 13(2), pages 1-14, February.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Guan, Dawei & Qu, Aoxing & Gao, Peng & Fan, Qi & Li, Qingping & Zhang, Lunxiang & Zhao, Jiafei & Song, Yongchen & Yang, Lei, 2023. "Improved temperature distribution upon varying gas producing channel in gas hydrate reservoir: Insights from the Joule-Thomson effect," Applied Energy, Elsevier, vol. 348(C).
    2. Ouyang, Qian & Pandey, Jyoti Shanker & von Solms, Nicolas, 2022. "Insights into multistep depressurization of CH4/CO2 mixed hydrates in unconsolidated sediments," Energy, Elsevier, vol. 260(C).
    3. Yin, Faling & Gao, Yonghai & Chen, Ye & Sun, Baojiang & Li, Shaoqiang & Zhao, Danshi, 2022. "Numerical investigation on the long-term production behavior of horizontal well at the gas hydrate production site in South China Sea," Applied Energy, Elsevier, vol. 311(C).
    4. Gu, Yuhang & Sun, Jiaxin & Qin, Fanfan & Ning, Fulong & Cao, Xinxin & Liu, Tianle & Qin, Shunbo & Zhang, Ling & Jiang, Guosheng, 2023. "Enhancing gas recovery from natural gas hydrate reservoirs in the eastern Nankai Trough: Deep depressurization and underburden sealing," Energy, Elsevier, vol. 262(PB).
    5. Wei, Rupeng & Xia, Yongqiang & Wang, Zifei & Li, Qingping & Lv, Xin & Leng, Shudong & Zhang, Lunxiang & Zhang, Yi & Xiao, Bo & Yang, Shengxiong & Yang, Lei & Zhao, Jiafei & Song, Yongchen, 2022. "Long-term numerical simulation of a joint production of gas hydrate and underlying shallow gas through dual horizontal wells in the South China Sea," Applied Energy, Elsevier, vol. 320(C).
    6. Yu, Tao & Guan, Guoqing & Wang, Dayong & Song, Yongchen & Abudula, Abuliti, 2021. "Numerical investigation on the long-term gas production behavior at the 2017 Shenhu methane hydrate production site," Applied Energy, Elsevier, vol. 285(C).
    7. Guan, Dawei & Qu, Aoxing & Wang, Zifei & Lv, Xin & Li, Qingping & Leng, Shudong & Xiao, Bo & Zhang, Lunxiang & Zhao, Jiafei & Yang, Lei & Song, Yongchen, 2023. "Fluid flow-induced fine particle migration and its effects on gas and water production behavior from gas hydrate reservoir," Applied Energy, Elsevier, vol. 331(C).
    8. Zhao, Ermeng & Hou, Jian & Liu, Yongge & Ji, Yunkai & Liu, Wenbin & Lu, Nu & Bai, Yajie, 2020. "Enhanced gas production by forming artificial impermeable barriers from unconfined hydrate deposits in Shenhu area of South China sea," Energy, Elsevier, vol. 213(C).
    9. He, Juan & Li, Xiaosen & Chen, Zhaoyang & You, Changyu & Peng, Hao & Zhang, Zhiwen, 2022. "Sustainable hydrate production using intermittent depressurization in hydrate-bearing reservoirs connected with water layers," Energy, Elsevier, vol. 238(PA).
    10. Guo, Xianwei & Xu, Lei & Wang, Bin & Sun, Lingjie & Liu, Yulong & Wei, Rupeng & Yang, Lei & Zhao, Jiafei, 2020. "Optimized gas and water production from water-saturated hydrate-bearing sediment through step-wise depressurization combined with thermal stimulation," Applied Energy, Elsevier, vol. 276(C).
    11. Chu, Jiawei & Liu, Yu & Lv, Xin & Li, Qingping & Dong, Hongsheng & Song, Yongchen & Zhao, Jiafei, 2021. "Experimental investigation on blockage predictions in gas pipelines using the pressure pulse wave method," Energy, Elsevier, vol. 230(C).
    12. Tsypkin, G.G., 2021. "Analytical study of CO2–CH4 exchange in hydrate at high rates of carbon dioxide injection into a reservoir saturated with methane hydrate and gaseous methane," Energy, Elsevier, vol. 233(C).
    13. Sergei Sabanov & Abdullah Rasheed Qureshi & Zhaudir Dauitbay & Gulim Kurmangazy, 2023. "A Method for the Modified Estimation of Oil Shale Mineable Reserves for Shale Oil Projects: A Case Study," Energies, MDPI, vol. 16(16), pages 1, August.
    14. Nikita V. Martyushev & Boris V. Malozyomov & Svetlana N. Sorokova & Egor A. Efremenkov & Denis V. Valuev & Mengxu Qi, 2023. "Review Models and Methods for Determining and Predicting the Reliability of Technical Systems and Transport," Mathematics, MDPI, vol. 11(15), pages 1-31, July.
    15. Li, Bo & Zhang, Ting-Ting & Wan, Qing-Cui & Feng, Jing-Chun & Chen, Ling-Ling & Wei, Wen-Na, 2021. "Kinetic study of methane hydrate development involving the role of self-preservation effect in frozen sandy sediments," Applied Energy, Elsevier, vol. 300(C).
    16. Cheng, Fanbao & Sun, Xiang & Li, Yanghui & Ju, Xin & Yang, Yaobin & Liu, Xuanji & Liu, Weiguo & Yang, Mingjun & Song, Yongchen, 2023. "Numerical analysis of coupled thermal-hydro-chemo-mechanical (THCM) behavior to joint production of marine gas hydrate and shallow gas," Energy, Elsevier, vol. 281(C).
    17. Zhong, Jin-Rong & Sun, Yi-Fei & Li, Wen-Zhi & Xie, Yan & Chen, Guang-Jin & Sun, Chang-Yu & Yang, Lan-Ying & Qin, Hui-Bo & Pang, Wei-Xin & Li, Qing-Ping, 2019. "Structural transition range of methane-ethane gas hydrates during decomposition below ice point," Applied Energy, Elsevier, vol. 250(C), pages 873-881.
    18. Shi, Kangji & Wang, Zifei & Jia, Yuxin & Li, Qingping & Lv, Xin & Wang, Tian & Zhang, Lunxiang & Liu, Yu & Zhao, Jiafei & Song, Yongchen & Yang, Lei, 2022. "Effects of the vertical heterogeneity on the gas production behavior from hydrate reservoirs simulated by the fine sediments from the South China Sea," Energy, Elsevier, vol. 255(C).
    19. Wu, Zhaoran & Liu, Weiguo & Zheng, Jianan & Li, Yanghui, 2020. "Effect of methane hydrate dissociation and reformation on the permeability of clayey sediments," Applied Energy, Elsevier, vol. 261(C).
    20. Zhao, Jiafei & Yu, Tao & Song, Yongchen & Liu, Di & Liu, Weiguo & Liu, Yu & Yang, Mingjun & Ruan, Xuke & Li, Yanghui, 2013. "Numerical simulation of gas production from hydrate deposits using a single vertical well by depressurization in the Qilian Mountain permafrost, Qinghai-Tibet Plateau, China," Energy, Elsevier, vol. 52(C), pages 308-319.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:16:p:5903-:d:1213989. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.