IDEAS home Printed from https://ideas.repec.org/a/eee/agiwat/v266y2022ics037837742200138x.html
   My bibliography  Save this article

Effect of different filter media on emitter clogging using reclaimed effluents

Author

Listed:
  • Duran-Ros, Miquel
  • Puig-Bargués, Jaume
  • Cufí, Sílvia
  • Solé-Torres, Carles
  • Arbat, Gerard
  • Pujol, Joan
  • Ramírez de Cartagena, Francisco

Abstract

Pressurized media filters are the most effective means of preventing emitter clogging when reclaimed effluents are used in drip irrigation systems. In these filters, water pollutants are retained in a granular bed, which needs to be replaced once its life span has been reached. Silica sand is the most common material used as a filtration bed, but the use of alternative materials which may improve filtration efficiency and reduce environmental impact, should be explored. Thus, the aim of this study was to compare the effect of two different granular media (silica sand and recycled glass) used in three filters with different underdrain designs (collector arms, inserted domes, and porous media) on emitter clogging. Experiments were carried out by filtering a reclaimed effluent for the duration of 1000 h for each filter and material. Four irrigation laterals 90 m in length with a 2.3 l/h pressure-compensating emitter placed every 0.40 m along the dripline were placed after each filter. Filter performances were continuously assessed while emitter discharges at 8 selected locations across the laterals were measured at the beginning, after 500 h, and at the end of the experiment. Filtration cycles lasted longer with recycled glass, but turbidity removal was affected by the combination of bed material and underdrain. Only after 1000 h of irrigation, was the discharge significantly lower for those emitters protected with porous underdrain using glass compared with sand. Emitter discharge was considerably reduced at the end of the lateral due to a higher number of completely clogged emitters at this location, but there were not significant differences between granular materials and filter designs. Overall, the results show that using recycled glass does not significantly increase emitter clogging compared with silica sand.

Suggested Citation

  • Duran-Ros, Miquel & Puig-Bargués, Jaume & Cufí, Sílvia & Solé-Torres, Carles & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2022. "Effect of different filter media on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 266(C).
    • Handle: RePEc:eee:agiwat:v:266:y:2022:i:c:s037837742200138x
    DOI: 10.1016/j.agwat.2022.107591
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S037837742200138X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.agwat.2022.107591?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Song, Peng & Li, Yunkai & Zhou, Bo & Zhou, Chunfa & Zhang, Zhijing & Li, Jiusheng, 2017. "Controlling mechanism of chlorination on emitter bio-clogging for drip irrigation using reclaimed water," Agricultural Water Management, Elsevier, vol. 184(C), pages 36-45.
    2. Oliver, M.M.H. & Hewa, G.A. & Pezzaniti, D., 2014. "Bio-fouling of subsurface type drip emitters applying reclaimed water under medium soil thermal variation," Agricultural Water Management, Elsevier, vol. 133(C), pages 12-23.
    3. Duran-Ros, M. & Puig-Bargués, J. & Arbat, G. & Barragán, J. & Cartagena, F. Ramírez de, 2009. "Effect of filter, emitter and location on clogging when using effluents," Agricultural Water Management, Elsevier, vol. 96(1), pages 67-79, January.
    4. Ravina, I. & Paz, E. & Sofer, Z. & Marm, A. & Schischa, A. & Sagi, G. & Yechialy, Z. & Lev, Y., 1997. "Control of clogging in drip irrigation with stored treated municipal sewage effluent," Agricultural Water Management, Elsevier, vol. 33(2-3), pages 127-137, June.
    5. Puig-Bargués, J. & Arbat, G. & Elbana, M. & Duran-Ros, M. & Barragán, J. & de Cartagena, F. Ramírez & Lamm, F.R., 2010. "Effect of flushing frequency on emitter clogging in microirrigation with effluents," Agricultural Water Management, Elsevier, vol. 97(6), pages 883-891, June.
    6. Mesquita, M. & Testezlaf, R. & Ramirez, J.C.S., 2012. "The effect of media bed characteristics and internal auxiliary elements on sand filter head loss," Agricultural Water Management, Elsevier, vol. 115(C), pages 178-185.
    7. Bové, Josep & Puig-Bargués, Jaume & Arbat, Gerard & Duran-Ros, Miquel & Pujol, Toni & Pujol, Joan & Ramírez de Cartagena, Francisco, 2017. "Development of a new underdrain for improving the efficiency of microirrigation sand media filters," Agricultural Water Management, Elsevier, vol. 179(C), pages 296-305.
    8. Espinosa-Tasón, Jaime & Berbel, Julio & Gutiérrez-Martín, Carlos, 2020. "Energized water: Evolution of water-energy nexus in the Spanish irrigated agriculture, 1950–2017," Agricultural Water Management, Elsevier, vol. 233(C).
    9. Solé-Torres, Carles & Puig-Bargués, Jaume & Duran-Ros, Miquel & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2019. "Effect of different sand filter underdrain designs on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 223(C), pages 1-1.
    10. Maestre-Valero, J.F. & Martínez-Alvarez, V., 2010. "Effects of drip irrigation systems on the recovery of dissolved oxygen from hypoxic water," Agricultural Water Management, Elsevier, vol. 97(11), pages 1806-1812, November.
    11. Zhang, Wenqian & Niu, Wenquan & Li, Guochun & Wang, Jie & Wang, Yanbang & Dong, Aihong, 2020. "Lateral inner environment changes and effects on emitter clogging risk for different irrigation times," Agricultural Water Management, Elsevier, vol. 233(C).
    12. Capra, A. & Scicolone, B., 2004. "Emitter and filter tests for wastewater reuse by drip irrigation," Agricultural Water Management, Elsevier, vol. 68(2), pages 135-149, August.
    13. Bucks, D. A. & Nakayama, F. S. & Gilbert, R. G., 1979. "Trickle irrigation water quality and preventive maintenance," Agricultural Water Management, Elsevier, vol. 2(2), pages 149-162, June.
    14. Zhou, Bo & Zhou, Hongxu & Puig-Bargués, Jaume & Li, Yunkai, 2019. "Using an anti-clogging relative index (CRI) to assess emitters rapidly for drip irrigation systems with multiple low-quality water sources," Agricultural Water Management, Elsevier, vol. 221(C), pages 270-278.
    15. Juana, Luis & Rodriguez-Sinobas, Leonor & Sanchez, Raul & Losada, Alberto, 2007. "Evaluation of drip irrigation: Selection of emitters and hydraulic characterization of trapezoidal units," Agricultural Water Management, Elsevier, vol. 90(1-2), pages 13-26, May.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Miquel Duran-Ros & Joan Pujol & Toni Pujol & Sílvia Cufí & Gerard Arbat & Francisco Ramírez de Cartagena & Jaume Puig-Bargués, 2023. "Solid Removal across the Bed Depth in Media Filters for Drip Irrigation Systems," Agriculture, MDPI, vol. 13(2), pages 1-14, February.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Solé-Torres, Carles & Puig-Bargués, Jaume & Duran-Ros, Miquel & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2019. "Effect of different sand filter underdrain designs on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 223(C), pages 1-1.
    2. Han, Siqi & Li, Yunkai & Zhou, Bo & Liu, Zeyuan & Feng, Ji & Xiao, Yang, 2019. "An in-situ accelerated experimental testing method for drip irrigation emitter clogging with inferior water," Agricultural Water Management, Elsevier, vol. 212(C), pages 136-154.
    3. Petit, Julien & García, Sílvia Mas & Molle, Bruno & Bendoula, Ryad & Ait-Mouheb, Nassim, 2022. "Methods for drip irrigation clogging detection, analysis and understanding: State of the art and perspectives," Agricultural Water Management, Elsevier, vol. 272(C).
    4. Oliver, M.M.H. & Hewa, G.A. & Pezzaniti, D., 2014. "Bio-fouling of subsurface type drip emitters applying reclaimed water under medium soil thermal variation," Agricultural Water Management, Elsevier, vol. 133(C), pages 12-23.
    5. do Amaral, Marcos Antonio Correa Matos & Coelho, Rubens Duarte & de Oliveira Costa, Jéfferson & de Sousa Pereira, Diego José & de Camargo, Antonio Pires, 2022. "Dripper clogging by soil particles entering lateral lines directly during irrigation network assembly in the field," Agricultural Water Management, Elsevier, vol. 273(C).
    6. Puig-Bargués, J. & Arbat, G. & Elbana, M. & Duran-Ros, M. & Barragán, J. & de Cartagena, F. Ramírez & Lamm, F.R., 2010. "Effect of flushing frequency on emitter clogging in microirrigation with effluents," Agricultural Water Management, Elsevier, vol. 97(6), pages 883-891, June.
    7. Arbat, G. & Pujol, T. & Puig-Bargués, J. & Duran-Ros, M. & Montoro, L. & Barragán, J. & Ramírez de Cartagena, F., 2013. "An experimental and analytical study to analyze hydraulic behavior of nozzle-type underdrains in porous media filters," Agricultural Water Management, Elsevier, vol. 126(C), pages 64-74.
    8. Liu, Haijun & Huang, Guanhua, 2009. "Laboratory experiment on drip emitter clogging with fresh water and treated sewage effluent," Agricultural Water Management, Elsevier, vol. 96(5), pages 745-756, May.
    9. Puig-Bargues, J. & Arbat, G. & Barragan, J. & Ramirez de Cartagena, F., 2005. "Hydraulic performance of drip irrigation subunits using WWTP effluents," Agricultural Water Management, Elsevier, vol. 77(1-3), pages 249-262, August.
    10. Song, Peng & Li, Yunkai & Zhou, Bo & Zhou, Chunfa & Zhang, Zhijing & Li, Jiusheng, 2017. "Controlling mechanism of chlorination on emitter bio-clogging for drip irrigation using reclaimed water," Agricultural Water Management, Elsevier, vol. 184(C), pages 36-45.
    11. Shen, Yan & Puig-Bargués, Jaume & Li, Mengyao & Xiao, Yang & Li, Qiang & Li, Yunkai, 2022. "Physical, chemical and biological emitter clogging behaviors in drip irrigation systems using high-sediment loaded water," Agricultural Water Management, Elsevier, vol. 270(C).
    12. Duran-Ros, M. & Puig-Bargués, J. & Arbat, G. & Barragán, J. & Cartagena, F. Ramírez de, 2009. "Effect of filter, emitter and location on clogging when using effluents," Agricultural Water Management, Elsevier, vol. 96(1), pages 67-79, January.
    13. Seyedzadeh, Amin & Maroufpoor, Saman & Maroufpoor, Eisa & Shiri, Jalal & Bozorg-Haddad, Omid & Gavazi, Farnoosh, 2020. "Artificial intelligence approach to estimate discharge of drip tape irrigation based on temperature and pressure," Agricultural Water Management, Elsevier, vol. 228(C).
    14. Miquel Duran-Ros & Joan Pujol & Toni Pujol & Sílvia Cufí & Gerard Arbat & Francisco Ramírez de Cartagena & Jaume Puig-Bargués, 2023. "Solid Removal across the Bed Depth in Media Filters for Drip Irrigation Systems," Agriculture, MDPI, vol. 13(2), pages 1-14, February.
    15. Muhammad, Tahir & Zhou, Bo & Puig-Bargu´es, Jaume & Ding, Can & Li, Shuqin & Manan, Irum & Zhou, Yunpeng & Liu, Zeyuan & Li, Yunkai, 2022. "Assessment of emitter clogging with multiple fouling and root intrusion in sub-surface drip irrigation during 5-year sugarcane growth," Agricultural Water Management, Elsevier, vol. 274(C).
    16. Zhang, Wenqian & Niu, Wenquan & Li, Guochun & Wang, Jie & Wang, Yanbang & Dong, Aihong, 2020. "Lateral inner environment changes and effects on emitter clogging risk for different irrigation times," Agricultural Water Management, Elsevier, vol. 233(C).
    17. Zhou, Bo & Li, Yunkai & Xue, Song & Feng, Ji, 2019. "Variation of microorganisms in drip irrigation systems using high-sand surface water," Agricultural Water Management, Elsevier, vol. 218(C), pages 37-47.
    18. Joan Pujol & Francesc X. Espinach & Miquel Duran-Ros & Gerard Arbat & Toni Pujol & Francisco Ramírez de Cartagena & Jaume Puig-Bargués, 2022. "Environmental Assessment of Underdrain Designs for Granular Media Filters in Drip Irrigation Systems," Agriculture, MDPI, vol. 12(6), pages 1-14, June.
    19. Zhou, Bo & Wang, Tianzhi & Li, Yunkai & Bralts, Vincent, 2017. "Effects of microbial community variation on bio-clogging in drip irrigation emitters using reclaimed water," Agricultural Water Management, Elsevier, vol. 194(C), pages 139-149.
    20. Zhou, Bo & Zhou, Hongxu & Puig-Bargués, Jaume & Li, Yunkai, 2019. "Using an anti-clogging relative index (CRI) to assess emitters rapidly for drip irrigation systems with multiple low-quality water sources," Agricultural Water Management, Elsevier, vol. 221(C), pages 270-278.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:agiwat:v:266:y:2022:i:c:s037837742200138x. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/locate/agwat .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.