IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v148y2020icp889-896.html
   My bibliography  Save this article

Effect of basicity in the aqueous phase reforming of brewery wastewater for H2 production

Author

Listed:
  • Oliveira, A.S.
  • Baeza, J.A.
  • Garcia, D.
  • Saenz de Miera, B.
  • Calvo, L.
  • Rodriguez, J.J.
  • Gilarranz, M.A.

Abstract

Real (RBW) and synthetic brewery wastewater (SBW) were treated by aqueous phase reforming (APR) with different 3%Pt/C catalysts for H2 production from the biomass-derived organic load. APR enabled simultaneous treatment of the wastewater and valorisation to H2 and alkanes of the biomass-derived organic load. In the catalytic APR of SBW, TOC and COD removal was higher than 60% after reaction time of the experiments. The addition of KOH or NaOH to SBW resulted in a slightly lower TOC and COD removal, however higher yields to H2 and percentage of valuable gases were obtained in those cases where KOH was added. Catalyst with basic support and low contribution of micropores showed the best performance in the APR of SBW + KOH (∼50% of H2 and 8.9 mmol H2/g COD). The concentration of anions detected in the liquid effluents varied with the catalysts tested and with the concentration of base, suggesting different reaction pathways. Increasing the concentration of KOH led to CO2-free H2 without significant changes in H2 yield. The results obtained with RBW were in good agreement with those from SBW, although the significantly different behaviour of some catalysts suggests the need of tuning their properties according to the composition of the wastewater.

Suggested Citation

  • Oliveira, A.S. & Baeza, J.A. & Garcia, D. & Saenz de Miera, B. & Calvo, L. & Rodriguez, J.J. & Gilarranz, M.A., 2020. "Effect of basicity in the aqueous phase reforming of brewery wastewater for H2 production," Renewable Energy, Elsevier, vol. 148(C), pages 889-896.
    • Handle: RePEc:eee:renene:v:148:y:2020:i:c:p:889-896
    DOI: 10.1016/j.renene.2019.10.173
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148119316702
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2019.10.173?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Wang, Tengfei & Zhai, Yunbo & Zhu, Yun & Li, Caiting & Zeng, Guangming, 2018. "A review of the hydrothermal carbonization of biomass waste for hydrochar formation: Process conditions, fundamentals, and physicochemical properties," Renewable and Sustainable Energy Reviews, Elsevier, vol. 90(C), pages 223-247.
    2. R. D. Cortright & R. R. Davda & J. A. Dumesic, 2002. "Hydrogen from catalytic reforming of biomass-derived hydrocarbons in liquid water," Nature, Nature, vol. 418(6901), pages 964-967, August.
    3. Kim, Min-Cheol & Kim, Tae-Wan & Kim, Hyung Ju & Kim, Chul-Ung & Bae, Jong Wook, 2016. "Aqueous phase reforming of polyols for hydrogen production using supported PtFe bimetallic catalysts," Renewable Energy, Elsevier, vol. 95(C), pages 396-403.
    4. Shi, Xian-Yang & Jin, Da-Wei & Sun, Qing-Ye & Li, Wen-Wei, 2010. "Optimization of conditions for hydrogen production from brewery wastewater by anaerobic sludge using desirability function approach," Renewable Energy, Elsevier, vol. 35(7), pages 1493-1498.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Song, Weiming & Zhou, Jianan & Li, Yujie & Li, Shu & Yang, Jian, 2021. "Utilization of waste tire powder for gaseous fuel generation via CO2 gasification using waste heat in converter vaporization cooling flue," Renewable Energy, Elsevier, vol. 173(C), pages 283-296.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Bastan, Farzad & Kazemeini, Mohammad & Larimi, Afsaneh Sadat, 2017. "Aqueous-phase reforming of glycerol for production of alkanes over Ni/CexZr1-xO2 nano-catalyst: Effects of the support’s composition," Renewable Energy, Elsevier, vol. 108(C), pages 417-424.
    2. Xu, Chunping & Paone, Emilia & Rodríguez-Padrón, Daily & Luque, Rafael & Mauriello, Francesco, 2020. "Reductive catalytic routes towards sustainable production of hydrogen, fuels and chemicals from biomass derived polyols," Renewable and Sustainable Energy Reviews, Elsevier, vol. 127(C).
    3. Tiago Teribele & Maria Elizabeth Gemaque Costa & Conceição de Maria Sales da Silva & Lia Martins Pereira & Lucas Pinto Bernar & Douglas Alberto Rocha de Castro & Fernanda Paula da Costa Assunção & Mar, 2023. "Hydrothermal Carbonization of Corn Stover: Structural Evolution of Hydro-Char and Degradation Kinetics," Energies, MDPI, vol. 16(7), pages 1-22, April.
    4. Yevheniia Ziabina & Tetyana Pimonenko, 2020. "The Green Deal Policy for Renewable Energy: A Bibliometric Analysis," Virtual Economics, The London Academy of Science and Business, vol. 3(4), pages 147-168, October.
    5. Andrea G. Capodaglio & Gustaf Olsson, 2019. "Energy Issues in Sustainable Urban Wastewater Management: Use, Demand Reduction and Recovery in the Urban Water Cycle," Sustainability, MDPI, vol. 12(1), pages 1-17, December.
    6. Zhang, Zhikun & Zhu, Zongyuan & Shen, Boxiong & Liu, Lina, 2019. "Insights into biochar and hydrochar production and applications: A review," Energy, Elsevier, vol. 171(C), pages 581-598.
    7. Śliz, Maciej & Wilk, Małgorzata, 2020. "A comprehensive investigation of hydrothermal carbonization: Energy potential of hydrochar derived from Virginia mallow," Renewable Energy, Elsevier, vol. 156(C), pages 942-950.
    8. Aragón-Briceño, C.I. & Pozarlik, A.K. & Bramer, E.A. & Niedzwiecki, Lukasz & Pawlak-Kruczek, H. & Brem, G., 2021. "Hydrothermal carbonization of wet biomass from nitrogen and phosphorus approach: A review," Renewable Energy, Elsevier, vol. 171(C), pages 401-415.
    9. Feng, Junfeng & Yang, Zhongzhi & Hse, Chung-yun & Su, Qiuli & Wang, Kui & Jiang, Jianchun & Xu, Junming, 2017. "In situ catalytic hydrogenation of model compounds and biomass-derived phenolic compounds for bio-oil upgrading," Renewable Energy, Elsevier, vol. 105(C), pages 140-148.
    10. Shimaa M. Elsaeed & E. G. Zaki & Tarek M. Ibrahim & Nasser Ibrahim Talha & Hosam A. Saad & Adil A. Gobouri & Amr Elkelish & Salah Mohamed el-kousy, 2021. "Biochar Grafted on CMC-Terpolymer by Green Microwave Route for Sustainable Agriculture," Agriculture, MDPI, vol. 11(4), pages 1-16, April.
    11. Saba, N. & Jawaid, M. & Hakeem, K.R. & Paridah, M.T. & Khalina, A. & Alothman, O.Y., 2015. "Potential of bioenergy production from industrial kenaf (Hibiscus cannabinus L.) based on Malaysian perspective," Renewable and Sustainable Energy Reviews, Elsevier, vol. 42(C), pages 446-459.
    12. Leonel J. R. Nunes & Abel M. Rodrigues & João C. O. Matias & Ana I. Ferraz & Ana C. Rodrigues, 2021. "Production of Biochar from Vine Pruning: Waste Recovery in the Wine Industry," Agriculture, MDPI, vol. 11(6), pages 1-15, May.
    13. Neel Patel & Bishnu Acharya & Prabir Basu, 2021. "Hydrothermal Carbonization (HTC) of Seaweed (Macroalgae) for Producing Hydrochar," Energies, MDPI, vol. 14(7), pages 1-16, March.
    14. Xu, Zhi-Xiang & Song, Hao & Zhang, Shu & Tong, Si-Qi & He, Zhi-Xia & Wang, Qian & Li, Bin & Hu, Xun, 2019. "Co-hydrothermal carbonization of digested sewage sludge and cow dung biogas residue: Investigation of the reaction characteristics," Energy, Elsevier, vol. 187(C).
    15. Leng, Lijian & Li, Hui & Yuan, Xingzhong & Zhou, Wenguang & Huang, Huajun, 2018. "Bio-oil upgrading by emulsification/microemulsification: A review," Energy, Elsevier, vol. 161(C), pages 214-232.
    16. Ane Caroline Pereira Borges & Jude Azubuike Onwudili & Heloysa Andrade & Carine Alves & Andrew Ingram & Silvio Vieira de Melo & Ednildo Torres, 2020. "Catalytic Properties and Recycling of NiFe 2 O 4 Catalyst for Hydrogen Production by Supercritical Water Gasification of Eucalyptus Wood Chips," Energies, MDPI, vol. 13(17), pages 1-17, September.
    17. Yi Zhang & Mingting Kou & Kaihua Chen & Jiancheng Guan & Yuchen Li, 2016. "Modelling the Basic Research Competitiveness Index (BR-CI) with an application to the biomass energy field," Scientometrics, Springer;Akadémiai Kiadó, vol. 108(3), pages 1221-1241, September.
    18. Su, Hongcai & Yan, Mi & Wang, Shurong, 2022. "Recent advances in supercritical water gasification of biowaste catalyzed by transition metal-based catalysts for hydrogen production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 154(C).
    19. Guo, Y. & Wang, S.Z. & Xu, D.H. & Gong, Y.M. & Ma, H.H. & Tang, X.Y., 2010. "Review of catalytic supercritical water gasification for hydrogen production from biomass," Renewable and Sustainable Energy Reviews, Elsevier, vol. 14(1), pages 334-343, January.
    20. Khatun, Rahima & Reza, Mohammad Imam Hasan & Moniruzzaman, M. & Yaakob, Zahira, 2017. "Sustainable oil palm industry: The possibilities," Renewable and Sustainable Energy Reviews, Elsevier, vol. 76(C), pages 608-619.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:148:y:2020:i:c:p:889-896. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.