IDEAS home Printed from https://ideas.repec.org/a/gam/jresou/v11y2022i12p108-d986237.html
   My bibliography  Save this article

Thermodynamics and Electrochemistry of the Interaction of Sphalerite with Iron (II)-Bearing Compounds in Relation to Flotation

Author

Listed:
  • Kyaw Zay Ya

    (Department of Mathematics, National University of Science and Technology “MISiS”, Leninsky Avenue, 4, 119991 Moscow, Russia)

  • Boris Goryachev

    (Department of Mathematics, National University of Science and Technology “MISiS”, Leninsky Avenue, 4, 119991 Moscow, Russia)

  • Arkadiy Adigamov

    (Department of Mathematics, National University of Science and Technology “MISiS”, Leninsky Avenue, 4, 119991 Moscow, Russia)

  • Karina Nurgalieva

    (Department of Development and Operation of Oil and Gas Fields, Saint-Petersburg Mining University, 21st Line, 2, 199106 St. Petersburg, Russia)

  • Igor Narozhnyy

    (Mining Oil and Gas Departmen, RUDN University, Miklukho-Maklaya, 6, 117198 Moscow, Russia)

Abstract

The flotation recovery of sphalerite depends on the inorganic reagents concentrations in the liquid phase of suspension and pH. This paper presents the results of studies of the interactions of iron (II) containing ions with the sphalerite surface in water solutions at different pH levels. The thermodynamic and electrochemical studies were carried out to analyze possible interactions of sphalerite with iron (II) sulfate in a water environment and relate them to sphalerite flotation with potassium butyl xanthate and sodium dibutyl dithiophosphate. The results of the thermodynamic calculations revealed the possibility of interaction of the sphalerite surface with iron (II) hydrolysis products. The effect of the hydroxide ions concentration on precipitation of iron (II) hydroxides was examined. The findings showed that at pH = 8 there were no precipitates observed in water solutions of FeSO 4 . Increasing pH of the solutions from 8 to 12 resulted in the formation of iron (II) hydroxides. The potentiometric studies revealed that in slightly alkaline solutions the Fe 2+ and FeOH + cations are potential-determining. In conclusion, the flotation tests with thiol collectors show the activation effect of iron (II) sulphate on sphalerite at low dosage and pH 12. This is evident by a higher flotation recovery of sphalerite at these conditions.

Suggested Citation

  • Kyaw Zay Ya & Boris Goryachev & Arkadiy Adigamov & Karina Nurgalieva & Igor Narozhnyy, 2022. "Thermodynamics and Electrochemistry of the Interaction of Sphalerite with Iron (II)-Bearing Compounds in Relation to Flotation," Resources, MDPI, vol. 11(12), pages 1-10, November.
    • Handle: RePEc:gam:jresou:v:11:y:2022:i:12:p:108-:d:986237
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2079-9276/11/12/108/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2079-9276/11/12/108/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Inzir Raupov & Ramis Burkhanov & Azat Lutfullin & Alexander Maksyutin & Andrey Lebedev & Elena Safiullina, 2022. "Experience in the Application of Hydrocarbon Optical Studies in Oil Field Development," Energies, MDPI, vol. 15(10), pages 1-18, May.
    2. Henrieta Pavolová & Katarína Čulková & Zuzana Šimková & Andrea Seňová & Dušan Kudelas, 2022. "Contribution of Mining Industry in Chosen EU Countries to the Sustainability Issues," Sustainability, MDPI, vol. 14(7), pages 1-13, March.
    3. George Buslaev & Pavel Tsvetkov & Alexander Lavrik & Andrey Kunshin & Elizaveta Loseva & Dmitry Sidorov, 2021. "Ensuring the Sustainability of Arctic Industrial Facilities under Conditions of Global Climate Change," Resources, MDPI, vol. 10(12), pages 1-15, December.
    4. Radel Sultanbekov & Ilia Beloglazov & Shamil Islamov & Muk Chen Ong, 2021. "Exploring of the Incompatibility of Marine Residual Fuel: A Case Study Using Machine Learning Methods," Energies, MDPI, vol. 14(24), pages 1-16, December.
    5. Cathryn Earl & Izhar Hussain Shah & Simon Cook & Christopher Robert Cheeseman, 2022. "Environmental Sustainability and Supply Resilience of Cobalt," Sustainability, MDPI, vol. 14(7), pages 1-10, March.
    6. Pavel Tcvetkov, 2021. "Climate Policy Imbalance in the Energy Sector: Time to Focus on the Value of CO 2 Utilization," Energies, MDPI, vol. 14(2), pages 1-22, January.
    7. Stavros Tomazinakis & George Valakas & Anna Gaki & Dimitrios Damigos & Katerina Adam, 2022. "The Importance and Challenges of Sustainable Development for the Raw Materials Sector: The Views of Key Stakeholders in Three ESEE Countries," Sustainability, MDPI, vol. 14(7), pages 1-17, March.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Vladimir I. Golik & Mikhail F. Mitsik & Yulia V. Aleksakhina & Elena E. Alenina & Natalia V. Ruban-Lazareva & Galina V. Kruzhkova & Olga A. Kondratyeva & Ekaterina V. Trushina & Oleg O. Skryabin & Mar, 2023. "Comprehensive Recovery of Metals in Tailings Utilization with Mechanochemical Activation," Resources, MDPI, vol. 12(10), pages 1-22, September.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Yuriy Zhukovskiy & Anastasia Koshenkova & Valeriya Vorobeva & Daniil Rasputin & Roman Pozdnyakov, 2023. "Assessment of the Impact of Technological Development and Scenario Forecasting of the Sustainable Development of the Fuel and Energy Complex," Energies, MDPI, vol. 16(7), pages 1-23, March.
    2. Yuriy Zhukovskiy & Pavel Tsvetkov & Aleksandra Buldysko & Yana Malkova & Antonina Stoianova & Anastasia Koshenkova, 2021. "Scenario Modeling of Sustainable Development of Energy Supply in the Arctic," Resources, MDPI, vol. 10(12), pages 1-25, December.
    3. Nan Li & Beibei Shi & Rong Kang, 2023. "Analysis of the Coupling Effect and Space-Time Difference between China’s Digital Economy Development and Carbon Emissions Reduction," IJERPH, MDPI, vol. 20(1), pages 1-25, January.
    4. Victor Duryagin & Thang Nguyen Van & Nikita Onegov & Galiya Shamsutdinova, 2022. "Investigation of the Selectivity of the Water Shutoff Technology," Energies, MDPI, vol. 16(1), pages 1-16, December.
    5. Emiliia Iakovleva & Daniel Guerra & Pavel Tcvetkov & Yaroslav Shklyarskiy, 2022. "Technical and Economic Analysis of Modernization of Solar Power Plant: A Case Study from the Republic of Cuba," Sustainability, MDPI, vol. 14(2), pages 1-23, January.
    6. Inzir Raupov & Mikhail Rogachev & Julia Sytnik, 2023. "Design of a Polymer Composition for the Conformance Control in Heterogeneous Reservoirs," Energies, MDPI, vol. 16(1), pages 1-18, January.
    7. Guo, Yaoqi & Li, Yingli & Liu, Yongheng & Zhang, Hongwei, 2023. "The impact of geopolitical relations on the evolution of cobalt trade network from the perspective of industrial chain," Resources Policy, Elsevier, vol. 85(PA).
    8. Agnieszka Sompolska-Rzechuła & Agnieszka Kurdyś-Kujawska, 2021. "Towards Understanding Interactions between Sustainable Development Goals: The Role of Climate-Well-Being Linkages. Experiences of EU Countries," Energies, MDPI, vol. 14(7), pages 1-20, April.
    9. Alexander Nikolaev & Kristina Plotnikova, 2023. "Study of the Rheological Properties and Flow Process of High-Viscosity Oil Using Depressant Additives," Energies, MDPI, vol. 16(17), pages 1-19, August.
    10. Victor I. Bolobov & Il’nur U. Latipov & Valentin S. Zhukov & Gregory G. Popov, 2023. "Using the Magnetic Anisotropy Method to Determine Hydrogenated Sections of a Steel Pipeline," Energies, MDPI, vol. 16(15), pages 1-15, July.
    11. Alexey Cherepovitsyn & Evgeniya Rutenko, 2022. "Strategic Planning of Oil and Gas Companies: The Decarbonization Transition," Energies, MDPI, vol. 15(17), pages 1-26, August.
    12. Alexander Lavrik & Yuri Zhukovskiy & Pavel Tcvetkov, 2021. "Optimizing the Size of Autonomous Hybrid Microgrids with Regard to Load Shifting," Energies, MDPI, vol. 14(16), pages 1-19, August.
    13. Ruslan Gizatullin & Mikhail Dvoynikov & Natalya Romanova & Victor Nikitin, 2023. "Drilling in Gas Hydrates: Managing Gas Appearance Risks," Energies, MDPI, vol. 16(5), pages 1-13, March.
    14. Nikolay Tsvetkov & Stanislav Boldyryev & Aleksandr Shilin & Yuriy Krivoshein & Aleksandr Tolstykh, 2022. "Hardware and Software Implementation for Solar Hot Water System in Northern Regions of Russia," Energies, MDPI, vol. 15(4), pages 1-18, February.
    15. Lucia Domaracká & Marcela Taušová & Katarína Čulková & Peter Tauš & Peter Gomboš, 2023. "Development of Greenhouse Gas Emission and Evaluation of Carbon Resource Use in Chosen EU Countries," Energies, MDPI, vol. 16(3), pages 1-17, January.
    16. Adam Sulich & Letycja Sołoducho-Pelc, 2022. "Changes in Energy Sector Strategies: A Literature Review," Energies, MDPI, vol. 15(19), pages 1-26, September.
    17. Natalia Romasheva & Diana Dmitrieva, 2021. "Energy Resources Exploitation in the Russian Arctic: Challenges and Prospects for the Sustainable Development of the Ecosystem," Energies, MDPI, vol. 14(24), pages 1-31, December.
    18. Vadim Fetisov & Adam M. Gonopolsky & Maria Yu. Zemenkova & Schipachev Andrey & Hadi Davardoost & Amir H. Mohammadi & Masoud Riazi, 2023. "On the Integration of CO 2 Capture Technologies for an Oil Refinery," Energies, MDPI, vol. 16(2), pages 1-19, January.
    19. Amanda Harker Steele & Travis Warner & Derek Vikara & Allison Guinan & Peter Balash, 2021. "Comparative Analysis of Carbon Capture and Storage Finance Gaps and the Social Cost of Carbon," Energies, MDPI, vol. 14(11), pages 1-24, May.
    20. Gulnur Zakirova & Vladimir Pshenin & Radmir Tashbulatov & Lyubov Rozanova, 2022. "Modern Bitumen Oil Mixture Models in Ashalchinsky Field with Low-Viscosity Solvent at Various Temperatures and Solvent Concentrations," Energies, MDPI, vol. 16(1), pages 1-18, December.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jresou:v:11:y:2022:i:12:p:108-:d:986237. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.